Appalachian Stove & Fabricators UV-EF-MIL 30-N Installation And Operating Instructions Manual

Brand: Appalachian Stove & Fabricators

Model: UV-EF-MIL 30-N

Category: Fireplaces

Type: Installation And Operating Instructions Manual

This manual is also suitable for

InstallationandOperatingInstructionsforUnventedZeroClearanceFireplaceHeaters

UV36RFP &UV-42RFP

INSTALLER:Leavethismanualwiththeappliance.

CONSUMER:Retainthismanualforfuturereference.

InstallationandOperatingInstructionsforGasLogHeaters

ModelsUV-EF-MIL (24/30)-N ANDUV-EF-MIL (24/30)-P

MODEL UV-EF-MIL 24P

UV-EF-MIL 30P

ForusewithPropane/LP gas

WARNING:Iftheinformationinthismanualis

notfollowedexactly,afireorexplosionmay

resultcausingpropertydamage,personalinjury,

orlossoflife.

WHATTODOIF YOUSMELL GAS

*Donottryandlightanyappliance.

*Donottouchanyelectricalswitch.

*Donotuseanyphoneinyourbuilding.

*Immediatelycallyourgassupplierfroma

neighbor’sphone.Followyourgassupplier’s

instructions.

*Ifyoucannotreachyourgassupplier,callthe

firedepartment.

*Installationandservicemustbeperformedbya

qualifiedinstaller,serviceagency,orthegas

supplier.

Donotstoreorusegasolineorotherflammable

vaporsandliquidsinthevicinityofthisoranyother

appliance.

Thisisanunventedgas-firedheater.It

usesair(oxygen)fromtheroomin

whichitisinstalled.Provisionsfor

adequatecombustionandventilation

airmustbeprovided.(Seepage3for

additionalinformation).

The AppalachianStoveandFabricators

329EmmaRd.

Asheville,NC28806

Phone:(828)-253-0164

158-L-09-5Fax:(828)-254-7803

The AppalachianStove

MODEL UV-EF-MIL 24N/

UV-EF-MIL 30N

ForusewithNaturalGas

UNVENTEDGAS APPLIANCE

WARNING: Thisapplianceisfor

installationonlyinasolidfuel

burningmasonryorUL 127

factorybuiltfireplaceorina

listedventlessfireboxenclosure.

Ithasbeendesigncertifiedfor

theseinstallations.Exception:

DONOT installthisappliancein

afactorybuiltfireplacethat

includesinstructionsstatingit

hasnotbeentestedorshould

notbeusedwithunventedgas

logs.

Stateorlocalcodesmayonly

allowoperationofthisappliance

inaventedconfiguration.Check

yourstateorlocalcodes.

THIS APPLIANCEMAY BE

INSTALLEDIN AN

AFTERMARKET,

PERMANENTLY LOCATED,

MANUFACTURED(MOBILE)

HOME,WHERENOT

PROHIBITEDBY LOCAL

CODES.

THIS APPLIANCEISONLY FOR

USEWITHTHETYPEOFGAS

INDICATEDONTHERATING

PLATE.THIS APPLIANCEIS

NOTCONVERTIBLEFORUSE

WITHOTHERGASES.

USPatent#5,397,233,#5,591,024and

otherPatentsPending

ThisunittestedtotheUnventedRoomHeater

Standard ANSZ21.11.2a-2008

Thisapplianceoperatesasanunventeddomesticroom

heaterwhenfittedtoamasonryorfactorybuiltfireplacewith

thefluedamperclosedorasadecorativeappliancewhenthe

fluedamperisfullyopen.Itmustnotbeusedforanyother

purposeandmustbefittedinamasonryorfactorybuilt

fireplace.Ifcertainrequirementsaremet,thenthisproduct

alsoqualifiesunder ANSZ21.60b-2004 CGA2.26b-2004

DecorativeapplianceforinstallationinSolid-FuelBurning

Fireplaces.

•

Contents

ImportantInformation.......................................................Page3

Installation.........................................................................Page4

Unpacking........................................................................Page5

FireplacePreparation.......................................................Page5

LogPositioning.................................................................Page5

GasConnection................................................................Page4

GasPressureCheck.........................................................Page4

InstallationandClearances...............................................Page4-5

InstructionsforVented Applications..................................Page8

LightingInstructions..........................................................Page6

To TurnOffGas Appliance................................................Page6

............................................................................Page7

ExplodedView...................................................................Page7

ImportantSafeguards.......................................................Page10

Cleaning............................................................................Page10

Servicing...........................................................................Page10

RepairParts......................................................................Page10

LimitedWarrantyPolicy....................................................Page11

FlameCheck.....................................................................Page7

PartsList

Important Information

WARNING: ANY CHANGE TO THIS HEATER OR ITS

CONTROLS CAN BE DANGEROUS.

IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY

BEFORE INSTALLING.

WARNING:

Due to high temperatures, the appliance should be located

out of traffic and away from furniture and draperies.

Young children should be carefully supervised when they

are in the same room as the appliance. Children and adults

should be alerted to the hazard of high surface temperatures,

and should stay away to avoid burns or clothing ignition.

The appliance should be inspected before use and at least

annually by a professional service person. More frequent

cleaning may be required due to excessive lint from

carpeting, bedding material, et cetera. It is imperative that

control compartment, burners, and circulating air

passageways of the appliance should be kept clear. See

cleaning instructions.

DO NOT place clothing or other flammable materials on or

near the appliance.

Installation and repair should be done by a qualified

service person.

Any safety screen or guard removed for servicing an

appliance must be replaced prior to operating the heater.

“ This appliance is intended for supplemental heating”

This appliance must be installed only in a solid fuel

burning fireplace with a working flue and constructed of non-

combustible materials, or UL 127 factory built fireplace or in a

listed ventless firebox enclosure. Exception: DO NOT install this

appliance in a factory built fireplace that includes instructions

stating it has not been tested or should not be used with unvented

gas logs.

The appliance area must be kept free and clear of combustible

materials, gasoline, and other flammable vapors and liquids. Solid

fuels shall not be burned in a masonry or UL 127 Factory-Built

Fireplace in which an unvented room heater is installed.

This appliance must only be used with pressures at the inlet

shown in Table 1.

The installation must conform with local codes, or in the

absence of local codes, with the NATIONAL FUEL GAS CODE

ANSIZ23.1/NFPA 54.

The appliance and its appliance main gas valve must be

disconnected from the gas supply piping system during any

pressure of that system at test pressures in excess of 1/2PSIG

(3.5 kPa).

The appliance must be isolated from the gas supply piping

system by closing its equipment shut off valve during any testing

of the gas supply piping system at test pressures equal to or less

than 1/2PSIG (3.5 kPa).

DO NOT use this heater in a bedroom, bathroom, or in a

recreation vehicle.

An unvented room heater having input rating of more than

10,000 Btu per hour shall not be installed in a bedroom or

bathroom.

DO NOT use this heater if any part has been under water.

Immediately call a qualified technician to inspect the appliance

and replace any part of the control system and any gas control

that has been under water.

ALWAYS OPERATE THE APPLIANCE AT THE MARKED

POSITIONS. NEVER OPERATE THE HEATER AT A SETTING

BETWEEN THESE POSITIONS, AS THIS COULD RESULT IN

IMPROPER COMBUSTION AND EXCESSIVE CARBON

MONOXIDE EMISSIONS.

WARNING: Glass doors must be in a fully open position when the

appliance is in operation.

Keep burner and control compartment clean. See installation and

operation instructions elsewhere in this manual.

WARNING: During manufacturing, fabricating, and shipping,

various components of this appliance are treated with certain oils,

films, or bonding agents. These chemicals are not harmful, but may

produce annoying smoke and smells as they are burned off during the

initial operation of this appliance, possibly causing headaches or eye

and lung irritation. This is a normal and temporary occurrence. The

initial break -in operation should last 2-3 hours with the burner at its

highest setting. Provide maximum ventilation by opening windows,

doors, and the chimney flue to allow odors to dissipate. Any odors

remaining after this initial break-in will be slight and disappear with

initial use.

The installation of appliances designed for manufactured homes

(U.S. Only) or mobile home installation must conform with the

standard in Canada, or with the

in the United States, or when such a standard is not

applicable,

Provide a 1/8 NPT plugged tapping accessible for test gauge

connection, immediately upstream of the gas supply connection to the

appliance.

This appliance can not be converted for use with other types of

gasses.

When used as an unvented heater, always ensure that there is

adequate ventilation for the room where the appliance is

operating. “This heater shall not be installed in a room or space

unless the required volume of indoor combustion air is provided by

the method described in the

.” “The

defines a confined space as a space whose volume is less than

50 cubic feet per 1,000 Btu per hour (4.8 m3 per kw) of the

aggregate input rating of all appliances installed in that space.

Rooms communicating directly with the space in which the

appliances are installed through openings not furnished by doors

are considered part of the unconfined space.

WARNING: If the area in which the heater may be operated does

not meet the required volume for indoor combustion air, combustion

and ventilation air shall be provided by one of the methods described

in the

or applicable local codes.

Unusually tight construction is defined as construction where:

(A) Walls and ceilings exposed to the outside atmosphere have a

continuous water vapor retarder with a rating of 1 perm (6x10-11 kg

per pa-sec-m 2) or less with openings gasketed sealed.

(B) Weather stripping has been added on openable windows and

doors.

around windows and door frames, between sole plates and doors,

between wall and ceiling joints, between wall panels, at penetrations

for plumbing, electrical and gas lines and at other openings.

Example of room dimension limitations: If this appliance is listed at

40,000 Btu’s, then the room cannot be less than 50 cubic feet for each

1,000 Btu’s or 2000 Cubic Feet. As an example, if the room is 11 ft. Tall,

12 ft. Wide, and 14 ft. Deep (11x12x14 = 1848), then it must be

provided with adequate combustion and ventilation air.

This appliance is equipped with an ODS (oxygen depletion

sensor) pilot light safety system designed to shut itself off if not enough

fresh air is available. Additional ventilation may be obtained by

opening a door to another room or opening a ventilating window.

National Fuel Gas Code, ANSI

Z223.1/NFPA 54, the International Fuel Gas Code, or applicable

local codes National Fuel Gas Code, ANSI Z223.1/NFPA

National Fuel Gas Code, ANSI Z223.1/NFPA 54, the

International Fuel Gas Code,

CAN/CSA Z240 MH, Mobile Housing,

Manufactured Home Construction and Safety Standard, Title 24 CFR,

Part 3820,

ANSI/ NCBS A225.1/ NFPA 501A, Manufactured Home

Installations Standard.

GASCONNECTION

GASPRESSURECHECK

CHECKGAS TYPE.Useonlythegastype

indicatedontheheater’sratingplate.Ifthe

gaslistedontheplateisnotthetypeofgas

supplyDONOT INSTALL.Contactyourdealer

forpropermodel.

AlwaysuseanexternalregulatorforallLP

appliancestoreducethesupplytankpressure

toamaximum13”WC. Thisisinadditionto

theregulatorfittedtotheheater.

WARNING:Connectiondirectlytoan

unregulatedLP tankcancauseanexplosion.

Thenormalgasconnectionis3/8”madeat

theleftsidefacingtheunit.Ifarightside

connectionisrequired,theconnectingpipe

maybeleadbehindtherearoftheappliance

toterminateattherighthandsidefor

connectiontotheinletoftheappliance.

Testforleaksusingasoapandwater

solutionaftercompletion.DONOT USE

OPENFLAME.

Checktheinletpressuretotheappliance

toensurethatitisasshowninthetable

below. Theminimuminputcanbeobtainedby

turningtheadjustablecontrolknobtoits

lowestsetting.

TABLE1

Thepressureiscontrolledbytheregulator

andshouldbecheckedatthepressuretest

pointlocatedinthecontrolvalvebody. Access

tothepressuretestpointisobtainedby

removingalllogs.

Thepressureshouldbecheckedwiththe

applianceburningandthecontrolsetonhigh.

Thepressureregulatorispresetand

lockedtoavoidtampering.Ifthepressureis

notspecified,replacethewhitereplacement

partUV-001BfornaturalgasandUV-026Bfor

propaneonly.

Aftermeasuringthepressure,replacethe

testpointplug,ensuringnoleaks,replacing

theheatshieldwhereappropriate,andthe

logsintheirspecifiedpositions.

MODEL UVEF-MIL24,30NUVEF-MIL 24,30P

GASNATURAL (N)PROPANE(LP)

Max.HeatInput39,000BTUH35,000BTUH

Min.HeatInput23,000BTUH23,000BTUH

GasInletPressure

Max.10.5ins.WC13.0ins.WC

Ideal7.0ins.WC11.0ins.WC

Min.4.5insWC10.0ins.WC

(Minimumforpurposeofinputadjustmentonly)

RegulatorPressure3.5insWC10ins.WC

INSTALLATION ANDCLEARANCES

WARNING:Beforeinstallinginasolidfuelburningfireplace,

thechimneyfluemustbecleanedofsoot,creosote,ashes,and

loosepaintbyaqualifiedchimneycleaner.

WARNING:Donotallowfanstoblowdirectlyintothe

fireplace. Avoidanydraftsthatalterburnerflamepatterns.

WARNING:Thisapplianceisforinstallationinasolidfuel

burningfireplaceonly.

WARNING:Failuretokeeptheprimaryairopening(s)ofthe

burner(s)cleanmayresultinsootingandpropertydamage.

Toensuresafeinstallationintoamasonryorfactorybuilt

fireplace,thefollowinginstructionsmustbecarefullyobserved.

1.SidewallClearances: Theclearancefromthesidepfthis

appliancetoanycombustiblewallshouldnotbelessthan15”.

2.CeilingClearances: Theceilingheightshouldnotbelessthan

42”fromthetopofthefireplaceopening.

3.MantelClearances:Inordertoreduceclearances,acanopy

(model#1510-0140)maybeused.Refertofigure4B&4Conpage5

foracleardefinitionofclearances.

Important: Airopeningsshallnotbeobstructedinanywaywhen

installingthisgasappliance.

Thefireplacescreenmustbeinplacewhentheapplianceis

operating,andunlessotherprovisionsaremadeforcombustionair,

thescreenshallhaveanopeningfortheintroductionofcombustion

air.

Theleftandrightsidesaredeterminedwhenfacingthefrontof

theappliance.

Withnocanopyused(Figure4B)theclearancefromthetop

edgeofthefireplaceopeningtoa2½”mantelis28,”6”mantelis

38,”anda10”mantelis44.”

Withoutlouversandthecanopyinposition(Figure4C)the

clearancefromthetopedgeofthefireplaceopeningtoa2½”mantel

is16,”6”mantelis20,”anda10”mantelis26.”

Withlouversandcanopyinposition(Figure4D)theclearance

fromthetopedgeofthefireplaceopeningtoa2½”mantelis18,”6”

mantelis24,”anda10”mantelis30.”

Themantelpieceprofilemustfallwithinthecrosssectionas

showninthefiguresonthenextpage.

(Sectioncontinuedonfollowingpage)

Pressure TestPoint

Left Right

FRONT OFBURNER

(Continuedfrompreviouspage)

Thecanopymustbeinstalledinaccordancewiththeinstructions

providedwithit.

Noncombustiblematerialsusedinthisinstallationsuchasslate,

marble,tile,etcetera,mustbeatleast½”thick. Thereshouldbeno

combustiblematerialinstalledbehindsheetmetal.

Failuretoinstallnoncombustiblematerialabovetheopeningas

specifiedwiththeseinstructionsmaycausedamagetothematerialsused

orcauseafirehazard.

Installation

WARNING:Before

installinginasolidfuel

burningfirebox,the

chimneyflueandfirebox

mustbecleanedofsoot,

creosote,ashesandloose

paintbyaqualified

chimneycleaner.

WARNING:Outsideair

ducts,and/orashdumps

inthefireplacemustbe

permanentlyclosedatthe

timeofappliance

installation.

WARNING:Donot

allowfanstoblowdirectly

intothefireplace. Avoid

anydraftsthatalterburner

flamepatterns.

WARNING:Donotuse

ablowerinsert,heat

exchangerinsert,orother

accessorynotapproved

withthisheater.

PositioningLogs

Unpacking

FireplacePreparation

Opencartonandremove

chassisfromitslocation.

Removeeachofthelogsby

grippingateitherendofthe

logwhileavoidingany

unduepressure.

Thefirstcartoncontains

thefollowingitem:

Burner

Thesecondcarton

containsthefollowingitems:

1.Rearlog

2.CenterRightLog

3.Frontleftlog

4. Topleftlog

5. Topcenterlog

6. Toprightlog

Beforeinstallation,the

dampermustbesecured

opentothepropersize.

Refertothechartonpage5

foradditionalinformation.

Thefireplacemustbe

preparedbeforeinstallation:

A. Turnoffthegassupply

tothefireplace.

B.Cleanthefireplace

floorandchimney(ifused)

ofanyashes,soot,

creosote,orobstruction.

Thiswillminimizeanysmell

fromthefireplace.We

recommendcleaningbya

chimneysweep.

Carefullypositionlogsas

shown:PositionLog#2

betweenfrontgrateand

mainburners. Thenposition

Log#1onrearsupporters,

pushingbackasfaras

possibleandintonotches.

ThenplaceLog#3around

theleftgratebar.PlaceLog

#4onLog#2andframeas

shown. ThenplaceLogs#5

and#6ontothepinsofLogs

#1and#2,settingtheminto

theirnotches.Makesure

thatnologcanbemoved

easilyfromsidetoside.

ENSURE THAT ALL LOGS

ARECENTRAL AND

VERTICAL ASSEENFROM

THESIDE. THERE

SHOULDBESOME

IMPINGEMENT OF

FLAMESFROM THE

BURNER.IF THELOGS

BECOMEBLACKENED

DURINGUSE, TURNUNIT

OFF ANDCLEANWITH A

DAMP CLOTHOR A SOFT

BRUSH.RECHECKFOR

POSITIONING.FOLLOW

CLEANING

INSTRUCTIONSBEFORE

RELIGHTING.

Figure1

DecorativeGlowingEmberPlacement

TheGlowEmberPadispre-assembledandneedsnoadjustingor

addedmaterialstoglow.Padshouldbesecureandinplacebefore

operating.

Warning:Thisapplianceisequippedfor

(naturalorpropane)gas.Fieldconversionis

notpermitted.

FOR YOURSAFETY READBEFORELIGHTING

A. Thisappliancehasapilotwhichmustbe

lightedbyhand. Whenlightingthepilot,followthese

instructionsexactly.

B.BEFORELIGHTINGsmellallaroundthe

applianceareaforgas.Besuretosmellnexttothe

floorbecausesomegasisheavierthanairandwill

settleonthefloor.

WHAT TODOIF YOUSMELL GAS:

DONOT TRY TOLIGHT ANY APPLIANCE.

DONOT TOUCH ANY ELECTRICAL

SWITCH;DONOT USE ANY PHONEIN YOUR

BUILDING.



 IMMEDIATELY CALL YOURGASSUPPLIER

WARNING:Ifyoudonotfollowtheseinstructionsexactly,afireor explosionmay

Resultcausingpropertydamage,personalinjuryor lossoflife.

LIGHTING INSTRUCTIONS

FROM A NEIGHBOR’SPHONE.FOLLOW

YOURGASSUPPLIER’SINSTRUCTIONS.

IF YOUCANNOT REACH YOURGAS

SUPPLIER,CALL THEFIREDEPARTMENT.



C.Useonlyyourhandtopushinorturnthegas

controlknob.Neverusetools.Iftheknobwillnotpush

inorturnbyhand,don’ttrytorepairit,callaqualified

servicetechnician.Forceorattemptedrepairmay

resultinafireorexplosion.

D.Donotusethisapplianceifanyparthas

beenunderwater.Immediatelycallaqualifiedservice

techniciantoinspecttheapplianceandtoreplaceany

partofthecontrolsystemandanygascontrolwhich

hasbeenunderwater.

1.STOP!Readthesafetyinformationabove.

2.Pushingascontrolknobslightlyandturnclockwiseto

“OFF.”NOTE:Knobcannotbeturnedfrom“PILOT”to

“OFF”unlesstheknobispushedinslightly.Donotforce.

3. Waitfive(5)minutestoclearoutanygas.Ifyousmellgas,

STOP!Follow“B”inthesafetyinformationabove.Ifyoudon’t

smellgas,gotothenextstep.

4.Findpilotlocatedbetweenthefrontlogandthesecondlog.

5. Turnthecontrolknobcounterclockwisetopilot.

6.Pushthecontrolknoballthewayinandholdin. Whilestill

holdingthecontrolknobin,pushthePiezoIgnitorbutton

severaltimes. Thiswillcauseasparkatthepilotwhichshould

ignitethepilotgas.Continuetoholdthecontrolknobinfor

severalsecondstopreventflamefailure.

7.Releasethecontrolknob.

*Ifthecontrolknobdoesnotpopbackupwhen

released,stopandimmediatelycallyourservice

technicianorgassupplier.

*Ifthepilotdoesnotstaylitafterseveraltries,turnthe

gascontroltoOFFandcallyourservicetechnicianor

gassupplier.

8.Oncethepilotremainslit,depressthegascontrolknobslightly

andturnthegascontrolknobcounterclockwiseto“ON.”

NOTE: The“ON/OFF”SWITCHisusedtoturntheflameonor

offwhenthecontrolvalveisinthe“ON”position.

Thisapplianceisfittedwithatransientpilotburnerforthesole

purposeofsafe,momentaryignitionofthemainburnerin

conjunctionwiththepiezoignitor. Wheninoperationwiththe

mainburner,itcontributestothebaseheatreleaseandisturned

offbyturningthecontrolknobtotheoffposition.

9.Periodicallycheckthepilotflameforproperflamepattern.

Ifthepilotcannotbeignitedwiththepiezo,itcanbemanuallylit

withtheuseofapapermatchandalighterrod.Placethematch

intheholderandlight. Withtherighthand,depressandturnthe

controlknobcounterclockwisetothepilotpositionandhold

in.

Taketherodandlitmatchandlightthepilot. Thepilotislocated

behindthefrontandthesecondlog.

Continuetoholdthecontrolknobforanadditional10secondsto

ensurethatthepilotismaintained.

IMPORTANT:DONOT OPERATEBETWEENSETTINGS

MATCHLIGHTING

Toturnoffthegasappliance

1.Fromthe“ON”position,turnthecontrolknobclockwisetothe“PILOT”position. Thelogsetwillextinguish,andthe

pilotwillremainlit.

2.Ifcompleteshutdownisdesiredfromthe“PILOT”position,pushinthecontrolknobslightlyandturnclockwisetothe

“off”position.Donotforcetheknob.

TO TURNOFF GAS TO APPLIANCE

Piezo

PiezoIgnitor

HI/LOKNOB

OFF

PILOT

OFF

ControlKnob

FlameCheck

A periodicvisualcheckoftheflamesshouldbemade. Thepilot

flameshouldalwaysbepresentwhentheapplianceisinoperation.

SeefiguresDandE.

Innormaloperation(atafullrateforapproximately15minutes),

thefollowingflameappearancesshouldbeobserved:

Rearflames: Theflamesattherearorateithersideofthetoplog

shouldbeverysimilar,yellowincolor,andshouldextendaboutthree

tofourinchesabovethelargecenterlogfornaturalgas,twotothree

inchesforPropane.

IMPORTANT:IF THESEFLAMESBECOMELARGERSEE

“CLEANINGINSTRUCTIONS”

MainBurner: Theflamesattheburnerfrontfacewillbeblue

becomingyellowishastheyhitthebottomofthefrontlogs. Typical

mainburnerflameshapesaregiveninFigureE.

NOTE:Foryoursafety,theapplianceisequippedwithanoxygen

depletionsystem. Thesystemsensedtheamountofoxygeninthe

atmosphereandswitchesoffthegassupplyincasethelevelof

oxygenfallsbelowasafelevel.

WHENUSED AS A HEATING APPLIANCE/HEAT OUTPUT

Theheatoutputiscontrolledbythespanknob,oroptional

thermostat,notbythemaincontrolknob. Thespanknobwilladjust

flameintensity.

Thisappliancemaybeusedasaheatingapplianceonlyif

unventedheatingappliancesarepermittedbylocalstateandcity

codes.

FigureE

WARNING:Failuretokeeptheprimaryair

opening(s)oftheburner(s)cleanmay

resultinsootingandpropertydamage.

PART NAMEPART ##REQ

1.RearLog24EF-0211

2.FrontRightLog24EF-0221

3.FrontLeftLog24EF-0231

4. TopLeftLog24EF-0241

5. TopMidLog24EF-0251

6. TopRightLog24EF-0261

7.EmberflameGloPad24EF-027

8.ControlValve(N)

(RobertShaw)24UV1201

(Genesis)24UV120E1

(S.I.T.)24UV1401

ControlValve(LP)

(RobertShaw)24UV1211

(Genesis)24UV121E1

(S.I.T.)24UV1411

PART NAMEPART ##REQ

9.PiezoUV0871

10.Pilot Assembly(N)UV070N1

Pilot Assembly(P)UV071P 1

11.RearBurnerOrifice24UV010C(N)1

12.MainBurnerOrifice24UV052(N)1

13.MainBurner(N)24UV4518-0241

MainBurner(LP)24UV4518-1681

14.MainBurner Tube13971-0161

15.LavaRock Tray13971-0031

SourceonPage10

InstructionsforVented Applications

Thisunitmaybeinstalledinareaswherebuildingcodesrequireallgasappliancestobevented,if

andonlyifthefollowingguidelinesaremet. ThoseguidelinesfallintotheNationalFuelGasCode

ANSIZ223.1standard.

Thisappliancemustbeinstalledinasolidfuelburningfireplacewithaworkingflueand

constructedwithnoncombustiblematerial.

Theminimumpermanentfreeopeningthatmustbeprovidedbyeitherthefireplacechimneyor

chimneydampertoventthefluegasmustbeinaccordancewiththetableinFigure10.

Solidfuelsshallnotbeburnedinafireplacewhereadecorativefireplaceisinstalled. The

installationandprovisionsforcombustionandventilationairmustconformwiththe

Ensureperiodicexaminationandcleaningoftheventingsystemofthesolidfuelburningfireplace

atleastonceayearbyaqualifiedagency.

Decorativeappliancesforinstallationinsolidfuelburningfireplacesshallnotbethermostatically

controlled. Additionssuchasthermostatsorotherautomaticallycyclingdevicesarenotpermitted.

Additionssuchasthermostatsorotherautomaticallycyclingdevicesarenotpermitted.

PermanentFreeOpening

SecureChimneyDamper

Thechimneydampermustbefixedinamannerwhichwillmaintaintheminimumpermanentvent

openingatalltimes(Byscrew,boltatdamper’sedgetopreventitsclosing,orbyaholeorholesinthe

damper).

NationalFuelGas

Code, ANSIZ223.1/NFPA54.

MINFLUEDIAMETER:7”

OtherImportantItems:

1.Operatorshouldnotadjusttheflamebythecontrolknob.(SeeImportantInformationandLightingInstructions.)

2.Extendedusemaycauseairholeonleftrearburnertubetoclogup. Thiswillmaketheflamesappeartallerwhich

couldcauseacarbonorsootingproblem.

3.Logsnotplacedcorrectlywillcausesooting.

Ifsootingoccurs,thisunitshouldnotbeoperateduntiltheproblemisdiagnosed!

Othernotsocommonproblemsmaycausesooting.

1.Incorrectlinetounit.Checkwithlocalbuildingcodesforproperlinesizes,andnokinksinanylineareacceptable.

2.Lowfuelpressureintank.

3.Draftfromfanssuchasceilingfansorproximitytodoorwaythatcausesflamestodanceerratically.

4. Anythingsittingtooclose,orinfrontoftheunit,maycauseanobstructionofairflowtothegaslogs.

ChimneyHeightEF-N,39,000Btu’s

(Min.PermanentEF-P,35,000Btu’s

freeopening)

6ft.34squareinches

8ft.32squareinches

10ft.29squareinches

15ft.27squareinches

20ft.24squareinches

25ft.23squareinches

30ft.22squareinches

Diameterof Area

Std.RoundFlue

5in20sq.in.

6in.29sq.in.

7in39sq.in.

8in51sq.in.

Figure10

IMPORTANT:Ensurethatthechimneydraftisadequatebyholdingalitmatchorcandleatthetop

edgeofthefireplaceopening. Thiswillindicateifairmovementistowardthefireplace.Ifdraftis

inadequate,donotoperatelogsuntildraftisadequate.Ifthedraftisinsufficient,haveitinspectedbya

qualifiedchimneysweep.

(Minimumpermanentfreeopeninginsquareinchesbasedon6’ height)

ImportantSafeguards

Althoughyourgaslogsareveryrealisticinappearance,itisnotarealwoodburningfireplaceandmustnotbeusedfor

burningrejectedmaterial.

Toavoidirreparabledamagetotheapplianceorpersonalinjury,matches,paper,garbage,oranyothersolidfuelsmust

notbeplacedorthrownontopofthelogsorintotheflames.

Toavoidpersonalinjury,donottouchanyhotsurfaceoftheappliancewhenitisinoperation.

Touchonlythecontrolknob. Avoidcontactwiththegratefeetorprongsoranyotherpartwhichmaybeveryhot.

Alwaysensurethatthefireplacescreenisclosedwhentheapplianceisoperatingandprovisionsaremadefor

combustionair. Thisapplianceisnotcertifiedforusewithglassdoorsinaclosedposition.

Closesupervisionisnecessarywhentheapplianceisoperatednearchildren.

Cleaning

CAUTION:Beforecleaningormovinglogsorotherpartsoftheunit,besuretoreadtheabovesectionsonimportant

safeguards.

Allcleaningshouldbedonewhentheapplianceiscold.

Onlylimitedcleaningwillberequiredundernormaluse.Dustingthefrontgrate,thetopofthecover,orthecontrolknob

panelmayberequiredoccasionally.Donotuseanycleaningfluidtocleanthelogsoranyotherpartoftheappliance.

Iftheflamesshowanyunusualshapesorbehavior,oriftheburnersfailtoigniteproperly,thentheburnerholesmay

requirecleaning.Ifthisoccurs,donotoperatetheappliance.

Contactyournearestdealertogetyourapplianceserviced. Theairholesontheleftbottomrearburnertubemay

causetheflamestobecome4½”ortallerwhenclogged,requiringthetubetobecleanedwithawireorpipecleaner.

Alternatively,theappliancecanbecleanedbyremovingthetop,front,andrearlogs.Handlethelogsgentlyastonot

damagethefiberpieces. Alwayslifteachlogbyholdingitcarefullyatbothends.

Carefullyuseavacuumcleanertoremovedustandlooseparticlesfromthebase,logs,andfromaroundtheburners.

Glovesarerecommendedtopreventthefibersfrombreakingyourskin.Iftheskinisbroken,washgentlywithsoapand

water.

Servicing

Repairandreplacementworkshouldonlybedonebyaqualifiedserviceperson. Theapplianceshouldbeinspected

beforeuseandatleastannuallybyaprofessionalserviceperson.Morefrequentcleaningmayberequireddueto

excessivelintfromcarpeting,beddingmaterials,etc.

Itisimperativethatthecontrolcompartmentismaintainedcleanandfreeofobstructions.

Alwaysshutoffthegassupplyandmakesuretheapplianceiscoolbeforebeginninganyserviceoperation.

Anysafetyscreenorguardremovedforservicingagasappliancemustbereplacedbeforeoperatingtheheater.

Alwayscheckforgasleaksafterservicing.

RepairParts

A partslistwithexplodedviewsisonpage7. Alwaysincludecorrectname,partnumber,andmodelnumberofthe

appliancewhenorderingserviceparts.

Ifyoudesiretocommunicatewiththefactory,writeto:

AppalachianStove

&Fabricators

329EmmaRoad

Asheville,NC28801

Phone:(828)235-0154

Fax:(828)254-7803

Location

Fireplacescreen

Centrallylocatetheunitinthefireplaceanddeepenoughintothefirepittoaccomplishadequatedraft.

Ensurethatthegratefrontfeetsitinsidethefrontedgeofthefireplace.

Thefireplacescreenmustbeinplacewhentheapplianceisoperating,andunlessotherprovisions

forcombustionairaremade,thescreenmusthaveanopening(s)fortheintroductionofcombustion

air.

Thiswarrantyislimitedtofireplacesmanufacturedandassembledby AppalachianStoveand

Fabricators,henceforth“Appalachian.”

Ifanycomponentofafireplacecoveredunderthiswarrantyisreturnedto Appalachianand

foundtobedefectivewithintwoyearsfromthedateofpurchase, Appalachianwill,atitsoption,

repairorreplacethedefectivecomponentatnocharge.Valves,ODS’s,regulators,andmotors

carrya1yearwarranty.Dateofpurchaseandpurchasepricemustbeverifiedbyan

acceptableproofofpurchase.

Thiswarrantycoversonlypartsasprovidedabove.Innocaseshall Appalachianbe

responsibleformaterials,components,orconstructionwhicharenotmanufacturedorsupplied

by Appalachian,orthelabornecessarytoinstall,repair,orremovesuchmaterials,components,

orconstruction.

Thefireplacemustbeinstalledinaccordancewith Appalachianinstallationinstructions

andlocalcodes.

Thefireplacemustbeinstalledbyaqualifiedinstallerandmustbeoperatedaccordingtothe

operationinstructionsfurnished.

Thislimitedwarrantyappliesonlytotheoriginalownerofthegaslogsortheoriginalowner

ofthedwellinginwhichthegaslogsareinstalled.

Appalachianisnotresponsibleforanyincidentalorconsequentialdamagecausedby

possibledefectsinthisproduct.

Thedurationofanyimpliedwarrantywithrespecttothefireplaceislimitedtotheduration

oftheforegoingwarranty.

Somestatesdonotallowtheexclusionofincidentalorconsequentialdamagesorlimitsonthe

durationofimpliedwarranties,sotheselimitationsmaynotapplytoyou.

Appalachianreservestherighttoinvestigateanyandallclaimsagainstthiswarrantyandto

decideonthemethodofsettlement.

Appalachianisnotresponsibleforwarrantyworkcompletedwithoutobtaining Appalachian’s

consent. Appalachianemployeesanddealershavenorighttoalterthiswrittenwarranty.

Thislimitedwarrantyisgiveninlieuofanyotherexpressedorimpliedwarranty.

The AppalachianStove

329EmmaRoad

AshevilleNC28806

Phone:(828)253-0164

Fax:(828)254-7803

WarrantyCoverage

Qualification

Limitations

WarrantyFulfillment

Two YearLimitedWarranty

Appalachian Stove & Fabricators UV-EF-MIL 30-N Installation And Operating Instructions Manual

Brand: Appalachian Stove & Fabricators

Model: UV-EF-MIL 30-N

Category: Fireplaces

Type: Installation And Operating Instructions Manual

This manual is also suitable for

Download PDF

report

Appalachian Stove & Fabricators UV-EF-MIL 30-N Installation And Operating Instructions Manual

This manual is also suitable for

Appalachian Stove & Fabricators UV-EF-MIL 30-N Installation And Operating Instructions Manual

Other documents