Brinly BB-56 Owner's manual

Brinly
Brand
Brinly
Model
BB-56
Type
Owner's manual
L-1434 Rev. B
Owner's Manual
42" Grader Blade
MODEL:
BB-56
• Assembly
• Installation
• Operation
• RepairParts
Recommended for use with Garden Tractors with Grader
Blade. Tire chains and wheel weights are recommended.
This manual contains information for the safety
of persons and property. Read it carefully before
assembly and operation of the equipment!
Visit us on the web!
www.brinly.com
For the latest product updates and setup tips:
IMPORTANT
L-1434 Rev. B
2
INTRODUCTION
SAFETY
CONGRATULATIONSonthepurchaseofyournewBrinly-HardyGrader
Blade!YourGraderBladeisdesigned,engineeredandmanufacturedto
giveyouthebestpossibledependabilityandperformance.
CUSTOMER RESPONSIBILITIES
Pleasereadandretainthismanual.Theinstructionsenablesyouto
assembleandmaintainyourGraderBladeproperly.Andplease,always
observethe“Safety”instructions.
TABLE OF CONTENTS
SAFETY......................................................................................... 2-3
PARTSBREAKDOWN................................................................. 4-5
ASSEMBLY................................................................................... 5-6
ADJUSTMENT..................................................................................7
OPERATIONANDMAINTENANCE.................................................7
WARRANTY......................................................................Backpage
PRODUCT COMPATIBILITY
ThisGraderBladeisdesignedforusewithgardentractorsequippedwith
SleeveHitch.Also,tirechainsandwheelweightsarerecommended.
RECORD PURCHASE INFORMATION
Recordyourpurchaseinformationinthespacesprovidedbelow:
DATEOFPURCHASE:
COMPANYNAME:
COMPANYPHONE:
SERIALNUMBER:
SAFETY LABELS
UNDERSTANDING THE MACHINE SAFETY LABELS:
Themachinesafetylabelsshowninthissectionareplacedinimportant
areasonyourmachinetodrawattentiontopotentialsafetyhazards.
Onyourmachinesafetylabels,thewordsDANGER,WARNING,and
CAUTIONareusedwiththissafety-alertsymbol.DANGERidentiesthe
mostserioushazards.
Theoperator'smanualalsoexplainsanypotentialsafetyhazards
whenevernecessaryinspecialsafetymessagesthatareidentiedwith
theword,CAUTION,andthesafety-alertsymbol.
SAFETY ALERT SYMBOL
L-1434 Rev. B
3
SAFETY
TO HELP PREVENT BODILY INJURY DUE TO LOSS
OF STABILITY OR CONTROL:
• Readthevehicle'sowner'smanual,yourtractor'sowner's
manual,andthisowner'smanualbeforeusingthis
GraderBlade.
• Knowcontrolsandhowtostopquickly.
• Donotallowchildrentooperatethevehicle,donotallow
adultstooperatewithoutproperinstructionandwithout
havingreadtheowner'smanual.
• Donotcarrypassengers.Keepchildrenandpetsasafe
distanceaway.
• Alwayswearsubstantialfootwear.Donotwearloose
ttingclothingthatcangetcaughtinmovingparts.
• Keepyoureyesandmindonyourtractor/attachmentand
areabeingcovered.Don'tletotherinterestsdistractyou.
• Stayalertforholesintheterrainandotherhidden
hazards.
• Keepthevehicleandattachmentsingoodoperating
conditionandkeepsafetydevicesinplace.
• Keepallnuts,boltsandscrewstighttobesurethe
equipmentisinsafeworkingcondition.
• Thevehicleandattachmentsshouldbestoppedand
inspectedfordamageafterstrikingaforeignobject.
Thedamageshouldberepairedbeforerestartingand
operatingtheequipment.
• Seetractorequipmentowner'smanualforsafeoperation
oftheequipment.
• Donotdriveclosetocreeks,ditchesandpublic
highways.
• Watchoutfortrafcwhencrossingornearroadways.
• Beforeloweringoroperatinganyattachments,ensure
bystandersarenotnearthevehicle.
• LowertheGraderBladeandimplementwhenleaving
vehicleunattended.
• Stoppingdistanceincreaseswithspeedandweight
ofattachment.Travelslowlyandallowextratimeand
distancetostop.
• Attachmentsintheraisedandloweredpositioncan
causelossoftractionandlossofcontrolonslopes.Stay
offsteepslopes.
SAFETY
Readthegeneralsafetyoperatingprecautionsinyourtowing
vehicleoperator'smanualforadditionalsafetyinformation.
PROTECT BYSTANDERS
• Keepbystandersawaywhenyouoperatethismachine.
Beforeyoubacklookcarefullybehindforbystanders.
• Beforeyouoperateanyfeatureofthismachine,observe
yoursurroundingsandlookforbystanders.
OPERATE SAFELY
• Usethismachineforintendedpurposeonly.
• Travelspeedshouldalwaysbeslowenoughtomaintain
control.Attachmentsinraisedandloweredpositioncan
changestabilityoftractor.
• Travelslowlyoverroughground.
• Donotletchildrenoranuntrainedpersonoperate
machine.
• Donotletanyone,especiallychildren,rideonthis
GraderBladeorthetowingvehicle.
• Checkvehiclebrakeactionbeforeyouoperate.Adjustor
servicebrakesasnecessary.
• Keepallpartsingoodconditionandproperlyinstalled.
Fixdamagedpartsimmediately.Replacewornor
brokenparts.Replaceallwornordamagedsafetyand
instructiondecals.
• DonotmodifytheGraderBladeorsafetydevices.
UnauthorizedmodicationstothevehicleorGrader
Blademayimpairitsfunctionandsafety,andvoidthe
warranty.
• Keepallnuts,boltsandscrewstight.
• AlwaysstopthetractorandraiseGraderBladeto
transportpositionBEFOREchangingbladeangleor
reversingblade.
• Careshouldbetakennotto"hang"theGraderBlade
onsurfaceprojectionssuchascornersofconcrete
driveways.
• LocktractorlifthandleDOWNwheninstallingor
removingGraderBladeonSleeveHitch.
TOWING SAFELY
• Stoppingdistanceincreaseswithspeedandweight
ofattachment.Travelslowlyandallowextratimeand
distancetostop.
• Totaltowingweightmustnotexceedlimitsspeciedin
vehicleoperator'smanual.
KEEP RIDERS OFF HITCH AND ATTACHMENT
• KeepridersoffGraderBladeandattachments.
• RidersonaGraderBladeorattachmentaresubjectto
injury,suchasbeingstruckbyobjectsandbeingthrown
offtheattachmentduringsuddenstarts,stopsandturns.
• Ridersobstructtheoperator'sview,resultinginthe
attachmentbeingusedinanunsafemanner.
KEEP BODY PARTS FROM UNDER Grader Blade
AND ATTACHMENTS
Beforedisconnectingthismachinefromtowingvehiclehitch
plate:
• Stoponlevelground.
• Stoptowingvehicleengine.
• Locktowingvehicleparkbrake.
• Blockwheelsofthemachine.
• MakesurebodypartsarenotunderGraderBladeor
attachments.
L-1434 Rev. B
4
PARTS REFERENCE
STOP
Installation Questions?
Missing Parts?
Replacement Parts?
Please call Customer Service
Department Toll Free
877.728.8224 or
customerservice@brinly.com
DON’T GO BACK
TO THE STORE!
19
18
15
14
2
1
11
13
12
20
9
6
5
7
4
3
16
17
10
8
L-1434 Rev. B
5
PARTS REFERENCE
Item # Part # Description Qty
1 45M4440P Washer,1-1/4" 1
2 B-1675P Locknut,3/8"-16 1
3 B-2375-10 42"BladeBlack 1
4 B-2376-10 AnglingBarBlack 1
5 B-2578 ClevisPin,7/16"x2-3/8" 1
6 B-3717 VinylGrip 1
7 B-2596-10 BladeMountBlack 1
8 B-5922 BrinlyDecal 1
9 B-4265-10 HitchBlack 1
10 B-4351-10 DrawbarBlack 1
Item # Part # Description Qty
11 2M1620P HexBolt,1/2"x1-1/4" 4
12 10M1216P CarriageBolt,3/8"x1" 4
13 10M1240P CarriageBolt,3/8"x2-1/2" 1
14 30M1200P HexNut,3/8" 4
15 30M1600P HexNut,1/2" 4
16 40M1200P Lockwasher,3/8" 4
17 45M1313P Washer,3/8" 4
18 40M1600P Lockwasher,1/2" 4
19 45M1717P Washer,1/2" 2
20 50M0416P CotterPin,1/8"x1"SS 1
ASSEMBLY
TOOLS REQUIRED:
(1)9/16"Wrench
(2)3/4"Wrenches
(1)PairofSlipJointPliers
(1)Level
1.AssembleBladetoBladeMountasshown.
Assemblehardwareloosely.Youwillfullytighten
inadjustmentsteplater.
2.Installdrawbardownontotheblademountas
shown.
Figure 1
17
3/8"Washer
Qty.4
16
3/8"Lockwasher
Qty.4
12
3/8"x1"CarriageBolt
Qty.4
14
3/8"HexNut
Qty.4
17
16
14
12
L-1434 Rev. B
6
ASSEMBLY
3.InstallLargeFlatWasheroverDrawbarPost.Slide
AnglingLeveroverDrawbarPostandassemblewith
ClevisPinandCotterPininoutermostholes.
4.InstallCarriageBoltandLocknutintoinnermostholes.
5.InstallVinylGripontoLever.
6.AssembleHitchtoDrawbarasshown.
Figure 2
1
1-1/4"Washer
Qty.1
2
3/8"Locknut
Qty.1
20
1/8"x1"CotterPin
Qty.1
5
ClevisPin
Qty.1
13
3/8"x2-1/2"CarriageBolt
Qty.1
14
3/8"Nut
Qty.4
18
1/2"Lockwasher
Qty.4
11
1/2"x1-1/4"HexBolt
Qty.4
19
1/2"Washer
Qty.2
14
2
18
19
11
13
5
20
1
9
4
6
L-1434 Rev. B
7
ADJUSTMENT
6.Attachthebladetothesleevehitchonyourtractor
usingthemiddleholesinthebladehitch.
7.Positionthetractor(withblade)onahard,levelsurface.
Lowerthebladeandchecktomakesureitislevel,side
toside,andthentightenthe(4)3/8"x1"CarriageBolts
holdingthebladetotheblademount.
8.Placealevelonthetopofthedrawbar.Adjusthitch
assemblyuntildrawbarislevelfronttoback.Tightenthe
(4)1/2"x1-1/4"HexBoltssecurely.
Figure 3
Blade Level Adjustment
(side to side)
(4) 3/8" x 1" Carriage Bolts
Level Drawbar at This Surface
(front to back)
Drawbar Level Adjustment
(front to back)
(4) 1/2" x 1-1/4” Hex Bolts
Point of
Blade Edge
9.Thestabilizerboltsonthehitchshouldbetightened
againsttheyokeondrawbartopreventany"sidesway"
duringtheoperationoftheblade.
10.Theoperatingdepthofthebladeneedstobesetnow.
Makesurethetractorhitchisfreetoallowbladetogo
belowgroundlevel,butstillmaintainingaminimumof5"
transportheightwhenraised.Refertoyourtractorand/or
sleevehitchmanualforanynecessaryadjustments.
OPERATION
MAINTENANCE
Variousbladeangles(leftandright)areobtainedbylifting
lever,rotatingthebladetothedesiredangle,thenlowering
theleverintooneofthelockingholes.
Tousethebladewiththetractorinreversegear,raisethe
lever,rotatetheblade180degreesandlockintothedesired
position.
Therearbladeisdesignedtobeusedinavarietyoflight
jobssuchasleveling,scraping,raking,backlling,snow
removal,etc.
Thetractorspeedwhileoperatingtherearbladeshouldbe
governedbythetasktobeaccomplished.
Whilegrading,donotattempttocutexcessiveamountsof
hardpackedmaterialatahighrateofspeed.
NOTE:Operateataspeedwhichallowsloosematerialthat
haspileduponthefaceofthebladetobedepositedinlow
areas.
Afterthebladeedgehaswornconsiderably,itshould
berotated(frombottomtotop)toprovidea"new"edge.
Removethefour3/8"x1"CarriageBolts,rotatetheblade,
andthenreassembletheunitwiththe"new"edgeonthe
surface.
Lubricateallpivotingpointswithadroportwoof30weight
oil.
L-1434 Rev. B
ThelimitedwarrantysetforthbelowisgivenbyBrinly-Hardy
Companywithrespecttonewmerchandisepurchasedand
usedintheUnitedStates,itspossessionsandterritories.
Brinly-HardyCompanywarrantstheproductslistedbelow
againstdefectsinmaterialandworkmanship,andwillat
itsoption,repairorreplace,freeofcharge,anypartfound
tobedefectiveinmaterialsorworkmanship.Thislimited
warrantyshallonlyapplyifthisproducthasbeenassembled,
operated,andmaintainedinaccordancewiththeOperator’s
manualfurnishedwiththeproduct,andhasnotbeensubject
tomisuse,abuse,commercialuse,neglect,accident,
impropermaintenance,alteration,vandalism,theft,re,
water,ordamagebecauseofotherperilornaturaldisaster.
NormalWearPartsorcomponentsthereofaresubject
toseparatetermsasfollows:Allnormalwearpartsor
componentfailureswillbecoveredontheproductfora
periodof90days.
Partsfoundtobedefectivewithinthewarrantyperiodwill
bereplacedatourexpense.Ourobligationunderthis
warrantyisexpresslylimitedtothereplacementorrepair,
atouroption,ofpartsfoundtobedefectiveinmaterialand
workmanship.
HOW TO OBTAIN SERVICE:Warrantypartsreplacements
areavailable,ONLYWITHPROOFOFPURCHASE,through
ourPullBehindAccessoriesCustomerServiceDepartment.
Call877-728-8224.
Thislimitedwarrantydoesnotprovidecoverageinthe
followingcases:
• Routinemaintenanceitemssuchaslubricantsandlters.
• Normaldeteriorationoftheexteriornishduetouseor
exposure.
• Transportationand/orlaborcharges.
• Thewarrantydoesnotincludecommercialand/orrental
use.
No implied warranty, including any implied warranty
of merchantability of tness for a particular purpose,
applies after the applicable period of express written
warranty above as to the part as identied below.
No other express warranty whether written or oral,
except as mentioned above, given by any person or
entity, including a dealer or retailer, with respect to
any product, shall bind Brinly-Hardy Co. During the
period of the warranty, the exclusive remedy is repair or
replacement of the product as set forth above.
The provisions as set forth in this warranty provide
the sole and exclusive remedy arising from the sale.
Brinly-Hardy Co. shall not be liable for incidental or
consequential loss or damage including, without
limitation, expenses incurred for substitute or
replacement lawn care services or for rental expenses to
temporarily replace a warranted product.
Somestatesdonotallowtheexclusionorlimitationof
incidentalorconsequentialdamages,orlimitationsonhow
longanimpliedwarrantylasts,sotheaboveexclusionsor
limitationsmaynotapplytoyou.
Duringthewarrantyperiod,theexclusiveremedyis
replacementofthepart.Innoeventshallrecoveryofany
kindbegreaterthattheamountofthepurchasepriceofthe
productsold.Alterationofsafetyfeaturesoftheproductshall
voidthiswarranty.Youassumetheriskandliabilityforloss,
damage,orinjurytoyouandyourpropertyand/ortoothers
andtheirpropertyarisingoutofthemisuseorinabilitytouse
thisproduct.
Thislimitedwarrantyshallnotextendtoanyoneotherthan
theoriginalpurchaserortothepersonforwhomitwas
purchasedasagift.
HOW STATE LAW RELATES TO THIS WARRANTY:This
limitedwarrantygivesyouspeciclegalrights,andyoumay
alsohaveotherrightswhichvaryfromstatetostate.
IMPORTANT:TheWarrantyperiodstatedbelowbeginswith
thePROOFOFPURCHASE.Withouttheproofofpurchase,
theWarrantyperiodbeginsfromthedateofmanufacture
determinedbytheserialnumbermanufacturingdate.
Grader Blade WARRANTY PERIOD:
ThewarrantyperiodforthisGraderBladeis2Years.
MANUFACTURER'S LIMITED WARRANTY FOR
Pull Behind Accessories
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

Brinly BB-56 Owner's manual

Brinly
Brand
Brinly
Model
BB-56
Type
Owner's manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents