Lenoxx 90313 Operational Instructions



CHILDRENSELECTRONICBATTERYOPERATEDMOTORTRICYCLE

OPERATIONALINSTRUCTIONS

Pleasereadthismanualindetailbeforeuse. 

Modelno:90313



WARNING:

Adultsupervisionisrequired.Donotdriveanywheredangerousincluding 

slopeswithmorethan10degrees,streets,nexttobodiesofwaterandaway

fromotherobstacles.Thedrivermustsitontheseattodrive.Readthe

instructionmanualandacknowledgeitbeforeuse.

1. Adultsupervisionrequired



2. Readtheinstructionmanualandinstructthechilduser

3. Theweightlimitis25kg

4. Onlyoneridertouseattheonetime

5. Pleasewearabikehelmetwhenriding

6. Sitstraightontheseatwhenriding

7. Rideonlyonflatsurfaces

8. Ride

awayfromothervehiclesandbodiesofwater

9. Rechargethebatteriesoutofreachofchildren

10. Donotchargethebatteryformorethan12hours

11. Wearshoeswhenriding

12. Onlyuseapoweradaptorandbatterybythemanufacturersadvice



1. SPECIFICATIONSOFTHEMOTORCYCLE:

Agerange:3–7

Maxspeed:3km/h

Measurements:80cmx36cmx52cm

Battery:Sealedanddry,6V4AH

Chargingtime:8hours

Loadingcapacity:25kg

2. HOWTOOPERATETHEBATTERYOPERATEDMOTORCYCLE:

1. Steponthepedaltostart,lift

footoffthepedaltostop.

2. Pressgoaheadtogoforward,pressbacktoreverse.Whentheswitch

isnotoneithermode,thebikewillnotdrive.

3. Wheningoforward,theheadlight willbeon.

4. Wheninreverse,thetaillightwillbeon.



5. Pressthesirenbuttontohearthesiren,pressthemusicbuttonto

hearthemusic.

3. SAFETY:

Pleaseinstructthechildonthecorrectwaytodrivethemotortricycle.

Pleasekeepinmindtheconditionoftheareatheyareridinginandthe

child’sdrivingability.

Designedforusebychildrenbetweentheagesof3–7years,weighing

lessthe25kg.Thisisadvisabletoavoiddamagetothemotor,gearsand

toprohibitoverloading.

Donotletchildrenrideinthestreet,anywheredangerousincluding

slopeswithmorethan10degrees,streets,nextto

bodiesofwaterand

awayfromotherobstacles.Useduringdaylighthoursorinan

illuminatedareaisadvisedtoavoidaccidentsinthedark.

Whenthemotortricycleisrunning,donotplaceanythingonthemoving

partssuchasthemotor,gearbox,wheelsorsteeringwheel. 

Donotdriveonlongorwetgrass,mud,softground,gravelorsand. 

Donotdriveneatanythingfla mmableorexplosive.Keepanyhazardous

chemicalsoutofthedriversreach.



4. HOWTOUSETHEBATTERY:

Itisnormalforthebatterytobewarmwhencharging.

1. Themotortricyclemustbechargedpriortoitsfirstuse.

WorkingACvoltageis220V(or1100V)(+/‐10%).

2. Chargingtimeis8‐12hours.Thefirsthourofchargingcan

getback

60%ofthebatteriesenergyba ck.Youmayleaveittocharge

overnight,butNEVERcontinuouslyover20Hours.Otherwiseyouwill

shortenthebatterieslife.



5. MAINTENCEANDTROUBLESHOOTING:

Factorswhichmayinfluencethemotortricyclesperformanceandlife

span:

‐ Howflatthedrivingsurface

is

‐ Theweightofthedriver

‐ Whetherthebatteryhasbeenfullycharged

‐ Whetherthemotortricycleisregularlyused

‐ Wetherwateroranyotherliquidhaserodedtheelectrical

components

Cleaning:Cleanthemotortricyclewithasoftdrycloth.Donotuseany

waxor

sprayliquidsforcleaning.Itcoulderodethepowerswitch.

Storage:Donotstorethemotortricycleinanareaofhightemperature,

humidityornearflames.Whenrainingorsnowing,keepthemotor

tricycleundercoverandoutoftheweather.

Donotchangethebatteriessetting,asit

cancausefireanddamagethe

electricalcircuitsystem.Donotchangethemotortricycleselectrical

circuitsystem.Anyrepairsdonetothisunitmustbecarriedoutby

authorisedandqualifiedservicepersonnel.

Donotallowchildrentochargethemotortricycle,playwiththebattery

ormotor.



Ifthemotortricyclewillnotbeusedforalongperiodoftime(3months

orlonger),itisadvisedthatyoufullychargethebatteryanddisconnect

itfromtheconnections.

Alongperiodofnonusewilldamagethebattery.Itisadvisedthatthe

batteryshould

bechargedonceamonth,evenifthemotortricycleis

notbeingused.

Anewbatterymustbefullychargedbeforeitsfirstuse.

Pleasetakecarewiththebatteryasitco ntains acidelectrolyte.Handling

ofthebatterybyadultsonly.

Ifthebatteryhaslea ked,donottouch

theacid.Placethebatteryintoa

polybaganddisposeofit.

Iftheelectrolytesplashesonyourskinorintoyoureyes,immediately

washwithwaterforatleast15minutesandconsultyourdoctor.

Donotcontactthebatteriestwoterminalswithanyothermetalobjects.

Itwill

causeshortcircuiting,damageorfire.

Adjustthef/rswitchtoonandpressthesirenbuttontocheckfor

power.Ifyouhearnomusic,checkthatthebatteryhasbeenjoinedup

correctly.Correctifrequired.

Neverpushorpullthemotortricyclebackwardwhenitisrunning.

notplugthechargerintoanynon‐workingorfaultywallsocket.This

couldcauseshortcircuitingorfire.

Inthecircumstanceofunstablevoltage,wesuggestthatyouequipa

regulator.



6. ASSEMBLY:

Warning:Childrencouldbeinjuredbysharpedges,sharpangles,small

componentsorelectricalcomponents.Takecarewhenassemblingor

disassemblingthemotortricycle.Keepthecomponentsandbatteryout

ofreachofchildren.



1. Themethodfromonesidetotheotherwhencompletedwillbe:

Nut,washer,passthroughtheholeofthefork,plasticwasher,

spacer,wheelcap,wheel,wheelcap,spacer,plasticwasher,pass

throughtheholeofthefork,washer,nut.

2. Putonthewheelcapsontothe

frontwheelonbothsides.

3. Addthespaceraftereachwheelcap,followedbytheplasticwasher

aftereachwheelcap.

4. Insertthefrontaxelontotheholesofthefork.

5. Putawasheroneachsideofthewheel.

6. Fastenthenutoneachsidewith

aspanner.



Addthefrontwheelcoverbyclippingitontotheforkabovethefrontwheel.



Fixthewindshieldontotheheadcoverwiththreeselftappingscrews.



Fixtheheadcoverontothebracketonthehandlebarusing3self

tappingscrews.



Ensuretheheadlightleadispas sedthroughthebackofthehandlebars

forconnectionlateron.



Attachtheplasticgaugepiecetothefrontbarsasbelow



Addthetoolboxtothemainbodyofthebike.

Insertthewiresofthesirenlightthrough theholesofthetoolbox.

Fixthealarmlightusing2selftappingscrews.

Fixthebracketunderthetoolboxusing4selftappingscrews.

Connectthetwopartsof

thetwothetoolbox(asshownintheabove

diagram).

Connectthewiresofthesirenlighttothetothoseofthemainbodyof

thebike.

Addthetoolboxandthebrackettotheholesonthemainbodyofthe

work.

Fastenwith2self

tappingscrews.



Jointhemainbodyofthemotortricycletothefrontendwiththefront

wheelusingtheboltandwasherandnutincluded. 



Usethenuttoscrewontothebolttoholdthepiecestightlytogether.

Headlightconnection:

Oncethemainbodyandthefrontendofthemotortricyclearejoined,youcan

thenconnectthewiresfromthemainbodytothewiresonthefrontend.This

isoptional

ifyouwouldlikethemotortricycletohaveaheadlightcomeon

whenthepedalispresseddownandthemotortricycleisdriving.



1. Steponthepedaltostart,liftfootoffthepedaltostop.

2. Pressgoaheadtogoforward,pressbacktoreverse.

Whentheforward/ reverseswitchisnotoneithermode,thebikewill

notdrive.

3. Wheningoforward,theheadlight willbeon.

4. Wheninreverse,thetaillightwillbeon.

5. Pressthesirenbuttontohearthesiren,pressthemusicbuttontohear

themusic.



Thebatteryislocatedundertheseat.



Toaccess,removethescrewholdingtheheatdownandthentaketheseatoff

thebody.



Thebatteryisheldinplacewithaplasticcover.Youcanremoveittoaccess

thebatterybyunscrewingthe4screws.

Plugtheredconnectorontotheredterminalofthebattery.Plugtheblack

connectorontotheblackterminalofthebattery.

Ifthebatteryisnot

connectedandyouchargethemotortricycle,thebattery

willnotbecharging.



Plugtheredconnectorontotheredterminalofthebattery.Plugtheblack

connectorontotheblackterminalofthebattery.

Ifthebatteryisnotconnectedandyouchargethemotortricycle,thebattery

willnotbecharging.

Theforward/reverseswitchmustnotbeoneithermodewhen

charging.

Chargingtimeis8–12hours.Thefirsthourofchargingcangetback60%of

thebatteriesenergyback.Youmayleaveitto chargeovernight,butNEVER

continuouslyover20Hours.Otherwiseyouwillshortenthebatterieslife.

Itisnormalforthebatterytobewarm

whencharging.

Themotortricyclemustbechargedpriortoitsfirstuse.

WorkingACvoltageis220V(or1100V)(+/‐10%).



Inserttheplugofthechargerintothechargingsocketwhichisonthemain

bodyofthebikeabovethesirenandmusicbuttons.

Connectthechargertothemo tortricyclefirst,andthenconnecttheplugto

power.Pleasenote,themotortricyclecannotbedrivenwhencharging.



Donotinsertanymetalpiecesintothechargingholeastoavoidshort

circuitingandanydamagetotheelectrocircuit.

Thisvehiclehasafunctionofchargingprotectionandwhileitisbeing

charged,otherfunctionscannotbeused.

Thisvehiclealsohasafunctionofoverload

protection.Ifthevehicleis

overloadedoroperat edincorrectly,theoverloadpreventerwillcutoff

automatically.Itwillconnectautomaticallyin20minutes.



Lenoxx 90313 Operational Instructions

Related papers

Other documents