Drive Medical Design 15560 User manual

Brand: Drive Medical Design

Model: 15560

Type: User manual

Owner’s Assembly And Operating Manual

Ultra Light Plus, Semi Electric Bed

Competitor

Item # 15560

REV3.1.23.14

1. Remove contents from carton.

Assembly Instructions

2. Placebothendsofthesleepsurfaceontheirsideandaligntheangewiththereceptacleasshown.

3. Toattachtheheadandfootspring,pulltheblackknobawayfortheframeandslidethetwosides

 together.Thelockknobisspringloadedandwilllockintopositionwhenreleasedandthetwosections

 ofthebedareushtogether.

To disassemble the head and foot section, pull the black lock knob out and rotate the knob a quarter turn.

Thelockknobwillremainopentoallowtheheadsectiontoberemovedfromthefootsection.

Assembly Instructions Cont.

4. Securethesleepsurfacewiththecotterpinasshown.

5. Lockthecotterpinwiththeattachedclasp.Repeatontheoppositeside.

REV3.1.23.14

Assembly Instructions Cont.

6. NOTE:Beforeinstallingmotor,plughandpendantcableintomotorasshown

7. To install motor, remove locking caps on top of the motor.

HAND CONTROL

TheCompetitorbedcomeswithahandcontrolthatwill

illuminatewhenthebedispluggedintoagroundedor

polarizedwalloutlet,orwith9Vbattery(notincluded)

installedinthehandcontrol.Thehandcontrolwill

illuminateaslongasthewallorbatteryhaspower.With

thisbatteryinstalled,themotorcanbeoperatedtoreturn

the sleep surface to the horizontal position in the event of

apowerfailure.

Assembly Instructions Cont.

There are two methods for the installation of

the motor

Method A

Themotorisinstalledonthebedframewhentheframeisstanding

on its side.

Installation instructions can be found on pages 7-8.

Method B

The motor is installed from underneath the bed frame

(horizontaltotheground)

Installation instructions can be found on pages 10-11.

REV3.1.23.14

Assembly Instructions Cont.

A2. Align the opening on the head end of the

 motorwiththeangeontheheadsectionof

 thebedandinserttheangeintothemotor

compartment.

Actuator Bar

Flange

A3. Withthepalmofyourhand,snapthemotor

 ushtotheactuatorbar.

A4. Align the opening on the foot end of the

 motorwiththeangeonthefootsectionof

 thebedandinserttheangeintothemotor

compartment.

Method A

Installation of the motor when bed frame is on its side

A1. Priortoinstallation,makesurethatthe2whitemotorblocksareintheretractedposition.

CORRECT INCORRECT

A5. Withthepalmofyourhand,snapthemotor

 ushtotheactuatorbar.

A6. Once in place, replace the motor covers to secure the motor.

A6.Oncethemotorisattached,laybedatandinstallheadandfootboards.Thereare2height

adjustments on the head and foot board. Select the desired positions and hook the frame onto the foot

board.Slidelocktowardslegoffootboardtosecurepositionasshown.Repeatforoppositeside.

Assembly Instructions Cont.

Slide Lock

HEIGHT ADJUSTMENT

9. TheCompetitorbeddeckhastwoheightadjustments.

10. Adjustmentoneislocatedontheframeasindicatedbelow.Thereisahighpositionandalowposition.

11. Adjustmenttwoisonthelegoftheheadandfootboard.Toadjust,loosenthethumbscrewontheleg

andpullonthespringloadedknobwithonehandandslidethelegtothedesiredheightwiththeotherhand.

Oncethedesiredpositionisfound,turnthethumbscrewuntiltight.Adjustotherlegstothesameposition.

REV3.1.23.14

Assembly Instructions Cont.

End Method A

Thechartbelowindicatestheheightadjustmentsastheyrelatetothetwoadjustmentoptions.

*Rails cannot be used at this height.

Deck Height Pins

Leg Holes

Upper

Lower

1- High

1- Medium

1-Low

Deck Height (inches) Deck Height Pins Leg Hole Wheels

 11* Lower Low No

 13.125 Upper Low No

 14 Lower Low Yes

 14.152 Lower Middle No

 16.125 Upper Low Yes

16.25 Upper Middle No

 17.152 Lower Middle Yes

 17.875 Lower High No

 19.25 Upper Middle Yes

20 Upper High No

 20.875 Lower High Yes

 23 Upper High Yes

End Method A

Method B

Installation of the motor from underneath the frame

B2. Repeat for the other side.

Assembly Instructions Cont.

Deck Height Pins

Leg Holes

Upper

Lower

1- High

1- Medium

1-Low

B1. Attached head a foot board to frame.

REV3.1.23.14

Assembly Instructions Cont.

B4.Removethecoversfromthemotorandplaceunderthebedandalignedwiththeactuatorunderthehead

section. There are labels on the motor that provide direction and placement in relation to the head section.

B5.Withbothhands,liftthemotorandinsertintotheactuatorandframeasshown.Withthepalmofyour

handsnapthemotorushtoactuatorbar.

B3. Priortoinstallation,makesurethatthe2whitemotorblocksareintheretractedposition.

CORRECT INCORRECT

Assembly Instructions Cont.

B6. Once in place, replace the motor covers to secure the motor.

End Method B

REV3.1.23.14

Assembly Instructions Cont.

Oncethedesiredpositionisfound,turnthethumbscrewuntiltight.Adjustotherlegstothesameposition.

12.  Adjustmenttwoisonthelegoftheheadandfootboard.Toadjust,loosenthethumbscrewontheleg

  andpullonthespringloadedknobwithonehandandslidethelegtothedesiredheightwiththeother

hand.

Assembly Instructions Cont.

Thechartbelowindicatestheheightadjustmentsastheyrelatetothetwoadjustmentoptions.

*Rails cannot be used at this height.

Deck Height (inches) Deck Height Pins Leg Hole Wheels

 11* Lower Low No

 13.125 Upper Low No

 14 Lower Low Yes

 14.152 Lower Middle No

 16.125 Upper Low Yes

16.25 Upper Middle No

 17.152 Lower Middle Yes

 17.875 Lower High No

 19.25 Upper Middle Yes

20 Upper High No

 20.875 Lower High Yes

 23 Upper High Yes

HEIGHT ADJUSTMENT

13.  TheCompetitorbeddeckhastwoheightadjustments.

13A. Adjustmentoneislocatedontheframeasindicatedbelow.Thereisahighpositionandalowposition.

REV3.1.23.14

Assembly Instructions Cont.

14.TheCompetitorbedcomeswithacasteraccessory(soldseparately,model#15044SET).Toinstallthe

 casters,insertthestemofthecasterintothelegreceptacleasshown.Itisrecommendedtoinstall1

 non-lockingcasteroneachbedend.Thelockingcastersshouldbeinstalleddiagonallyfromeachother.

15. Toinstallbedrails,lifttheheadsectionandndtherailreceptaclelocatedontheframeofthebedasshown.

Assembly Instructions Cont.

16. Pullreceptacleoutwardandreturnheadsectiontotheatposition.

17. Turn the receptacle in order to receive the rail. Repeat for all four rail receptacles.

REV3.1.23.14

Assembly Instructions Cont.

18. Insert the bed rail into the receptacle. Repeat for the other rail.

NOTE: The competitor bed can be used with a free standing trapeze or a Drive Medical frame

mounted trapeze (Item # 15560TRAPEZE). A trapeze cannot be mounted on the Competitor head

board.

Driverecommendsthefollowingmaintenanceandcleaningproceduresbeconductedbetweenusers.

ELECTRONICS

• Checkallcontrolstomakesureallfunctionsworkproperly.

• Foot control

• Head control

• Checkallcablesfordamagedorfrayedwires.

 • Powercord

• Pendant cord

• Checktomakesureallplugsarefullyinsertedorattached.

• Check9Vbatteryonmotorandhandcontrolandreplaceannually.

BED FRAME & SLEEPING SURFACE

• Visuallycheckallwelds.

• Head section

• Foot section

• Main Frame

• Checkjointsbetweensleepingsurfacesectionsforloosefasteners.

CLEANING

• Themetalpartsofthebedarecoveredwithapowdercoating.Thebedcanbepowerwashed.

 Cleanallcoatedpartswithmilddetergentandwarmwater.Periodicallyraiseheadandfeet

 sectionsofthebedandremovedustfromframe.Also,periodicallyremovemattressandclean

mattress deck.

WARRANTY

• Lifetimewarrantyonwelds.

• 5yearwarrantyonframe.

• 5yearwarrantyonmotor.

• 5yearonhandcontrol.

• 1yearwarrantyonallotherpartsandcomponents.

Duringthewarrantyperiod,defectiveitemswillbereplacedatDrive’soptionatnocharge.

Maintenance & Safety Checks

REV3.1.23.14

99 Seaview Boulevard

Port Washington, NY 11050

Phone: 516-998-4600

Toll Free: 877.224.0946

Fax: 516.998.4601

www.drivemedical.com

Drive Medical Design 15560 User manual

Drive Medical Design 15560 User manual

Drive Medical Design 15560 User manual

Related papers

Other documents