Northern Tool and Equipment QCPS?28000 Owner's manual

Brand: Northern Tool and Equipment

Model: QCPS?28000

Category: Fireplaces

Type: Owner's manual

1



InstallationandOperatingManual

QCPS‐28000PelletStoveOwner’sManual



SAFETYNOTICE

PLEASEREADTHISENTIREMANUALBEFOREYOUINSTALLANDUSEYOURNEWPELLETSTOVE.FAILURE

TOFOLLOWINSTRUCTIONSMAYRESULTINPROPERTYDAMAGE,BODILYINJURY,OREVENDEATH.

IFTHISPELLETSTOVEISNOTPROPERLYINSTALLED,AHOUSEFIREMAYRESULT.FORYOURSAFETY

CAREFULLYFOLLOWINSTALLATIONINSTRUCTIONS.

CONTACTYOURLOCALBUILDINGORFIREOFFICIALSABOUTRESTRICTIONSANDINSTALLATION

INSPECTIONREQUIREMENTSINYOURAREA.

CONTACTYOURLOCALAUTHORITY(SUCHASMUNICPALBUILDINGDEPARTMENT,FIREDEPARTMENT,

FIREPREVENTIONBUREAU,ETC.)TODETERMINETHENEEDFORAPERMIT.

THISUNITISFORRESIDENTIALUSEBUTISNOTSUITABLEFORMOBILEHOMES.

SAVETHESEINSTRUCTIONS



We suggest that our products

be installed and serviced by

professionals who are

certified in the US by the

National Fireplace Institute

(NFI) as NFI specialists.

2



IMPORTANTNOTES

Thismanualidentifieshazardsandhasspecialsafetymessagesthathelpyouandothersavoidpersonal

injuryandevendeath.WarningandCautionsignalwordsareusedtoidentifythelevelofhazard.

However,regardlessofthehazard,beextremelycareful.

WARNING

Signalsahazardthatmaycauseseriousinjuryor

deathifyoudonotfollowtherecommended

precautions.





ImportantNotes 2

ImportantSafetyInstructions 3

PelletStoveOperationNotes 4

StoveAccessories 5

Installation 5

Venting 7

UsingCorrectFuel 14

OperatingInstructions 15

Refill 16

ShutDownProcedure 16

CleaningandMaintenance 17

Specifications 20

TroubleshootingandHelpfulHints 21

Warranty 22

CAUTION

Signalsahazardthatmightcauseminoror

moderateinjuryifyoudonotfollowthe

recommendedprecautions.



PLEASEREADTHISENTIREMANUALBEFORE

YOUINSTALLANDUSEYOURNEWPELLET

STOVE.FAILURETOFOLLOWINSTRUCTIONS

MAYRESULTINPROPERTYDAMAGE,BODILY

INJURY,OREVENDEATH.



FUEL:TheQCPS‐28000isapprovedtoburnPremiumWoodPelletsonly.Burningpeacoal,cherrypits, 

oranythingotherthanwoodpelletsisnotadvisedandwillvoidyourwarranty.



EACHUNITHASBEENTESTEDBEFORELEAVINGTHEFACTORYSOTHEREMAYBEALITTLERESIDUEOF

ASHESORPELLETSINSIDE.

STORETHISMANUALINASAF EPLACEFORFUTUREREFERENCE.



TABLEOFCONTENTS

We suggest that our products be

installed and serviced by

professionals who are certified in the

US by the National Fireplace Institute

(NFI) as NFI specialists

.

3



IMPORTANTSAFETYINSTRUCTIONS

Werecommendtheuseofsmokedetectorsandcarbonmonoxidedetectorswiththistypeofproductin

yourhome.Whenusingthesmokeorcarbonmonoxide detectors,followthemanufacturer’s

instructionsforplacementandoperationinyourhome.

WARNING

• Donottouchthepelletstovewhileitisburning.Allowatleast30minutestocooldownafterthe

flameisextinguishedforanyrefill,resta rt,cleaning,ormaintenance.

• Donotoperatetheunitwiththehopperopen.

• Thelidmustbeshutandtightlysecured.

•

Donotoperatewiththedooropen.

• Donottouchtheunitwhileoperatingorisstillhot.Contactcancauseskinburns.

• Keepchildrenandsmallanimalsawayfromthepelletstoveatalltimes.

• Donotstoreorplaceflammablematerialsclosethepelletstove.

• Keepcombustiblematerials(suchasgrass,leaves,etc.)atleast3feetawayfromtheflueoutleton

theoutsideofthebuilding.

• Restricttheuseofthisproducttopersonswhoread,understand, andfollowthewarningsand

instructionsinthismanualandontheunit.

CAUTION

• Professionalinstallationisrequiredforthisstove.

• Thepelletstovemustbeelectricallygroundedinaccordancewithlocalcodesorwithnational

electricalcodeANSI/NEPA70andCSA‐C22.1.

• Thestoveisdesignedforusewithpelletizedwoodonly.Donotburncoalorwoodlogsofany

kind.

Onlyburnpremiumwoodpellets.

• Thisstoveshallbeoperatedwithapowersourceforblowers,exhaustsystem,andfuelfeeding

system.

• Neverblocktheairsupplytoorfromthisstoveasitwillseriouslydegradetheperformanceand

causesmokingandsoot.

• Donot

burnhighashcontentpelletsbecauseitwillrapidlyfilluptheburningpotandaffectthe

combustion.

• Theunitisnotsuitableformobilehomes.



4



PELLETSTOVEOPERATIONNOTES

• Contactyourlocalbuildingorfireofficialsaboutrestrictionsandinstallationinspection

requirementsinyourarea.Callyourhomeowner’sinsurancerepresentative forinspectionofyour

stove’sinstallation.

• Readandcomplywiththeinstructionsinthismanual.

• ThisstoveisdesignedtoburnPremiumWoodPelletsonly.Burningpea

coal,cherrypitsoranything

otherthanpremiumwoodpelletswillvoidyourwarranty.Pelletswithhighashcontentwillnot

burncleanandwillrequiretheunittobecleanedmoreoften.Thisunitisdesignedforusewith

6mm(1/4in)diameterpelletfuel.Usingpelletslongerthan

50mm(2in)canbindtheaugerand

requirefrequentmanualremoval.

• Besureyourpelletsarenotdamporwet.Keepsawdustoutoftheunit.

• Use76mm(3in)ULapprovedPelletVentTwist‐LockPipewheninstallingthisstoveandfollowthe

manufacturer’sspecificationsfor

installationandclearances.Eventhoughthispipeinterlocks,itis

recommendedtosealallconnectionswithhightemperaturesilicone.Useatleastthreescrewsto

securethepipetothisunit’sexhaustblower.IfyoudonotuseULapprovedtwist‐lockpelletpipe,

besuretouseULapproved

pelletventpipeandfasteneachjointwithatleastthreescrews.

• Outsidecombustionairis mandatoryforthisunittoworkproperly.Makethisconnectionusing

48mm(1‐7/8in)IDmetalpipeandcoupler.Besuretosecurethepipetotheunitwithaclamp.The

outside

endshouldbecovered(screened)topreventanyforeignmatter fromenteringthesystem.

Trytokeepthenumberofbendsinthispipetoaminimum.

• Regularlyinspecttheburnpotareaandifanycrustforms,removeitwithapoker.

• Theashintheburn

potshouldberemovedregularlydependingontheburnrate.Keeptheairholes

oftheburnpotcleanforamoreefficientburning.Checkyourexhaustsystemfrequently.

• Keeppelletsandallothercombustiblematerialsatasafedistancefromtheunit.

• Thisunitrequiresfloorprotectionif

installedonacombustiblesurface.Theminimumfloor

protectionshouldgiveatleast152mm(6in)ofprotectionattherear,and101mm(4in)oneach

sideand152mm(6in)minimumatthefrontoftheunit.

• Horizontalrunsshouldnotexceed1.2m(4ft)

withamaximumverticalfluehe ightof10.6m(35ft).

• Thisunitshouldbeturnedoffandallowedtocoolpriortocleaning.Anyashesshouldbekeptinan

airtightmetalcontainerandnotdisposedofuntiltheyarecompletelycooled.

• Readtheinstructionsthoroughlyandsave

themforfutureuse.

• Donotallowpaint,chemicalsorconstructiondustonorneartheunit.Donotallow liquidorany

foreignmaterialsonorinsideyourunit.Shutyourunitdown,letcoolandthencoveritwhen

painting,duringconstructionorsimilaractivity.Wipeand

cleanyourunitifanyforeignmaterial

getsonorinsideyourunit.Unplugunitfirst,andthenvacuumandcleanthemotorandinsideof

theunit.

• Impropergasketmaintena nce,includingfailuretoreplacegaskets,cancauseairleaksresultingin

smoke‐backproblems.

5



• Thisunitisforresidentialusebutisnotsuitableformobilehomes.

STOVEACCESSORIES

Seebelowforaccessoriesincludedwithyourunit.



INSTALLATION

Removethefactorypackagingandfindasuitablelocationaccordingtothefollowingguidelines.

CLEARANCETOCOMBUSTIBLES

Thisstovemustbeinstalledwiththefollowingminimumclearancestothesideandbackwall

combustiblematerial.RefertoFigure1forverticalinstallationandFigure2forverticalcorner

installation.

Floorprotection:Minimum152mm(6in)inthefrontand152mm(6in)oneachside.

Thestovemust

beplacedoncontinuous(groutedjoints)ofnon‐combustiblematerialsuchasceramictile,cement

board,brick,9.5mm(3/8in)millboardorequivalentorotherapprovedmaterialsuitableforfloor

protection.

Note:Ceramictileoranytilemustbelaidonacontinuousnon‐combustiblesheet

topreventthe

possibilityofembersfallingthroughthesurface.Se eFigure3.

6



INSTALLATION

COMBUSTIONAIRSUPPLY

Aflexiblemetalpipeisprovidedwiththisstove.Attachthepipetotheinletatthestove’srear.See

Figure4fortheairintakeattherearofstove.AttachaRODENTGUARD–notincludedwiththisunit–

attheendandattachto

thewall.RefertoFigure5forinstallationofairintake.Fastenthepipeby

attachingtheTRIMCOLLARtowall.Allconnectionsmustbesecuredandmadeairtightbyusingeither

anappropriatelysizedhoseclampand/orUL‐181‐AP foiltape.

WARNING

• Donotusemakeshiftmaterialsorcompromisesintheinstallationofthisunit.

• Installventwithclearancespecifiedbytheventmanufacture.

7



INSTALLATION

Ifoutsideairisnotused,itisimportantthatcombustionairbeeasilyavailabletotheairinlet.Anair



VENTING

ThisunitiscertifiedforusewithULcertified/Listed76mm(3in)or101mm(4in)diameterinsize.This

unitcanbeventedinanexistingchimneywiththeadditionofalinerifthechimneyismorethan101

mm(4in)indiameter.Referto

theinstructionsprovidedbytheventorchimneymanufacturer,

especiallywhenpassingthroughawall,ceilingorroof.

Thisisapressurizedexhaustsystem.Allventconnectorjointsmustbesealed with500F(260C)RTV

siliconesealanttoensureconsistentperformanceandavoidsmokeandashspillage.Allhorizontal

connector

jointsmustbesealedwithUL181APfoiltape.Werecommendthatallverticalventconnector

jointsbesecuredwithaminimumof3screws.



EQUIVALENTVENTLENGTH

Thelongertherunofpipeinyourinstallation,themorerestrictionthereisinthesystem.Therefore

largerdiameterpipe

shouldbeusedforlongerruns.

Use76.2mm(3in)pipeifyouhavelessthan4.57m(15ft)ofEquivalentVentLength(EVL).

TocalculateEVL,usethefollowingconversiontable:

Qty TypeofPipe EVL(ft)



190degreeelbowor“T” 5



145degreeelbow 3



1ft Horizontalpiperun 1



1ft Verticalpiperun 0.5



Example:(3x1.22m[4ft]ofverticallength=3.66m[12ft]x0.5=6EVL)+(1xelbowor“T”=5EVL)+

(2x0.3m[1ft]ofhorizontallength=2EVL)

TotalEVL=13.So76.2mm(3in)

diameterventisallowed.

WARNING

• Donotinstallinabedroom.

CAUTION

• Donotconnectthisunittoachimneyflueservinganotherappliance.

• Donotinstallafluedamperintheventingsystemofthisunit.

• Installventatclearancesspecifiedbytheventmanufacture.

• Thestructuralintegrityofthemanufacturedhomefloor,wall,ceiling,roofmustbe

maintained.

8



VENTING

NOTE:ATALTITUDESOFMORETHAN914.4m(3000FT),WESUGGESTTHEUSEOF102mm(4IN)

DIAMETERVENTATANEVLof2.13m(7FT)ORMORE.



INSTALLATIONCONFIGURATION

HORIZONTALLYINSTALLTHROUGHWALL

NOTE:FOLLOWL‐VENTCHIMNEYMANUFACTURER’SINSTRUCTIONS.

1.PositionthestoveasFigures1&2andmaintaintheclearancespecifiedinFigure3.

2.Determinethepositionofholeinwallwheredirectlybehindstoveexhaustvent(refertoFigure4).

3.Alwaysmaintain152.4

mm(6in)clearancefromcombustiblematerials.

4.RefertoFigure7forinstallation.

5.InstallL‐ventwallthimbleperL‐ventmanufacturer’sinstructions.

6.Attachenoughpipingtogothroughandextendatleast152.4mm(6in)beyondexteriorwall.A

203.2m(8ft)verticalpiperun

issuggestedwherepossibletoreducethepossibilityofsmokespillage

causedbynegativepressure.

7.Attachcapandsealoutsidewallthimbleswithnon‐hardeningwater‐roofmastic.

8.Terminationshouldnotbelocatedsothathotexhaustgasescanignitetrees,shrubsorgrassesorbe

ahazard

tochildren.Exhaustgasescanreachestemperatureof260˚C(500F)andcauseseriousburns

iftouches.



9



VENTING

9.Locatedterminations:a)notlessthan0.91m(3ft)aboveanyforcedairinletlocatedwithin3.05m

(10ft);b)notlessthan1.22m(4ft)beloworhorizontallyfrom,oronefootabove,anydoor,window

orgravityairinletintoanybuilding;c)notless

than0.61m(2ft)fromanadjacentbuildingandnot

lessthan2.13m(7ft)abovegradewhenlocatedadjacenttoapublicwalkway.



VERTICALLYWITHCHIMNEYSYSTEM

1.FollowL‐Ventchimneymanufacturer’sinstructions.

2.Option–toachieveacenteredverticalinstallation,a45degree

elbowandaclean‐outteecanbe

usedtooffsetthepipefromtheexhaustoutlettotherearcenterofthestove.

3.Option–installL‐ventelbowinplaceofclean‐outtee.Locatestove.Dropplumbbobtocenterof

teeoutlet,markpointonceiling.

InstallceilingsupportandL‐ventpipeasperL‐ventmanufacturer’s

instructions.

4.Alwaysmaintain76.2mm(3in)clearancefromcombustiblematerials.Whenpassingthrough

additionalfloorsorceilings,alwaysinstallfire‐stopspacer.

5.Afterlinerisup,cuteitherroundorsquareholeinroof,always76.2mm

(3in)largeralltheway

aroundpipe.Installupperedgeandsidesofflashingunderroofingmaterials,nailtotheroofalong

upperedge.Donotnailloweredge.Sealnailheadswithflexiblewaterproofsealant.

6.Applyflexible,waterproofsealantwherethestormcollarmeetsthevent.Slidestorm

collardown

untilitsitsontheflashing.Sealandinstallcap.



10



VENTING





11



VENTING

VERTICALLYINTOEXISTINGCHIMNEYSYSTEM

Asanalternate,76.2or101.6mm(3or4in)L‐ventcanberuninsideexistingchimneytotermination

(refertoFigure10).



VERTICALLYINTOEXISTINGMASONRYFIREPLACE

1.FollowL‐ventchimneymanufacturer’sinstructions.

2.Havethemasonrychimneyinspectedbya

qualifiedchimneysweeporinstallertodetermineits

structuralintegrity.

3.Runthepipefromthestoveoutletto457.2mm(18in)abovethetopofchimney.

4.Installablanketplateandthechimneypipe,andifusedtheoutsideairpipeasshowninFigure11.

5.Attach

theDuraVentadaptor,asectionofpipeandcleanouttee,makesurethecleanoutteeis

centeredinthechimneyfluearea.UseRTV,metallictapeandaminimumofthreeself‐tapingscrews

atalljointconnectionstoensureatightseal.

6.Positionthestoveadhering

totheclearancespe cifi edinFigure1&2.

7.Measureandbuildchimneytopplate.Cutoutholesforchimneypipe,andifusedtheoutsideair

pipe.Installandsealwithflexiblewaterproofsealanttopreventwaterleakage.Installventcap.



12



VENTING



INSTALLATIONTHROUGHSIDEOFMASONRYCHIMNEY

1.FollowL‐ventchimneymanufacturer’sinstructions.

2.Positionthestove,adheringtotheclearanceinFigures1&2.Markthecenteroftheholewherethe

pipeistopiercethemasonrychimney.

3.Itwillbenecessarytocutoutthe

masonryaroundthelocationofthepipecentermark.Cuta101.6

mm(4in)diameterholefor76.2mm(3in)pipeand127mm(5in)diameterholefor101.6mm(4in)

pipe.

4.Measureandbuildchimneytopplate.Cutoutholeforchimneypipeandif

usedfortheoutsideair

pipe.

5.Installtheteeonthebottomoftheverticalpipesystemandloweritdownthechimneyuntilthe

centerbranchoftheteeislevelwiththecenteroftheholeinmasonryasshowninFigure12.

6.Installandseal

thetopplatefromstep3withflexiblewaterproofsealant.Slipthestormcollarover

thepipeandwhileholdingthepipeattheproperelevation,affixthecollarwithaminimumofthree

6.35mm(1/4in)stainlesssteelmetalscrews.Sealalljointsandseamsaroundthecollar.

Connectthehorizontalpipebypushingitthroughtheholeinthemasonryandliningitupwiththe

branchinthetee.Pushthepipeintotheteewhile twistingittolockthetee.



13



VENTING

8.Ifneeded,oncethehorizontalpipeisinplace,thespacebetweenthepipeandmasonrymaybefilled

withhightemperature grout.

9.Installthetrimcollar.Anadjustablepipelengthandadaptormaybeneededtoalignandcomplete

theconnectiontothestove.



CONNECTIONOFCOMBUSTION

AIRSUPPLY

STEP1:AttachTrimCollartothewallinsidethehouseand attachwith4screws.

STEP2:AttachRodentGuardCovertothewalloutsidethehouseandattachwith4screws.

STEP3:AttachtheMetalPipetoAirIntakeatthebackofstove(See

Figure4forlocationofAirIntake)

andattachwithPipeClamp.

STEP4:RoutetheMetalPipeintothewallandfixtheotherendofMetalPipeintoRodentGuard.

STEP5:AttachtheRodentGuardontothecover.

STEP6:AttachExteriorCovertoRodentGuardCoverand

attachwith2screws.



14



VENTING



USINGCORRECTFUEL

Thisstoveisdesignatedforburning pelletizedwoodfuelonly.Pelletof6.35mm(1/4in)or21.17mm

(5/6in)indiameterandapproximately25.4mm(1in)longshallbeused.Longerorthickerpellets

sometimebridgetheauge rflights,whichpreventsproperpelletfeed.

Burningwoodinforms

otherthanpelletsisnotpermitted.Itwillviolatethebuildingcodesforwhich

thestovehasbeenapprovedandwillvoidallwarranties.

Thisstovefeedpelletsatpresetrates,addingfuelbyhandwillnotincreaseheatoutputbutmay

seriouslyimpairthestoveperformancebygeneratingconsiderable

smoke.

Donotburnwetpellets.

Thestoveperformancedependsheavilyonthequalityofyourpelletfuel.Avoidtheuseofpelletwhich

isexcessfines,withbinderandhighashcontent.





WARNING

• Donotuseanyflammableliquidssuchasgasoline,gasoline‐typelanternfuel,kerosene,charcoal

lighterfluid,orsimilarliquidstostartorfreshen‐upthefire!Keepallsuchliquidswellawayfrom

theheaterwhileitisinuse.

15



OPERATINGINSTRUCTIONS

1. SETTHEAIRINLETDAMPERS

Itisnotpossibleforthemanufacturetofactorysetyour

stovetoworkproperlywithoutsomeadjustments.The

dampershelpcontroltheamountofairflowsupplied

forcombustion.



AdamperPUSHEDINalltheway,maximizesconcentrated

airflowtotheburnpot.

Thiswillmaintainarobustfire.

TheAugertimingisdesignedtoberun,inmostconditions,

withthedampersclosed.



Insomeareas/conditions,itmaybebenecessarytoadjust

thedamperopenslightlyinordertoslowdowntheflame

andallowthepelletstokeeppacewiththe

rateofburn.

Thisshouldbemonitoredcloselytoensureyouhavethe

properfeedrateestablished.

Ifdampersareopened

toomuch,therateofburnwillbeveryslowandthe

pelletswillbuildup.



THISSETTINGNEEDSTOBEFINETUNEDTOACCORDING

TOYOURLOCATIONANDELEVATION.ITISRECOMMENDED

THATYOUSTARTWITHTHEDAMPERSPUSHEDINTOSTART.

2. OPENINGANDCLOSINGTHEMAINDOOR

Openthestovedoorbyrotatingthehandlecounterclockwise,towardthetopofthestove.

Makesure

thestovedoorispushedfirmlyagainstthestoveandinthelockedpositionbeforestartingstove.

3. FILLTHEHOPPERWITHFUEL

Ensurethehopperiscleanofanydebris,manuals,orotherforeignobjectsthatcouldjamupthefuel

feedauger.Usepelletsmadefromsawdust

and/orotherwoodby‐products.Premiumgradepelletswill

producethehighestheatoutput.



4. Connecttheplugintostandard120Vac,60Hzoutlet.PressO/Ioncetostartlighting.

WARNING

• Donotuseanyflammableliquidssuchasgasoline,gasoline‐typelanternfuel,kerosene,charcoal

lighterfluid,orsimilarliquidstostartorfreshen‐upthefire!Keepallsuchliquidswellawayfrom

theheaterwhileitisinuse.

• Makesurehopperlidandfrontdoorof

thestovehavebeentightlyclosedbeforestartingstove.

Airinletdampers

16



OPERATINGINSTRUCTIONS

5. Theunithasenteredthestart‐upperiodandpelletisnowfeedingunderthepre‐setrate.

6. After5minutes,thepelletisthenburningnormallyandyoucanselecttheHEATLEVELandBLOWER

airflowasbelow:

ADJUSTHEATRATE–PressUPandDOWNbutton

atleftsideofcontrolpaneltoselectpelletfeed

ratetoadjusttheheatouput.



 TheLEDdisplayatleftshallshow1–LOW,2–MEDIUM,3–HIGH.



REFILL

1.PressI/OswitchoncetoturntheunitOFF.

2.Thepelletwillstopfeedingbuttheunitwillrunforafewminutes.

3.Aftertheunitiscooled,openhopperlidandfillpelletsintohopper.

4.RestarttheunitbypressingO/Ionce.



SHUTDOWNPROCEDURE

PressO/IoncetoturntheunitOFF.Theblowerandexhaustfanwillrunforafewminutesuntilthe

pelletsinfireboxarecompletelyburnt.Theunitcanonlyberestartedwhentheinternaltemperature

fallenintopresetlevel.



WARNING

• Keephopperlidandfrontdoorclosedatalltimes.Donotoverfillhopper.

17



CLEANINGANDMAINTENANCE



1.Disposetheashbypullingouttheashdrawer.Puttheashintoair‐tightmetalcontainerandwaitfor

finaldisposal.Themetalcontainerorashshallbeplacedonanon‐combustiblesurfaceoronthe

groundandwellawayfromallcombustiblematerial.Replacethe

ashdraweraftercleaning.Make

surethedrawerispushedallthewayinandlevel.

2.Openthedoor.Sweeptheashesonthefrontglassbythebrushprovided.



3.Sweeptheashesoninsidesurfaces.

CAUTION

• Makesuretheunitiscooledandunpluggedbeforeanymaintenanceandcleaning.

WARNING

• Failuretocleanandmaintainthisunitwillresultinpoorperformanceandsafetyhazards.

• Nevercleantheunitwhenhot.

• Makesureashesarecooltothetouchbeforeusingvacuum.

18



CLEANINGANDMAINTENANCE



4.Pullouttheburningpotandsweeptheburningpotbybrush.Alsosweeptheinsidesurfaceoffire

box(aroundtheburningpot)thoughtheopeningintoAshdrawer.Puttheburningpotbackinplace.

Makesureitislevelandallthewayin.



5.Remove4hexscrewsatthebackcoverbyHexscrewdriverprovided.Theexhaustblowerandpellet

feedingassemblyareasshownbelow.Cleantheexhaustblowerandpelletfeedingassemblyby

vacuum.

WARNING

• Makesurethefrontdooriscompletelyclosedbeforeyouoperate.

19



CLEANINGANDMAINTENANCE





Note:Donotfurtherdisassembletheinsideparts/component.Iffurtherrepairorreplacementof

partsisneeded,callcustomerservice.

EXHAUSTBLOWERASSEMBLYDIAGRAM



20



CLEANINGANDMAINTENANCE

PELLETFEEDINGMOTORASSEMBLYDIAGRAM



SPECIFICATIONS

 Model:………………………………………………………………………………….QCPS‐28000

 Width:……………………………………………………………………………..55cm(21.6in)

 Depth:………………………………………………………………………….52.5cm(20.6in)

 Height:…………………………………………………………………………….75cm(29.5in)

 Weight:…………………………………………………………………………80kg(176.3lbs)

 HopperCapacity:…………………………………………………Upto22kgs(48.5lbs)



(Hoppercapacitymayvaryslightlydependingonpelletsize,length,anddiameter) 

 BurnRate:………………………………………………………...Maximum2kgs(4.4lbs)

 BTURange:……………………………………………………………………………28000 BTU

 ElectricalRating:…………………………………………………………………120Vac,60Hz

 LightCycle:……………………………………………………………………………………..410W

 ContinuousCycle:…………………………………………………………………………..110W





Page is loading ...

Northern Tool and Equipment QCPS?28000 Owner's manual

Brand: Northern Tool and Equipment

Model: QCPS?28000

Category: Fireplaces

Type: Owner's manual

Download PDF

report

Northern Tool and Equipment QCPS?28000 Owner's manual

Northern Tool and Equipment QCPS?28000 Owner's manual

Other documents