Davey X90 Operating instructions

Brand: Davey

Model: X90

Category: Sanitary ware

Type: Operating instructions

This manual is also suitable for

Installation and

Operating Instructions

for Dynajet

X50 / X70 / X90

Water Pressure Systems

Trouble Shooting Check List

a) MOTOR RUNS WHEN SWITCHED ON BUT DOES NOT PUMP.

 1. Suctionlineandpumpbodynotlledwithwater.

 2. Airleaksinsuctionlinesorsuctionpipenotunderwater.

 3. Airtrappedinsuctionlines(alsopossiblewithoodedsuctiondueto

unevenriseinpiping;eliminatehumpsandhollows).

 4. Nowateratsourceorwaterleveltoolow.

 5. Valveonsuctionlinesclosed.

b) PUMP SWITCHES ON AND OFF FREQUENTLY (CYCLING)

 1. Checkthattankairpressureiscorrect-seeabove.

 2. Leakingtaps,oatvalvesetc.checkplumbing.

 3. Leakingcheckvalve/footvalve.

c) MOTOR DOESN’T START WHEN SWITCHED ON.

 1. Powernotconnected.

 2. Supplyvoltagetoolow.

 3. “Overtemperature”cut-outtripped.*

 4. Motornotfreetoturneg.ajammedimpeller.

 5. Internalmotorfault.

Checking and Replenishing Tank Air Charge

Supercell“P”PressureTanksdonotrequireregularchecks

undernormaloperatingconditions,Ifairchargeadjustment

isrequiredthenfollowthefollowingprocedures:

1. Releaseallwaterpressurefromthepressuretankby

switchingoffthepumpatthepowerpoint,andopeningthe

closettap.Forabovegroundsupplytanksitisnecessary

toclosethegatevalvebetweenthesupplytankandthe

pump.

Leavetapopenduringairreplenishment.

2. Whenallwaterpressurehasbeenreleasedfromthesystem,checkair

pressureatairvalveontopofpressuretank.Thestandardpre-charge

pressurereadingshouldbe165kPaforX50and190kPaforX70andX90

models.Inanycasethepre-chargeshouldbesetat15kPabelowcut-in

pressure.

3. Ifnecessary,replenishairchargetothecorrectpressureindicated.Ensure

thatatapinoutletpipingofpumpsisopenduringreplenishmentofair

precharge.

Period Checks

Flushing:Dependingonthequalityofthepumpedwater,fromtimetotime,

yourtankmayrequiredushingtoremovesettlednessuchasmudorsand.

Ifsandormudisallowedtostayinthetank,itwillacceleratewearonthe

internalliningandshortenyourtank’slife.

Safelydisconnectthetankfromthewatersupply,dischargeallairfromthe

tankandushthetankseveraltimeswithcleanwater.Oncetheushing

waterisclean,reconnectthetankandrechargetheairasperabove.

Externalinspection:Atankingoodorderwillnotleak,butovertimedueto

damagethroughroughhandling,impactsorgritand/orimpuritiesinthewater,

thetankshellmayfailand/orleak.Shouldthetankleakorshowsignsof

possiblefailure,thetankshouldbeimmediatelydisconnectedandreplaced.

Please pass these instructions on to the operator of this equipment.

*NOTE: For protection, the Davey pump motor is tted with an

automatic “over temperature” cut-out. Constant tripping of this

overload device indicates a problem eg. low voltage at pump,

excessive temperature (above 45

C) in pump enclosure.

Care should also be taken when servicing or disassembling pump to

avoid possible injury from hot pressurised water. Unplug pump, relieve

pressure by opening a tap on the discharge side of the pump and allow

any hot water in the pump to cool before attempting to dismantle.

WARNING: When servicing or attending pump, always ensure power

is switched off and lead unplugged. Electrical connections should be

serviced only by qualied persons.

During servicing, use only approved, non-petrochemical based oring

and gasket lubrication. If unsure, consult your Davey Dealer for advice.

WARNING: Do not use hydrocarbon based or hydrocarbon propelled

sprays around the electrical components of this pump.

In accordance with AS/NZS 60335.2.41 we are obliged to inform you that this

pump is not to be used by children or inrm persons and must not be used as a

toy by children.

WARNING: Failure to follow these instructions and

comply with all applicable codes may cause serious

bodily injury and/or property damage.

NOTE: Prior to installation remove the red transport

plugs & associated seals from the suction and/or

discharge ports.

CAUTION: To prevent personal injury, ensure all water pressure is released

from the pressure system prior to work being performed.

NOTE: During air replenishment the tank should be externally inspected. Any

signs of leakage from the tank may indicate a need for immediate replacement.

WARNING: Do not use tank if it leaks or shows signs of corrosion or damage.

Davey

Repair or Replacement Guarantee

In the unlikely event in Australia or New Zealand that this Davey product develops any malfunction within two years of the date of original purchase due to

faulty materials or manufacture, Davey will at our option repair or replace it for you free of charge, subject to the conditions below.

Should you experience any difculties with your Davey product, we suggest in the rst instance that you contact the Davey Dealer from which you

purchased the Davey product. Alternatively you can phone our Customer Service line on 1300 367 866 in Australia, or 0800 654 333 in New Zealand, or

send a written letter to Davey at the address listed below. On receipt of your claim, Davey will seek to resolve your difculties or, if the product is faulty or

defective, advise you on how to have your Davey product repaired, obtain a replacement or a refund.

Your Davey Two Year Guarantee naturally does not cover normal wear or tear, replacement of product consumables (i.e. mechanical seals, bearings or

capacitors), loss or damage resulting from misuse or negligent handling, improper use for which the product was not designed or advertised, failure to

properly follow the provided installation and operating instructions, failure to carry out maintenance, corrosive or abrasive water or other liquid, lightning

or high voltage spikes, or unauthorized persons attempting repairs. Where applicable, your Davey product must only be connected to the voltage shown

on the nameplate.

Your Davey Two Year Guarantee does not cover freight or any other costs incurred in making a claim. Please retain your receipt as proof of purchase; you

MUST provide evidence of the date of original purchase when claiming under the Davey Two Year Guarantee.

Davey shall not be liable for any loss of prots or any consequential, indirect or special loss, damage or injury of any kind whatsoever arising directly

or indirectly from Davey products. This limitation does not apply to any liability of Davey for failure to comply with a consumer guarantee applicable to

your Davey product under the Australian or New Zealand legislation and does not affect any rights or remedies that may be available to you under the

Australian or New Zealand Consumer Legislation.

In Australia, you are entitled to a replacement or refund for a major failure and for compensation for any other reasonably foreseeable loss or damage. You

are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure.

Should your Davey product require repair or service after the guarantee period; contact your nearest Davey Dealer or phone the Davey Customer Service

Centre on the number listed below.

For a complete list of Davey Dealers visit our website (davey.com.au) or call:

* Installation and operating instructions are included with the product when purchased new.

They may also be found on our website.

P/N 48660-9 supersedes P/N 48660-8

AUSTRALIA

Customer Service Centre

6 Lakeview Drive,

Scoresby, Australia 3179

Ph: 1300 367 866

Fax: 1300 369 119

Website: davey.com.au

Davey Water Products Pty Ltd

Member of the GUD Group

ABN 18 066 327 517

NEW ZEALAND

Customer Service Centre

7 Rockridge Avenue,

Penrose, Auckland 1061

Ph: 0800 654 333

Fax: 09 527 7654

Website: daveynz.co.nz

® Davey & Dynajet are registered trade marks of Davey Water Products Pty Ltd.

Choosing a Site

Chooseasitewitharmbaseandasclose

tothewatersourceaspossiblewithcorrect

powersupply.Makesureyourpressure

systemisalwaysconnectedtoanadequate,

reliablesourceofcleanwater.

Housing your Davey Pressure System

Toprotectyourpressuresystemfromtheweather,

makesurethepumphouseisbothwaterproof,

frostfreeandhasadequateventilation.Thepump

shouldbehorizontallymountedonarmbase

allowingfordrainage,toavoiddamagetoooring

etc.,thatovertimemayoccurfromleakingpipe

jointsorpumpseals.Donotmountthepump

vertically.

Agoodqualitynon-returnvalvemustbe

installedinthepressurepumpoutletpipework

beforethehotwaterservice.Failuretoinstall

thisnon-returnvalvemayresultinpump

damage.Suchdamageisnotcoveredby

guarantee.

Connection of Mains Scheme or Town Water Supply to either Suction or

Discharge of Pumps & Pressure Systems

MostWaterSupplyAuthoritieshavestrictregulationsregardingdirect

connectionofpumpstomainswatersupplies.Inmostcasesanisolatingtank

isrequiredbetweenmainssupplyandpump.Daveyalsorecommendthis

method.Directlyappliedmainspressurecanexceedpumpoperatingpressure

anddamagepump.

Davey Products Pty Ltd can

not accept responsibility

for loss or damage

resulting from incorrect or

unauthorised installations.

WARNING: Some insects, such as small ants, nd electrical devices

attractive for various reasons. If your pump enclosure is susceptible

to insect infestation you should implement a suitable pest control plan.

Pipe Connections

ForbestperformanceuseP.V.C.orpolythenepipesatleastthesame

diameterasthepump’sinletanddeliveryoutletopenings.Largerdiameter

pipemaybeusedtominimiseresistancetoowwhenpumpinglonger

distances.

Useunionsatpipeconnectionstoenableeasyremovalandservicing.Use

sufcienttapetoensureairtightsealandhandtightenonly.Topreventstrain

onpumpthreadsalwayssupportheavyinletandoutletpipes.Ifthereisa

likelihoodthewatersupplymaycontain

solidparticlessuchaspiecesofplantor

vegetablematter,asuctionstrainershould

beinstalledbeforethepumptoavoid

blockingofthepump.Laysuctionpipeat

aconstantgradienttoavoidairpockets

whichmayreducepumpefciency.

Where to use Check Valves and Foot Valves

Installationswithasuctionliftover1mrequireagoodqualityfootvalveto

avoidlossofprime.Inthiscase,thepoppetvalveinsidethepumpshould

beremoved.Installationswithoodedsuctionrequireagatevalvesowater

supplycanbeturnedoffforpumpremovalandservicing.

Priortousingthispumpyoumustensurethat:

• Thepumpisinstalledinasafeanddryenvironment

• Thepumpenclosurehasadequatedrainageintheeventofleakage

• Anytransportplugsareremoved

• Thepipe-workiscorrectlysealedandsupported

• Thepumpisprimedcorrectly

• Thepowersupplyiscorrectlyconnected

• Allstepshavebeentakenforsafeoperation

Appropriatedetailsforalloftheseitemsarecontainedinthefollowing

InstallationandOperatingInstructions.Readtheseintheirentiretybefore

switchingonthispump.IfyouareuncertainastoanyoftheseInstallationand

OperatingInstructionspleasecontactyourDaveydealerortheappropriate

Daveyofceaslistedonthebackofthisdocument.

Congratulationsonyourpurchaseofahighquality,AustralianbuiltDaveypres-

suresystem.Allcomponentshavebeendesignedandmanufacturedtogive

troublefree,reliableoperation.

1. Pressuretank

2. Pressureswitch

3. Deliveryoutlet

4. Suction inlet

5. Pump body

6. Motor

7. Base

8. Primingplug

Connectionsizes:

Model Inlet Outlet

X50 1” 1”

X70 1

” 1”

X90 1

” 1”

Do not use pipe thread sealing compounds on any part of this pump.

ONLY use Teon sealing tape.

Before installing your new pump, please read all instructions carefully as fail-

ures caused by incorrect installation or operation are not covered by the guar-

antee. Your Dynajet® system is designed to handle clean water. It should not

be used for any other purpose without specic referral to Davey. The use of the

pump to handle ammable, corrosive and other materials of a hazardous nature

is specically excluded.

Priming and Operation

1.Removeprimingplugandll

pumpandsuctionline(onooded

suction,simplyopengatevalve

 topump).Whenfull,

 replaceprimingplug.

2.Ensureoutletnearesttopumpis

open.

3.Ensureallvalvesinsuctionlineare

openandswitchon.

4.Primeshouldestablishalmost

immediatelyandastrongow

ofwatershouldbe

evidentfromthe

outlet.Allowwaterto

owfor10-20seconds

toexpelairthenclose

outlet.

5.Ifnoowisevidentfromtap,

switchoffatpowerpointandrepeat

fromstep1ensuringthereisan

adequatesupplyofwateravailable

tothepump.

Power Connection

Connect lead to power supply designated on pump label, do not use

long extension leads as they cause substantial voltage drop, poor

pump performance and may cause motor overload.

NOTE: Suction leaks are the

largest cause of poor pump

performance and are difcult

to detect. Ensure all

connections are completely

sealed using thread tape only.

IMPORTANT

For Automatic Pressure Pumps Installed with a Mains Pressure Hot

Water System.

Abrasive Materials

The pumping of abrasive materials will cause damage to the

pressure system which will then not be covered by the guarantee.

Davey X90 Operating instructions

Brand: Davey

Model: X90

Category: Sanitary ware

Type: Operating instructions

This manual is also suitable for

Download PDF

report

Davey X90 Operating instructions

This manual is also suitable for

Davey X90 Operating instructions

Related papers

Other documents