COMPANION COMP830LI Owner's manual

COMPANION
Brand
COMPANION
Model
COMP830LI
Type
Owner's manual
OWNERS MANUAL
Australia’s original Outdoor brand
OWNERS MANUAL
Part No. COMP830LI
AQUACUBE LOGIC Li
RECHARGEABLE CAMP SHOWER
AUSTRALIA ONLY
Cert. SAI - 400135
SAI Global
AS 2658 - 2008
GAS SAFETY
CERTIFICATION
®
INTRODUCTION
YOUR AQUACUBE
®
INCLUDES
IMPORTANT: Read these instructions carefully and understand the operation and safety features
of this appliance. Familiarise yourself with the appliance before connecting it to the
gas cartridge. Keep these instructions safe for future reference.
Digital control panel
Shower outlet
GAS
REGULATOR
WATER HOSE
AND PUMP
12V DC LEAD &
CONNECTION
AC POWER
ADAPTOR
QUICK CONNECT
FITTING
SILICONE
HOSE
SHOWER
HEAD
CARRY
BAG
UNDERSTANDING YOUR AQUACUBE
®
1
2
OWNERS MANUAL
Water outlet
temperature
Water inlet
temperature
START CONTROL
POWER On/OFF
gaS teMperature
control
BatterY charge leVel
Burner inDicator
uSeS DiSpoSaBle
propane cYlinDerS
puMp fuSe
water inlet
puMp power outlet
power inlet
gaS regulator
rear carrY hanDlefront carrY hanDle
SHOWER OUTLET
SILICONE HOSE
QuicK connect fitting
Shower heaD
on/off flow
Switch
UNDERSTANDING YOUR AQUACUBE
®
DIGITAL CONTROL PANEL
3
THIS APPLIANCE IS NOT INTENDED FOR THE SUPPLY OF DRINKING WATER.
THIS APPLIANCE IS INTENDED FOR THE SUPPLY OF HEATED WATER FOR THE PURPOSE OF WASHING AND CLEANING ONLY.
CHECK AND CONFIRM SAFE WATER TEMPERATURE BEFORE USING THIS APPLIANCE. WATER FROM THIS APPLIANCE MAY BE VERY HOT.
IMPORTANT
• Thisapplianceisdesignedtobeusedwithasourcewatertemperatureof20°Corbelow
• Themaximumtemperatureliftfromtheapplianceis30°Cfromthesourcewatertemperature
• Forsafetytheapplianceisdesignedtoshutofftheburnerwhenthewatertemperatureexceeds50°C
+
/
-
2°(average)
• Theaverageruntimefortheappliancefromafullychargedbatteryis45to50minsbeforeitwillrequirerecharging
• TheappliancecanbeoperatedwhilstconnectedtoACorDC.Thebatterywillacceptchargeifitislessthan12Vwhilstoperating.
DO NOT: Operatethisappliancebeforereadingtheinstructionbooklet
DO NOT: Placearticlesonoragainstthisappliance
DO NOT: Placechemicalsorammablematerials,orsprayaerosolsnearthisappliance
DO NOT: Operatewithpanels,coversorguardsremovedfromthisappliance
DO NOT: Operateinanenclosedareawithoutventilation
DO NOT: Operateinaboat,caravanortent
CAUTION
4
GENERAL WARNINGS
• Thisapplianceshallonlybeusedwiththeregulatorsupplied
withtheapplianceandmustonlybeconnectedto
non-rellable468gdisposablePropaneCartridgescertied
toDOT-39,UN1075.
• Thisapplianceistobestoredinadryandwellventilated
locationfreefromdirectsunlight.Donotstorewhenstill
connectedtothecylinder.Makesurethatthecylinderis
disconnectedandisstoredinawellventilatedarea,free
fromdirectsunlight,heatandignitionsources.Ifbeing
storedindoorsensurethatthelocationcomplieswiththe
standardAS/NZS1596.
• Thisappliancemustonlybeservicedbyanauthorised
serviceagent,returntoyourplaceofpurchaseforservice
andrepair.
DANGER!
• Thisapplianceisdesignedforoutdooruseonly.
• Donotusetheapplianceifitisleaking,damagedordoes
notoperateproperly.
• Handlewithcareevenafterbriefuse,alwayspickupusing
thehandles.
• Itmaybehazardoustoattempttotothertypesofgas
containersorcartridges.
• Useonlyinwellventilatedareas.
• Thisapplianceshallonlybeusedinanabovegroundopen
airsituationwithnaturalventilation,withoutstagnant
areas,wheregasleakageandproductsofcombustionare
rapidlydispersedbywindandnaturalconvection.
• Donotuseadaptors.Donotmodifyappliancetotother
connectorsorcylinders.
• Whenusingthisappliancechildrenmustbe
supervisedbyanadultatalltimes.
• Neverleaveapplianceunattendedwhenoperating.
• Donotuseasacookingapplianceormodifyforany
otherreason.
CARBON MONOXIDE HAZARD
• Usingthisapplianceinanenclosedspacemaycause
DEATH.Donotuseincaravans,tents,marinecraft,cars,
mobilehomesorsimilarlocations.
• OUTDOORUSEONLY–Theappliancemustbeusedoutdoors
onlyandistobeoperatednocloserthan800mmfromthe
sidesand800mmfromaboveallcombustiblesurfaces,
fabricsandammablematerials.Mustonlybeusedonsolid
andstablehorizontalsurfacesmadefromnon-combustible
ornon-ammablematerialsandshouldbeprotectedfrom
directdraftsandinawellventilatedplace.
• Caution:Accessiblepartsmaybeveryhot.Keepyoung
childrenaway.
• Ifyousmellgasimmediatelyturnthegasoffatthecartridge
andmovetheapplianceandcartridgetoawellventilated
areaoutside,keepingwellawayfromsourcesofheatsuch
asnakedamesandpilotlights.
• Donotattempttomoveorrelocatetheappliancewhen
itisoperating.Extinguishtheburnerandallowtocool,
disengagethegascartridgethenmovetheappliance.
CHECKING FOR GAS LEAKS
• Checkthatallconnectionsaretightandthatthegas
connectionhasbeentightenedbeforeyouturnthe
applianceon.
• NEVERcheckforleakswithaameorpilotlight.
• Usingsoapywatercoatallconnections,ifbubblesappear
retightenthecartridgebeforere-testing.
• Inspecttheapplianceregularlyforsignsofwear,leaks
orincorrectoperation.Ifsymptomssuchasaringofthe
burners,issueswithlighting,damagesconnectionsorleaks
fromsealsorgascontrolsareidentieddonotattemptto
repair,contactCustomerServiceon1300555197.
• Tocheckifgasremainsinthecartridge,disconnectfromthe
applianceandholdthecartridgeinaverticalpositionthen
shakefromsidetoside.Ifthereisasoundorafeelofliquid
movementinsidethecartridge,thecartridgecontainsgas.
• Whenchanginggascartridgeensurethisisconducted
outsideinawellventilatedlocationfreefrompeople,
animalsandignitionsourcessuchasnakedames,pilot
lightsandelectricalequipmentwithheatersorelements.
OWNERS MANUAL
5
SAFETY INSTRUCTIONS
Thisapplianceshallonlybeusedinanabovegroundopenairsituationwithnaturalventilation,withoutstagnant
areas,wheregasleakageandproductsofcombustionarerapidlydispersedbywindandnaturalconvection.
Any enclosure in which the appliance is used
shall comply with one of the following:
(A)Anenclosurewithwallsonallsides,
butwithnooverheadcover.
(B)Withinapartialenclosurethatincludesanoverhead
coverandnomorethantwowalls.
(C)Withinapartialenclosurethatincludesanoverhead
coverandmorethantwowalls,thefollowingshallapply:
(1)Atleast25%ofthetotalwallareaiscompletelyopen.
(2)30%ormoreintotaloftheremainingwallside,back
andfrontwallareasisopenandunrestricted.
(3)Inthecaseofbalconies,20%ormoreofthetotalwall
areashallremainopenandunrestricted.
1
1
1
2
2
Important
Duringoperationensurethatallair
inletsandexhaustsarekeptfreefrom
obstructionsandclosure.
Air Inlet
IMPORTANT–Thisapplianceisdesignedtobeused
withasourcewatertemperatureof20ºCorbelow,ifthe
temperatureoftheoutletwaterexceeds50ºC
+
/
-
2ºthe
burnerswillshutoffandwillonlyrelightoncetheoutlet
watertemperaturefallsbelow45ºC.
Thisapplianceisdesignedtoraisetheoutletwater
temperaturebyamaximum(average)of25ºCto30ºC
abovethesourcewatertemperatureandcanbeadjusted
bythegascontrol.Intheeventthatthetemperaturelift
isinsufcient,simplyrunwaterthroughtheappliance
oncereturningtheheatedwatertothesourcewater
reservoir.Runagainthroughtheapplianceuntilthe
desiredtemperatureisreached.
SAFETY FEATURES
Thisapplianceisequippedwiththefollowingsafetyfeatures:
• Over Temperature Sensor–theappliancewillnot
allowtheburnertoremaininoperationoncetheoutlet
watertemperaturereaches50º
+
/
-
2º,theburnerwill
automaticallyrelightoncetheoutlettemperaturefalls
below45º.
• Water Flow Sensor–watermustbeowingthroughthe
systemtoallowtheburnertoignite.Inthecasethatthe
watersupplyisrestrictedorceases,ie.theFlowSwitch
onshowerheadisinthe“off”position,theburnerwill
beextinguishedandwillnotrelightuntilthewaterow
recommences.
• Tilt Switch–intheeventthattheapplianceismovedduring
operationorisbeingoperatedonanunstableornon-solid
surfacetheappliancewillshutdownandmustbeswitched
offuntilasuitablesurfaceislocated.
• Fuse Protection–fusesarelocatedinthecigarettelighter
andpumppowerinlet.Intheeventofanelectricalsupply
issuethesewill‘blow’andprotecttheelectronicsystemof
theappliance.
• Replacement Fuse–5A250V(5mmx20mm)
OWNERS MANUAL
6
7
Setting Up
Step 1. Removeallcomponentsfromthestoragebagandplacethe
applianceonasolid,non-combustiblesurfaceandstraightenout
allhosestoremoveanykinksortwists.
Step 2. Screwthegasregulator(clockwisedirection)ontothegasinletatthe
topRHSatrearoftheapplianceandtightensecurely.Note:Priorto
connectingthegasregulator,checktoensuretheblackrubberseal
hasbeenttedontothegasinletpipe.
Step 3. Screwthegascartridge(clockwisedirection)ontothegasregulator
andtightensecurely.Checkforleakswithsoapywater
–Donotuseaame.Ifaleakisdetectedremovethegascartridge
andretightenallconnections,thenretest.
Step 4. ConnectpumppowerleadtoPUMPCONNECTIONsocket(BLACK)at
rearoftheappliance.
Step 5. Attachthepumphosetothewaterinletattherearoftheappliance
–pushonrmly.
Step 6. Submergethepumpinasuitablereservoirofcleanwater.DONOTuse
waterdirectfromrivers,lakesortheocean.DONOTusesaltwater
withthisappliance.
Step 7. Connecttheshowerhosetothewateroutletonthefrontpanel
–pushonrmly.
Step 8. SlideshowerheadowswitchtoONposition.
1
4 5 6
87
3
2
8
Operating the Shower
Step 1. PressthePowerbuttonandtheunitwillswitchon.
Step 2. ChecktheBatteryChargeLeveltoseeifsufcientpoweris
available,ifnotconnecttotheACorDCadaptor.Referto
page10forAppliancePowerandCharging.
Step 3. Positionthegastemperaturecontrolinthecentralpositionbetween
MINandMAX.ThenpresstheSTARTbuttonandwaterwillstartto
owwithinafewmoments.
Step 4. Theelectronicignitionshouldbeheardignitingtheburner,
whenlit,the“Flame”icononthedisplaywillilluminateandthe
outletwatertemperaturereadoutwillincrease.
Step 5. Takingcaretomeasurethetemperatureofthewaterfromthe
showerhead,thetemperaturecanbeadjustedbyturningthegas
controluntilthedesiredlevelisreached.
Step 6. Thewaterowcanbestoppedatanytimebyslidingthe
FlowSwitchtothe“OFF”position,theburnerwill
extinguishandthepumpwillcontinuetooperate.
Step 7. Toturntheapplianceoff,pressthePowerButton.
IMPORTANT–Waterremainingintheheatexchangerwhilethe
owisstoppedmaybecomehot.Whentheowisresumedthe
usermustcheckthetemperatureoutputtoensurethatitis
suitableandnottoohot.
Oncetheuserhasnishedwiththeappliance,slidetheFlow
Switchtothe“OFF”positionanddepressthe“START”button
tostoptheowofwatertotheappliance.
5
1
7
2
4
3
Ensure
Gas
control is
in central
position
6
OWNERS MANUAL
9
1
Storing the Appliance
Step 1. PressthePowerButtontoensuretheapplianceisswitchedoff.
Step 2. Disconnectallhosesandholdverticallyallowingallexcesswaterto
drainfromthem.Checkontheshowerheadthattheowregulation
switchisinthe‘ON’position
Step 3. Unscrewtheregulatorassemblyfromtheapplianceandremovethe
gascartridge.
Step 4. Tiptheappliancetowardsthebackandtoonesidetodrainexcess
waterfromtheheatexchangerviathewaterinlet.
2
3
4
10
Appliance Power and Charging
Thechargingsystemisdesignedsoitwillallowthebatterytoberecharged
whilsttheunitisinoperation.Therechargetimeswillincreaseby50%ifthe
unitisoperatingwhilstitisbeingcharged.
Step 1. Theapplianceisttedwitha12V3.2A/hrbatterypackand
canberechargedfromeithertheACorDCadaptorssupplied.
Step 2. TorechargetheappliancefromeitheranACorDCpower
source,theunitmustbeswitchedonandtheBatteryChargeLevel
mustbeilluminated.
Step 3. ConnecttotheDCINPUTsocket(RED)attherearoftheappliance
andtheBatteryChargeLevelwillstarttoashandmovefrom
‘RedtoGreen’conrmingthatthebatteryisnowcharging.Note:
Whenthebatteryisfullycharged,theRed,YellowandGreen
batterylevelswillstopashing.
Step 4. AC:Connectthethree(3)pinplugtoasuitableoutletthen
connecttotheapplianceandswitchontheACoutlet.
Step 5. DC:Connecttheadaptortotheapplianceandthenconnect
toasuitableoutletviathecigarettelightertting.
DO NOT USE–ACtoDCconvertersormodifytheadaptors
suppliedwiththeappliance.
IMPORTANT – If the appliance is not being used or is stored
it must be recharged every three months to guarantee the
battery life expectancy, failure to do so may result in
battery failure.
Chargetimetorechargethebatteryfromeitherpowersource
canbereachedin:
25%-1Hour
50%-2Hours
100%-4to5Hours
Tomaintainbatterylifeandconditionitisrecommendedthat
theunitisallowedtobechargedto100%
4
5
2
3
1
OWNERS MANUAL
CARE INSTRUCTIONS
Usingwarmsoapywaterwithamilddetergentwipe
downallsurfacesandareasoftheappliance,taking
carenottoallowwatertoentertheburneroutlets.
DONOTsubmergetheapplianceinasinkorbowl.
DONOTuseabrasivecleanersorbleach.
PartNo: COMP830Li
Waterow: 2litresperminute(Average)
Inletvoltage: 12VDC-5A
Size: 422x262x434mm
Weight: 7.9Kgs
Injectorsize: 0.66mmx4
Consumption: 20.68Mj/hr/412g/hr
SPECIFICATIONS
11
12
PROBLEM CAUSE
Water will
not flow from
shower head
Checkthatapplianceisswitchedon
Checksufcientwaterisavailable
Checkthatthepumpisconnectedto
theappliance
Checkthatpumpfuseisnotblown
CheckthatadequateDCpowerisavailable
CheckDCfuseincigarettelightertting
Checkthattheshowerowswitchisinthe
ONposition
Unit will not
switch on -
display will
not illuminate
CheckDCfuseincigarettelightertting
CheckthatadequateAC/DCpower
isavailable
Checkifbatteryrequiresre-charging
Burner will
not light
Checkthatgascylinderisturnedonand
thatthereisgasincylinder
Checkthatthewaterisowingfrom
showerhead
Checkthatthewaterisnotovertemperature
Water is not
hot enough
CheckgasTemperatureControlissetonMAX
Checksourcewatertemperature
Recyclethewaterthroughthesystemback
intothesourcereservoirthenthroughthe
applianceagain
Water is
too hot
CheckGasTemperatureControlissetonMIN
Checkinletwatertemperature
Checkwaterowfromshowerheadisset
toouterring
Checkifwaterrestrictorplugttedinside
showerheadhandle.
Removehoseconnectionandpulloutplug.
Retainplugandretifconditionschange.
TROUBLE SHOOTING GUIDE
Theguideshouldbefollowedincaseoffailureofthe
appliancetooperatecorrectly.Ifsymptomspersist
contactCustomerServiceon1300 555 197.
DO NOT ATTEMPT TO REPAIR
OR MODIFY THE APPLIANCE
Error Codes
Theapplianceisttedwithanumberofoperationaland
safetyfeaturesthatcanbeidentiedbythefollowing
errorcodes.Intheeventthattheunitwillnotoperate
refertotheTroubleShootingGuide:
E1:Flamenotextinguishing–turnunitoff
andremovecartridge
E3: NoFlame/Burnernotlit
E4:WaterOutlet–contactcustomerservice
E6:OverTempShutOff
E7: OutletWaterTempExceed50ºC
+
/
-
2º
E8:TiltSwitchactivated–placeonlevelsurfaceand
re-startappliance
OWNERS MANUAL
Appliance cutting out due to water temperature too hot:
IfE6OverTemperatureCutOfforE7OutletWater
TemperatureExceed50ºC
+
/
-
2ºappearontheDigital
ControlPanelandthegascontrolissettoMIN.
1.Checkifthereisawaterrestrictorplugttedinside
showerheadhandle.Thewaterrestrictorplughasbeen
addedtoallowthewaterowtoslowandprovidean
increaseintheoutletwatertemperature.Thisfeature
maynotberequiredinhotterconditions.
2.Theplugcaneasilyberemovedbyunscrewingthe
hosefromtheshowerheadandpullingouttherestrictor
plug.Reconnectthehosetotheshowerheadandcheck
theoutlettemperature.
Note:Retaintheplugandretincoolerconditions.
1 2
13
Notes
14
OWNERS MANUAL
COM4837
Distributedby
Companion Brands
BundooraVictoria3083
www.companionbrands.com.au
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16

COMPANION COMP830LI Owner's manual

COMPANION
Brand
COMPANION
Model
COMP830LI
Type
Owner's manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents