Raymarine PJ5RAY101 User manual

Ray101

Handheld

VHF Radio

Owner’s

Handbook

Document number: 81229_1

Date: November 2003

81229_1.book Page i Wednesday, November 12, 2003 2:39 PM

81229_1.book Page ii Wednesday, November 12, 2003 2:39 PM

iii

About this Handbook

Introduction

This handbook describes the Ray101 portable VHF marine radio. The

Ray101 provides two-way communications on all US, Canadian and

International marine channels and ten weather channels.

Conventions Used

Throughout this handbook, the dedicated (labelled) keys are shown in bold

capitals (for example: SCAN/SAVE). The LCD indicators and functions are

shown in normal capitals (for example: TX).

➤ Operating procedures, which may consist of a single key-press or a

sequence of numbered steps, are indicated by an arrow icon shown in

the margin.

Technical Accuracy

To the best of our knowledge, the information in this handbook was correct

as it went to press. However, our policy of continuous product improvement

and updating may change specifications without prior notice. As a result,

unavoidable differences between the product and handbook may occur

from time to time. Raymarine cannot accept liability for any inaccuracies or

omissions it may contain.

For the latest product information visit our website:

www.raymarine.com

Warranty

To register your new Raymarine product, please take a few minutes to fill out

the warranty registration card found at the end of this handbook. It is very

important that you complete the owner information and return the card to the

factory in order to receive full warranty benefits.

81229_1.book Page iii Wednesday, November 12, 2003 2:39 PM

iv Ray101 Handheld VHF Radio

Important Information

Safety Warnings

WARNING: Navigation Aid

Although we have designed this product to be accurate and reliable,

many factors can affect its performance. As a result, it should only be

used as an aid to navigation and should never replace common sense and

navigational judgement. Always maintain a permanent watch so you

can respond to situations as they develop.

WARNING: Battery and Battery Charger Safety

Do not short the terminals in the charger base that recharge the

batteries.

Do not put the charger in water.

Do not charge the batteries with + and – terminals reversed.

Do not use charger if power plug or cable is damaged.

Do not recharge batteries if physically deformed or leaking.

EMC Conformance

All Raymarine equipment and accessories are designed to the best industry

standards for use in the recreational marine environment. Their design and

manufacture conform to the appropriate Electromagnetic Compatibility

(EMC) standards but correct installation and use is required to ensure that

performance is not compromised.

81229_1.book Page iv Wednesday, November 12, 2003 2:39 PM

v

Raymarine Products and Services

Raymarine products are supported by a network of Authorized Service

Representatives. Raymarine’s Technical Services representatives or your

local dealer will be available to answer any questions you may have. For

information on Raymarine products and services, contact either of the

following:

United States Raymarine, Inc.

22 Cotton Road, Unit D

Nashua, NH 03063-4219

USA

Telephone:1-603-881-5200

1-800-539-5539

Fax: 1-603-864-4756

Europe Raymarine Ltd

Anchorage Park

Portsmouth, Hampshire

England PO3 5TD

Telephone: +44 (0) 23 9269 3611

Fax: +44 (0) 23 9269 4642

Or, you may contact us on the World Wide Web at:

www.raymarine.com

Raymarine is a registered trademark of Raymarine Limited.

81229_1.book Page v Wednesday, November 12, 2003 2:39 PM

vi Ray101 Handheld VHF Radio

81229_1.book Page vi Wednesday, November 12, 2003 2:39 PM

vii

Contents

Safety Warnings .......................................................................................iv

EMC Conformance .................................................................................iv

Chapter 1: General Information .........................................................................1

1.1 Introduction ......................................................................................1

1.2 Features ............................................................................................1

1.3 Licensing Requirements ...................................................................2

Chapter 2: Installation .........................................................................................5

2.1 Unpacking and Inspection ................................................................ 5

Equipment Supplied .....................................................................5

2.2 Attaching the Antenna ...................................................................... 5

2.3 Attaching the Belt Clip ..................................................................... 6

2.4 Attaching the Wrist Strap .................................................................6

2.5 Battery Usage ...................................................................................6

Battery Tray .................................................................................. 6

Charging Rechargeable NiMH Cells ........................................... 8

Chapter 3: Getting Started ..................................................................................9

3.1 Keypad and Rotary Knobs ............................................................... 9

Rotary Keys ..........................................................................10

Push Keys .............................................................................10

Description .................................................................................10

1. PWR/VOL ........................................................................10

2. SQ .....................................................................................10

3. PTT .................................................................................... 10

4. UP/DOWN ........................................................................ 11

5. Backlight / Keylock .......................................................... 11

6. 16/9 ................................................................................... 11

7. DW/TRI ............................................................................ 11

8. WX / BAND ...................................................................... 11

9. SCAN / SAVE ................................................................... 11

10. HL/USER ........................................................................ 11

3.2 LCD Display .................................................................................. 12

1. (TX) Transmitting ...................................................................12

2. (RX) Receiving .......................................................................12

3. (USER) Favorite Channel Mode .............................................12

4. (SAVED) Memory Mode ........................................................13

5. (PSCAN) All Scan/Saved Scan/Priority Scan ........................ 13

6. (U I C) Channel Set .................................................................13

7. (B) Receive-only Channel ...................................................... 13

8. (A) Simplex Channel ..............................................................13

81229_1.book Page vii Wednesday, November 12, 2003 2:39 PM

viii Ray101 Handheld VHF Radio

9 Channel Number ......................................................................13

10. Battery Level .........................................................................13

11. Keylock ................................................................................13

12. Indicators ..............................................................................14

13. Signal Strength ......................................................................14

Chapter 4: Operations ........................................................................................15

4.1 Turning the Power ON and OFF .....................................................15

4.2 Setting the Volume .........................................................................15

4.3 Setting the Squelch .........................................................................16

4.4 Setting the Power Output ................................................................16

Overriding the Low Output Power Restriction ...........................17

4.5 Setting the Channel ........................................................................17

4.6 Selecting a Weather Channel ..........................................................17

Weather Alert Operation .......................................................18

4.7 Setting the Frequency Band ...........................................................19

4.8 Selecting the Priority Channel ........................................................19

4.9 Selecting the Secondary Priority Channel ......................................20

Reprogramming the Secondary Priority Channel .......................20

4.10 Transmitting ...................................................................................21

4.11 Turning On the Backlight ...............................................................22

4.12 Turning On the Keylock .................................................................22

4.13 Using the Scan Modes ....................................................................23

All Scan .......................................................................................23

Saved (Memory) Scan ................................................................24

Priority All Scan .........................................................................25

Priority Saved Scan .....................................................................26

4.14 Adding Channels to Memory .........................................................27

4.15 Using the Monitor Modes ...............................................................28

Dual Watch ..................................................................................28

Tri Watch .....................................................................................29

4.16 USER Channel Mode .....................................................................30

4.17 Resetting Factory Defaults .............................................................31

Appendix A:Specifications .................................................................................33

Appendix B:Channel List .....................................................................................35

U.S. VHF Marine Radio Channels and Frequencies.................. 35

Canadian VHF Marine Radio Channels and Frequencies.......... 38

International VHF Marine Radio Channels & Frequencies ....... 43

Weather Channel (WX) Frequencies ..........................................46

Appendix C:Glossary ...........................................................................................47

Index ..................................................................................................49

81229_1.book Page viii Wednesday, November 12, 2003 2:39 PM

Chapter 1: General Information 1

Chapter 1: General Information

1.1 Introduction

The Ray101 is a microprocessor-controlled,

portable transceiver that provides reliable simplex

(single frequency) and semi-duplex (two

frequency) communications. This handbook

describes the physical and functional

characteristics of the radio.

The Ray101 provides two-way communications

on all US, Canadian and International marine

channels and ten weather channels. Refer to the

Frequency Tables in Appendix B, which list all

marine VHF channels available in your radio.

You should familiarize yourself with these tables

as you are responsible for using the proper

channels.

1.2Features

The Ray101 is designed and manufactured to

provide ease of operation with excellent

reliability. The Ray101 features:

•Waterproof to IPX-7 standard

•Saved-channels Scan and Priority Scan

•Dual/Tri Watch Monitor modes

•Dedicated key for switching to Channel 16

•10 Weather Channels

•Programmable Secondary Priority channel key

•NiMH batteries (AA size) included

•NiMH Quick Charger included

•12VDC Cigarette Lighter Adapter included

81229_1.book Page 1 Wednesday, November 12, 2003 2:39 PM

2 Ray101 Handheld VHF Radio

1.3 Licensing Requirements

Raymarine radios comply with the Federal Communications Commission

(FCC) and Industry Canada requirements that regulate marine VHF radio

usage for the US and Canada, respectively. Marine VHF radio users in the US

must comply with all applicable FCC rules and regulations, some of which

are described here and in Section 5.

This information was current at the time this handbook was printed. Up-to-

date information, including licensing requirements, can be obtained on the

FCC website at:

www.fcc.gov/wtb/marine

Official FCC forms can be obtained on the FCC website at:

www.fcc.gov/formpage.html

FCC Notice

This device complies with Parts 15 and 80 of the FCC Rules. Operation is

subject to the conditions that this device does not cause harmful

interference. Changes or modifications to this equipment not expressly

approved in writing by Raymarine, Incorporated could violate compliance

with FCC rules and void the operator’s authority to operate the equipment.

Station License

An FCC Ship Radio Station License and Call Sign are not required for most

recreational vessels travelling in US waters. Examples of radio equipment

that do not require a license include: marine VHF radios, any type of

Emergency Position Indicating Radio Beacon (EPIRB), any type of radar,

GPS or LORAN receivers, depth finders, CB radio, or amateur radio (an

amateur license is required). However, you must obtain a license if: (1) you

are required by law or treaty to carry a radio on your vessel; (2) your vessel

travels to foreign ports; (3) you use marine radio equipment on board your

vessel other than the devices listed above. Ships that use MF/HF single side-

band radio, satellite communications, or telegraphy must be licensed by the

FCC. If necessary, you can obtain a Station License by filing FCC Form 605,

which is available from the FCC website listed above.

81229_1.book Page 2 Wednesday, November 12, 2003 2:39 PM

Chapter 1: General Information 3

Operator License

An Operator License is not required to operate a VHF Marine Radio within

US territorial waters. However, a license is required to operate the radio if

you dock in a foreign port (including Canada and Mexico) or leave a foreign

port to dock in a U.S. port. You can request a Restricted Radiotelephone

Operator Permit from the FCC by filing Form 753.

INDUSTRY CANADA

You do not need a license to operate this radio within sovereign waters of

Canada or the US. You will need a license to operate this radio outside of

Canada or the US. To obtain Industry Canada licensing information, contact

the nearest field or regional office, or write:

Industry Canada

Radio Regulatory Branch

Attention: DOSP

300 Slater Street

Ottawa, Ontario

Canada, KIA OC8

The following information about the radio is required to complete the

license application:

Industry Canada Certification Number 4069823227AD-----------------

FCC Type Number PJ5RAY230--------------------------

FCC Type Accepted Parts 15 and 80------------------

Output Power 1 watt (low) & 25 watts (high)-----------------

Modulation 16FE (FM)----------------------------

Frequency Range 156.025-157.425-----------------------

81229_1.book Page 3 Wednesday, November 12, 2003 2:39 PM

4 Ray101 Handheld VHF Radio

81229_1.book Page 4 Wednesday, November 12, 2003 2:39 PM

Chapter 2: Installation 5

Chapter 2: Installation

2.1 Unpacking and Inspection

Use care when unpacking the unit from the shipping carton to prevent

damage to the contents. It is also good practice to save the carton and the

interior packing material in the event you must return the unit to the factory.

Equipment Supplied

The following is a list of materials supplied with the Ray101:

1

Only connect Cigarette Lighter Adapter to 12VDC system. Connecting to other voltage systems

can damage the charger.

2.2 Attaching the Antenna

Rotate the antenna clockwise to securely fasten it to the threaded connector

on the top of the radio.

Note: Do not operate the radio or press PTT without an antenna attached.

Table 2-1: Supplied Components

Part Number Description

E43026 RAY101 Handheld VHF Radio

81229 Ray101 Handbook

— Antenna

— Battery Tray

— NiMH Quick Charger

—

12VDC Cigarette Lighter Adapter

1

— Batteries, (6) AA NiMH (1300mAh)

— Wrist Strap

— Belt Clip

81229_1.book Page 5 Wednesday, November 12, 2003 2:39 PM

6 Ray101 Handheld VHF Radio

2.3 Attaching the Belt Clip

➤ To attach the belt clip and adapter:

1. Remove the belt clip and adapter hardware from the packing materials.

2. With the adapter button facing away from the Ray101, slide the adapter

into the notch on the rear of the radio until it snaps into place.

3. Hold the belt clip perpendicular to the Ray101 and slide the belt clip

notch onto the adapter button until it snaps into place.

4. Rotate the belt clip so that the longer end extends above the top of the

radio.

5. Squeeze together the two top ends of the belt clip and attach to your belt

or pant waist.

➤ To remove the radio from the belt clip:

1. Rotate the radio perpendicular to the belt clip.

2. Press the release button at the top of the belt clip.

3. Pull the radio up and away from the belt clip.

2.4 Attaching the Wrist Strap

1. Feed the narrow end of the strap through the two mounting holes at the

top of the radio behind the antenna.

2. Continue feeding the narrow end of the strap through the loop and pull

tight.

2.5 Battery Usage

The Ray101 can be powered by the supplied six (6) Nickel Metal Hydride

(NiMH) batteries or with six (6) regular AA alkaline cells (not supplied),

using the supplied Battery Tray.

Battery Tray

➤ To open the Battery Tray and insert the battery cells:

1. Using a coin or flat blade screwdriver, turn the screw at the base of the

unit counterclockwise1/4 turn to the UNLOCK position.

2. While holding the Ray101 in one hand, use the other hand to push the bat-

tery tray downward and then away to separate it from the back of the

radio.

81229_1.book Page 6 Wednesday, November 12, 2003 2:39 PM

Chapter 2: Installation 7

Figure 2-1: Removing and Attaching the Battery Tray

3. Lift up the tab located on the center right side of the battery tray cover

and remove it from the battery tray.

4. Locate the Battery Type switch just below the battery compartment and

turn to the appropriate position: ALKALINE or NiMH.

Figure 2-2: Removing the Battery Tray Cover

Remove

Attach

Battery Type Switch

(under batery cover)

81229_1.book Page 7 Wednesday, November 12, 2003 2:39 PM

8 Ray101 Handheld VHF Radio

5. Noting the proper orientation, install the AA cells in three rows of two

batteries each.

6. Replace the battery tray cover.

WARNING:

Be sure to set the Battery Type switch to the ALKALINE position before

operating the radio with alkaline batteries. Operating the radio with

alkaline batteries when the Battery Type switch is set to NiMH can cause

battery leakage or explosion resulting in damage or injury.

7. Slide the battery tray up into the rear of the radio and then downward until

it snaps into place.

8. Turn the screw at the base of the battery case clockwise to the LOCK

position.

Charging Rechargeable NiMH Cells

The NiMH batteries must be fully charged

before use. To charge the batteries:

1.Insert the radio with the battery tray attached

into the NiMH charger unit.

2.Connect the AC wall adapter into a standard

wall outlet.

or

Connect the Cigarette Lighter Adapter into a

standard 12VDC Cigarette Lighter.

3.Insert the molded plug into the connector on

the side of the battery charger.

The CHARGE indicator LED on the front of the

charger lights when it is receiving voltage from

the AC adapter.

RED means the batteries are charging.

GREEN means the batteries are fully charged.

Initial charging will complete in approximately 8

hours. Typical time for recharging is 3 to 5 hours.

CAUTION:

1.Make sure the switch just below the battery

compartment is set to the NiMH position.

2.Please follow the Battery Safety rules out-

lined at the front of this handbook.

LED

81229_1.book Page 8 Wednesday, November 12, 2003 2:39 PM

Chapter 3: Getting Started 9

Chapter 3: Getting Started

3.1 Keypad and Rotary Knobs

Several of the keys on the front panel of the base station serve multiple

purposes. For the most part, the function indicated on the first line of the key

is accessed by pressing and releasing that key. The function indicated on the

second line of the key is accessed by pressing and holding the key for three

seconds.

Figure 3-1: Ray101 Keys Layout

81229_1.book Page 9 Wednesday, November 12, 2003 2:39 PM

10 Ray101 Handheld VHF Radio

Rotary Keys

Push Keys

Description

1. PWR/VOL

Use this knob to turn the radio ON and OFF and to set the volume.

2. SQ

Use this knob to set the squelch threshold, which cuts off the receiver when

the signal is too weak for reception of anything but noise.

3. PTT

While pressing this Press-to-Talk key radio transmission is enabled.

Key Name Function

1. PWR/VOL Power radio ON / OFF and adjust volume level

2. SQ Adjust squelch threshold level

Key Name Press & Release (<3 sec) Press & Hold(>3 sec)

3. PTT Press-to-talk Press-to-talk

4. UP/DOWN Channel increment/decrement Rapid channel change

5.

Backlight ON/OFF Keylock ON/OFF

6. 16/9 Switches between the Priority

and Working Channels

Switches to secondary Priority CH (9);

If already tuned to secondary channel,

programs a new secondary Priority Channel.

7. DW/TRI Dual Watch Mode Tri Watch Mode

8. WX/BAND Weather Channel Mode Select frequency band

9. SCAN/SAVE Scan ON/OFF SAVE/DELETE channel to/from memory

10. HL/USER TX Power High/Low USER (Saved Memory Channel) Mode

81229_1.book Page 10 Wednesday, November 12, 2003 2:39 PM

Chapter 3: Getting Started 11

4. UP/DOWN

Use the arrow keys to change the current channel number.

5. Backlight / Keylock

Use this key to toggle ON or OFF the display’s backlight and the keylock

function, which protects the radio from any keypad entry.

6. 16/9

Use this key to switch to the priority channel or to change the value of the

Secondary Priority Channel.

7. DW/TRI

Use this key to select either the Dual Watch or Tri Watch modes. Dual Watch

monitors the current working channel and CH 16 in cycle. Tri Watch

monitors CH 16, the current working channel and the channel you have set

as the Secondary Priority Channel in cycle.

8. WX / BAND

Use this key to select the Weather mode or to alternate the frequency band

between the USA, International and Canadian channel sets.

9. SCAN / SAVE

Use this key to enter a Scan Mode or to enter a channel into the radio’s

memory.

10. HL/USER

Use this key to toggle the transmit power from HIGH to LOW and to enter

User Channel Mode, which displays only the channels that you have saved to

memory.

81229_1.book Page 11 Wednesday, November 12, 2003 2:39 PM

12 Ray101 Handheld VHF Radio

3.2 LCD Display

The following describes the functional characters on the Ray101’s LCD.

Figure 3-2: Ray101 LCD Layout

1. (TX) Transmitting

Indicates the PTT is being depressed and the radio is transmitting.

2. (RX) Receiving

Indicates that the radio is receiving a radio signal.If the radio receives a signal

but the squelch threshold is set so high that the signal cannot be heard, the RX

indicator is not displayed but the bar graph on the left side of the LCD is

illuminated to show the appropriate signal strength.

3. (USER) Favorite Channel Mode

Indicates the radio is in USER Mode. USER Mode displays only the

channels that you have saved to memory, enabling you to easily scan your

favorite channels while bypassing unwanted or seldom-used channels.

81229_1.book Page 12 Wednesday, November 12, 2003 2:39 PM

Page is loading ...

Raymarine PJ5RAY101 User manual

This manual is also suitable for

Raymarine PJ5RAY101 User manual

Related papers

Other documents