2. COMPANION
  3. COMP232

COMPANION COMP232 Owner's manual

  • Hello! I am an AI chatbot trained to assist you with the COMPANION COMP232 Owner's manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
Australia’s original Outdoor brand
OWNERS MANUAL
Part No. COMP232
LP GAS HEATER
outdoor use only - do not use indoors
AS2568:2008
SAI - 400167
SAI Global
AS 2658:2008
Cert. GSCS20069
SAI Global
AS 2658:2008
Cert. GSCS20054
SAI Global
AS 2658:2008
Cert. GSCS20055
SAI Global
AS 2658 1988
Cert. GSCS20063
SAI Global
AS 2658 2008
Cert. GSCS20063
SAI Global
AS 2658 2008
Cert. GSCS20108
SAI Global
AS 2658 2008
Cert. GSCS20148
SAI Global
AS 2658 2008
Cert. GSCS20148
SAI Global
AS 4551-2008
Cert. GSCS20131
SAI Global
2
GenerAl WArninGs
• Thisapplianceshallonlybeusedwiththeapproved1500mmPropanegashose&regulator
assemblysuppliedwiththeapplianceandmustbeconnectedonlytoaPropanegascylinder
certiedtoAS2469standardsttedwithPOLConnectionsonlyItmaybehazardoustoattempt
totothertypesofgascontainersorcartridges.Donottotherhosetypes.
• IT MAY BE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPES OF GAS CONTAINERS OR CARTRIDGES.
• Ensurenotriphazardispresentduringoperation.
• Thisapplianceistobestoredinadry&wellventilatedlocationfreefromdirectsunlight.
Donotstorewhenstillconnectedtothecylinder.Makesurethatthecylinderisdisconnected
andisstoredinawell-ventilatedarea,freefromdirectsunlight,heatandignitionsources.
IfbeingstoredindoorsensuresthatthelocationcomplieswiththestandardAS/NZS1596.
• Thisappliancemustonlybeservicedbyanauthorisedserviceagent,returntoyourplaceof
purchaseforservice&repair.
dAnGer!
• ThisapplianceisdesignedforOUTDOORUSEONLY–DONOTUSEINDOORS.
• Donotusefordomesticinstallationsindoors.
• Donotremovetheguardprotectingtheburnerfromthisappliance.
• Donotusetheapplianceifithasaleak,worn,deterioratedordamagedseals.
• InspectthePropaneGashoseregularlyforsignsofwearordamage,replaceiffoundtobedamaged.
• Handlewithcareevenafterbriefuseassomesurfacesmaybecomehotduringoperation;
alwaysallowtheappliancetocooldownbeforemoving.
• Pickupusingthehandleonly.
• Useonlyinwellventilatedareas.
• Theguardontheappliancewillbecomeextremelyhot–DONOTTOUCH
• Thisapplianceshallonlybeusedinanabovegroundopenairsituationwithnaturalventilation,
withoutstagnantareas,wheregasleakageandproductsofcombustionarerapidlydispersedby
windandnaturalconvection.
• Donotuseadaptorsormodifyappliancetototherconnectorsorcylinders.
• Whenusingthisappliancechildrenmustbesupervisedbyanadultatalltimes.
• Neverleaveapplianceunattendedwhenoperating.
• Donotuseasacookingapplianceormodifyforanyotherreason.
• Donothangorattempttodryclothesoranyammablematerialonorplacedneartheappliance.
• Donotmodifythisapplianceorremoveanyguardsorcovers.
• Thisapplianceisnottobeusedinenclosedareasandmustbeoperatedawayfromanytypeof
ammablematerialorliquid.
IMPORTANT: Read these instructions for use carefully. Familiarise yourself with the appliance
before connecting it to its gas container. Keep these instructions for future reference.
Owners Manual
3
iMPortAnt
• OUTDOORUSEONLY–ONLYUSEINWELLVENTILATEDAREASTheappliancemustbeused
outdoorsonlyandistobeoperatednocloserthan1000mmfromthesidesand1000mm
fromaboveallcombustiblesurfaces,fabricsandammablematerials.Mustonlybeused
onsolid&stablehorizontalsurfacesmadefromnon-combustibleornon-ammable
materialsandshouldbeprotectedfromdirectdraftsandinawell-ventilatedplace.
• Keepclearoffrontofappliance.
• Useonlyinashelteredpositionensuringtheapplianceisnotexposedtorain
• Caution:Accessiblepartsmaybeveryhot.Keepyoungchildrenaway.
• Avoidtwisting&kinkingthePropanegashose.
• Ifyousmellgasimmediatelyturnthegasoffatthecylinderandmovetheappliance&
cylindertoawell-ventilatedareaoutside,keepingwellawayfromsourcesofheatsuchas
nakedames&pilotlights.
• Donotattempttomoveorrelocatetheappliancewhenitisoperating.Extinguishthe
burner&allowcool,disengagingthegascylinderthenmovingtheappliance.
CHeCKinG For GAs leAKs
• Checkthatallconnectionsaretightandthatthegascylinderconnectionhasbeen
tightenedbeforeyouturnthecylindergasvalveon.
• NEVERcheckforleakswithaameorpilotlight.
• Usingsoapywatercoatallconnections,ifbubblesappearturnthecylindergascontrol
offandretightentheconnectionbeforere-testing.
• Tocheckifgasremainsinthecylinder,disconnectfromtheapplianceandholdthecylinder
inaverticalpositionthenshakefromsidetoside.Ifthereisasoundorafeelofliquid
movementinsidethecylinder,thecylindercontainsgas.
• Whenchanginggascylindersensurethisisconductedoutsideinawell-ventilatedlocation
freefrompeople,animals&ignitionsourcessuchasnakedames,pilotlights&electrical
equipmentwithheatersorelements.
CArBon MonoXide HAZArd
THIS APPLIANCE CAN PRODUCE CARBON MONOXIDE WHICH
HAS NO ODOUR. USING IT IN AN ENCLOSED SPACE (FOR EXAMPLE,
CARAVAN, TENT, CAR, MOBILE HOME) MAY CAUSE DEATH.
4
sAFety instruCtions
Thisapplianceshallonlybeusedinanabovegroundopenairsituationwithnaturalventilation,withoutstagnant
areas,wheregasleakageandproductsofcombustionarerapidlydispersedbywindandnaturalconvection.
Any enclosure in which the appliance is used
shall comply with one of the following:
(A)Anenclosurewithwallsonallsides,
butwithnooverheadcover.
(B)Withinapartialenclosurethatincludesanoverhead
coverandnomorethantwowalls.
(C)Withinapartialenclosurethatincludesanoverhead
coverandmorethantwowalls,thefollowingshallapply:
(1)Atleast25%ofthetotalwallareais
completelyopen.
(2)30%ormoreintotaloftheremaining
wallside,backandfrontwallareasis
openandunrestricted.
(3)Inthecaseofbalconies,20%ormore
ofthetotalwallareashallremainopen
andunrestricted.
1
1
2
2
1
Owners Manual
5
understAndinG your APPliAnCe
POL REGULATOR
AND 1500mm LPG HOSE
cARRy
HANDLE
PIEZO
IGNITION
GUARD
cERAmIc
PLATE
GAS
INLET
FEET
cONTROL
6
ConneCtion to Cylinder
Step 1. Locatetheapplianceonarmhorizontalandnon-combustible
surface.
Step 2. Checkthatthecontrolontheapplianceisintheigniteposition.
Step 3. Connecttothecylinderwiththesuppliedhoseandregulator
assembly.
Step 4. Tightenusingaspanner.
Step 5. Turnthegascylindervalveoninaclockwisedirection
andthenchecktheconnectionsforleakswithsoapywater,
ifaleakisdetectedturnthecylinderoffandre-tightenall
connectionsandretest.
1
3
2
4
5
Owners Manual
7
liGHtinG tHe HeAter
Step 1. Turnthegascylinder“On”
Step 2. Checkthatthecontrolisinthe“Ignite”position
andthendepressandhold.
Step 3. PressthePiezoignitertolightthepilotameandcentre
burnerplate.Keepthegascontroldepressedfor10to15
secondsthenrelease.
Step 4. IfthePilotlight&burnerdoesnotigniteallowforany
excessgastodispersebeforetryingtorelight.
1
3
2
8
1
2
1
2
AdjustinG tHe HeAt outPut
Step 1. Slightlydepressthecontrolandturninananti-clockwise
directiontothe
thecentreburnerwillremaininoperation.
Step 2. Againslightlydepressthecontrolandturninananti-clockwise
directiontothe
or toignitetheremainingburners
asrequired.
turninG tHe APPliAnCe “oFF”
Step 1. Slightlydepressthecontrolandturninaclockwisedirection
tothe“Ignite”position,thesingleburner&pilotlightwill
remainon.
Step 2. Turnthegascylinder“off”andwaitfortheametoextinguish
Step 3. Turnthegascylindervalveoff.
Note:Allowtheappliancetoremainoffforaminimumof
5minutesbeforerelighting.
Donotattempttomoveorrelocatetheappliancewhenitis
operating.Extinguishtheburner&allowcool,disengaging
thegascylinderthenmovingtheappliance.
Owners Manual
9
specifications
PartNo.
COMP232
Dimensions:
363x353x170mm
Weight:
4.2Kg
GasJet:
0.56mmx3
Consumption:
11.44Mj/Hr-227G/Hr
Certicate:
SAI400167
teCHniCAl detAils
serViCinG
Inspecttheapplianceregularlyforsignsofwear,leaksorincorrectoperation.Ifsymptomssuchasaringoftheburners,
issueswithlighting,damagestohosesorconnectionsorleaksfromsealsorgascontrolsareidentieddonotattemptto
repair,contactCustomerServiceon1300555197.
DO NOT ATTEMPT TO REPAIR OR MODIFY THE APPLIANCE
CAre instruCtions
Usingwarmsoapywaterwithamilddetergentwipedownallsurfacesandareasoftheappliance,
takingcarenottoallowwatertoentertheburneroutlets.
DONOTsubmergetheapplianceinasinkorbowl.
DONOTuseabrasivecleanersorbleach.
10
notes
Owners Manual
11
notes
Distributedby
Companion Brands
BundooraVictoria3083
www.companionbrands.com.au
COM4875
/