Haier QDT125SSL0SS Installation guide

Brand: Haier

Model: QDT125SSL0SS

Category: Dishwashers

Type: Installation guide

This manual is also suitable for

Installation Instructions

Built-In Dishwasher

If you have questions, call Haier Customer Support at 1-877-337-3639 or visit our website at:

HaierAmerica.com.

IMPORTANT – The dishwasher MUST be installed to allow

for future removal from the enclosure if service is required.

If you received a damaged dishwasher, you should

immediately contact your dealer or builder.

Optional Accessories – See the Owner’s Manual for

available custom panel kits.

Your dishwasher is a water heating appliance

FOR YOUR SAFETY

Read and observe all CAUTIONS and WARNINGS

shown throughout these instructions. While performing

installations described in this booklet, gloves and

either safety glasses or goggles should be worn.

READ CAREFULLY.

KEEP THESE INSTRUCTIONS.

IMPORTANT – Observe all governing codes and

ordinances.

• Note to Installer – Be sure to leave these instructions for

the consumer’s and local inspector’s use.

• Note to Consumer – Keep these instructions with your

Owner’s Manual for future reference.

• Skill Level – Installation of this dishwasher requires

basic mechanical, electrical and plumbing skills. Proper

installation is the responsibility of the installer.

Product failure due to improper installation is

not covered under the Warranty. See Warranty

information.

• Completion Time – 1 to 3 Hours. New installations

require more time than replacement installations.

BEFORE YOU BEGIN

Read these instructions completely and

carefully.

31-31575 09-16 GEA

STOP

ENGLISH/FRANÇAIS

PARTS SUPPLIED:

Ŷ 7ZR3KLOOLSVKHDGZRRGVFUHZVORQJWR

secure dishwasher to underside of countertop

(in literature package).

Installation Preparation

TOOLS YOU WILL NEED:

Ŷ 3KLOOLSVKHDGVFUHZGULYHU

Ŷ DQGQXWGULYHU

Ŷ 7WRUTXHGULYHU

Ŷ $GMXVWDEOHZUHQFK

Ŷ /HYHO

Ŷ &DUSHQWHUVVTXDUH

Ŷ 0HDVXULQJWDSH

Ŷ 6DIHW\JODVVHV

Ŷ )ODVKOLJKW

Ŷ %XFNHWWRFDWFKZDWHUZKHQIOXVKLQJWKHOLQH

Ŷ *ORYHV

For New Installations Only:

Ŷ 7XELQJFXWWHU

Ŷ 'ULOODQGDSSURSULDWHELWV

Ŷ +ROHVDZVHW

MATERIALS YOU WILL NEED:

Ŷ )HUUXOHFRPSUHVVLRQQXWDQG(OERZ

137H[WHUQDOWKUHDGRQRQHHQGRSSRVLWHHQG

sized to fit water supply)

Ŷ 7KUHDGVHDOWDSH

Ŷ 8//LVWHGZLUHQXWV

Materials For New Installations

Only:

Ŷ $LUJDSIRUGUDLQKRVHLIUHTXLUHG

Ŷ :DVWHWHHIRUKRXVHSOXPELQJLIDSSOLFDEOH

Ŷ (OHFWULFDOFDEOHRUSRZHUFRUGLIDSSOLFDEOH

Ŷ 6FUHZW\SHKRVHFODPSV

Ŷ 6WUDLQUHOLHIIRUHOHFWULFDOFRQQHFWLRQ

Ŷ +DQGVKXWRIIYDOYH

Ŷ :DWHUOLQHPLQFRSSHU

Ŷ &RXSOHUIRUH[WHQGLQJGUDLQOLQHLIDSSOLFDEOH

2 Wood Screws

Hand

Shut-Off

Valve

90° Elbow,

Ferrule and

Compression Nut

Thread

Seal Tape

Wire Nuts (3)

Hot Water Line

Electrical Cable

(or Power Cord, if applicable)

Waste Tee

Coupler

Air

Gap

Screw Type

Hose Clamps

Strain Relief

Phillips

Head

Screwdriver

1/4" and

5/16" Nutdriver

Level

Carpenters

Square

T25 Torque

Driver

6" Adjustable

Wrench

Tubing Cutter

Measuring Tape

Safety GlassesFlashlight

Gloves

Bucket Hole Saw Set Drill and Bits



Installation Preparation

PREPARE DISHWASHER ENCLOSURE

7KHURXJKFDELQHWRSHQLQJPXVWEHDWOHDVWGHHS

WRZLGHDQGDSSUR[LPDWHO\KLJKIURP

ÀRRUWRXQGHUVLGHRIWKHFRXQWHUWRS

WARNING

7RUHGXFHWKHULVNRIHOHFWULFVKRFN¿UHRULQMXU\

to persons, the installer must ensure that the

dishwasher is completely enclosed at the time of

installation.

CLEARANCES: :KHQ

installed into a corner,

DOORZ´PLQFOHDUDQFH

between dishwasher and

DGMDFHQWFDELQHWZDOORU

other appliances. Allow

PLQFOHDUDQFH

from the front of the

dishwasher for door

RSHQLQJ)LJXUH%

DRAIN REQUIREMENTS

)ROORZORFDOFRGHVDQGRUGLQDQFHV

'RQRWH[FHHG¶GLVWDQFHWRGUDLQ

• Do not connect drain lines from other devices to the

dishwasher drain hose.

NOTE: Air gap must be used if waste tee or disposer

FRQQHFWLRQLVOHVVWKDQDERYHIORRUWRSUHYHQW

siphoning.

DETERMINE DRAIN METHOD

The type of drain installation depends on the following

questions.

Ŷ 'RORFDOFRGHVRURUGLQDQFHVUHTXLUHDQDLUJDS"

Ŷ ,VZDVWHWHHOHVVWKDQDERYHIORRU"

If the answer to either question is YES, Method 1 MUST

be used.

• If the answers are NO, either method may be used.

CABINET PREPARATION

'ULOODGLDPHWHUKROHLQWKHFDELQHWZDOOZLWKLQ

WKHVKDGHGDUHDVVKRZQLQ)LJXUH$IRUWKHGUDLQKRVH

connection. The hole should be smooth with no sharp

edges.

IMPORTANT::KHQFRQQHFWLQJ

drain line to disposer, check to be

sure that drain plug has been

UHPRYHG',6+:$6+(5:,//127

'5$,1,)3/8*,6/()7,13/$&(

• The dishwasher must be installed so that drain hose is no

PRUHWKDQ¶LQOHQJWKIRUSURSHUGUDLQDJH

AT\^eT

7^__Ta

?[dV

Method 1 – Air Gap with Waste Tee or Disposer

An air gap must be used when required by local codes and

ordinances.

The air gap must be installed according to manufacturer’s

instructions.

Method 2 – Drain Hose Routing

:KHQQRWXVLQJDQDLUJDSWKHGUDLQKRVHPXVWEHURXWHG

WRIRUPDKLJKORRSRIDWOHDVWWRSUHYHQWVLSKRQLQJ6HH

6WHSRQSDJH

Figure B



2[TPaP]RTU^a3^^a

>_T]X]V!<X]X\d\

2^d]cTac^_

3XbWfPbWTa

!'"'

Cabinets

Square

and

Plumb

Floor MUST

be Even with

Room Floor

This Wall Area

must be Free of

Pipes or wires

Plumbing and Electric Service

Must Enter Shaded Area

34-1/2" ± 1/2"

Underside of

Countertop

to Floor

24"

Min.

17 5/8" Min.

18" Max.

5" 5"

Figure A

CAUTION

An air gap MUST BE USED if the drain hose is

FRQQHFWHGWRZDVWHWHHRUGLVSRVHUORZHUWKDQ

DERYHWKHIORRUOHYHO)DLOXUHWRSURYLGHWKHSURSHU

GUDLQFRQQHFWLRQKHLJKWZLWKDQDLUJDSRUPLQLPXP

high drain loop will result in improper draining of the

dishwasher, which may cause damage.

Figure C

Figure D

'

<X]

'

<X]

Installation Preparation

PREPARE ELECTRICAL WIRING

- Electrical Shock Hazard

WARNING

)253(5621$/6$)(7<

Remove house fuse or open circuit breaker before

EHJLQQLQJLQVWDOODWLRQ'RQRWXVHDQH[WHQVLRQFRUGRU

adapter plug with this appliance.

For models equipped with power cord: Do not modify

the plug provided with the appliance; if it will not fit

the outlet, have a proper outlet installed by a qualified

technician.

Cabinet Preparation and Wire Routing

• The wiring may enter the opening from either side, rear or

WKHÀRRUZLWKLQWKHVKDGHGDUHD

&XWDPD[GLDPHWHUKROHWRDGPLWWKHHOHFWULFDO

FDEOH&DEOHGLUHFWFRQQHFWLRQVPD\SDVVWKURXJK

the same hole as the drain hose and hot water line, if

convenient. If cabinet wall is metal, the hole edge must be

covered with a bushing.

Note:3RZHUFRUGVZLWKSOXJPXVWSDVVWKURXJKD

separate hole.

Electrical Connection to Dishwasher

(OHFWULFDOFRQQHFWLRQLVRQWKHULJKWIURQWRIGLVKZDVKHU

)RUFDEOHGLUHFWFRQQHFWLRQVWKHFDEOHPXVWEHURXWHGDV

VKRZQLQ)LJXUH(&DEOHPXVWH[WHQGDPLQLPXPRI

from the rear wall.

)RUSRZHUFRUGFRQQHFWLRQVLQVWDOODSURQJJURXQGLQJ

W\SHUHFHSWDFOHLQWKHVLQNFDELQHWUHDUZDOOPLQRU

PD[IURPWKHRSHQLQJWRDERYHWKHÀRRU

Figure E

Electrical Requirements

7KLVDSSOLDQFHPXVWEHVXSSOLHGZLWK9+]DQG

connected to an individual properly grounded branch

FLUFXLWSURWHFWHGE\DRUDPSHUHFLUFXLWEUHDNHURU

time delay fuse.

:LULQJPXVWEHZLUHZLWKJURXQGDQGUDWHGIRU&

)

• If the electrical supply does not meet the above

requirements, call a licensed electrician before

proceeding.

Grounding Instructions–Cable Direct

This appliance must be connected to a grounded metal,

permanent wiring system, or an equipment grounding

conductor must be run with the circuit conductors and be

connected to the equipment grounding terminal or lead on

the appliance.

Grounding Instructions–Power Cord Models

This appliance must be grounded. In the event of a

malfunction or breakdown, grounding will reduce the risk

of electric shock by providing a path of least resistance

for electric current. This appliance is equipped with a cord

having an equipment grounding conductor and a grounding

plug. The plug must be plugged into an appropriate outlet

that is installed and grounded in accordance with all local

codes and ordinances.

1-1/2” Dia.

Hole (Max.)

3”

from

Cabinet

24”

from Wall

Ground

Black

White



- Electrical Shock Hazard

WARNING

The improper connection of the equipment grounding

FRQGXFWRUFDQUHVXOWLQHOHFWULFVKRFN&KHFNZLWKD

qualified electrician or service representative if you are

in doubt that the appliance is properly grounded. Do not

modify the plug provided with the appliance; if it will not

fit the outlet, have a proper outlet installed by a qualified

technician.

Installation Instructions

PREPARE HOT WATER LINE

7KHOLQHPD\HQWHUIURPHLWKHUVLGHUHDURUÀRRUZLWKLQWKH

VKDGHGDUHDVKRZQLQ)LJXUH)

• The line may pass through the same hole as the electrical

FDEOHDQGGUDLQKRVH2UFXWDQDGGLWLRQDOGLDKROH

to accommodate the water line. If power cord with plug is

used, water line must not pass through power cord hole.

Figure F

Water Line Connection

• Turn off the water supply.

• Install a hand shut-off valve in an accessible location,

such as under the sink. (Optional, but strongly

recommended and may be required by local codes.)

:DWHUFRQQHFWLRQLVRQWKHOHIWVLGHRIWKHGLVKZDVKHU

,QVWDOOWKHKRWZDWHULQOHWOLQHXVLQJQROHVVWKDQ2'

FRSSHUWXELQJ5RXWHWKHOLQHDVVKRZQLQ)LJXUH)DQG

H[WHQGIRUZDUGDWOHDVWIURPUHDUZDOO

$GMXVWZDWHUKHDWHUIRU)WR)WHPSHUDWXUH

)OXVKZDWHUOLQHWRFOHDQRXWGHEULV

7KHKRWZDWHUVXSSO\OLQHSUHVVXUHPXVWEH36,

BEFORE YOU BEGIN

/RFDWHDQGVHWDVLGHWKHSDFNDJHFRQWDLQLQJ

3KLOOLSVKHDGFRXQWHUWRSPRXQWLQJVFUHZV

DQGDGGLWLRQDOWRHNLFNVFUHZVORFDWHGLQ

the literature package).

Figure G

STEP 1 CHECK DOOR BALANCE

To check the door balance, hold the top of the dishwasher

¿UPO\

&KHFNWKHGRRUEDODQFHE\RSHQLQJDQGFORVLQJWKHGRRU

• If the door drops when released, increase the spring

tension. If the door rises when released, decrease the

spring tension.

• Models have different spring mounting and tension

PHWKRGV5HIHUWRWKHDSSURSULDWH¿JXUHIRU\RXUPRGHO

CAUTION

7KHKRWZDWHUVXSSO\OLQHSUHVVXUHPXVWEHDWOHDVW

SVL/RZHUSUHVVXUHVFRXOGFDXVHWKHZDWHUYDOYHWR

leak and cause water damage.

Cabinet Face

Shut-off

Valve

3" From Floor

18" From Wall

From

Cabinet

1-1/2" Dia.

Hole

Hot

Decrease

Increase



CAUTION

Opening the door will cause the

dishwasher to tip forward. Do not open

the door until you are ready to install

the dishwasher. If it is necessary to

open the door, hold the top of the

dishwasher securely with one hand

and hold the door with the other hand.

STOP

Installation Instructions

STEP 2 ADJUST LEVELING LEGS

• Move the dishwasher close to the installation location and

lay it on its back.

Figure I

• Measure installation height and dishwasher height.

([WHQGOHYHOLQJOHJVRXWIURPWKHGLVKZDVKHUEDVH

less than installation height.

STEP 3 REMOVE TOEKICK

5HPRYHWKHWRHNLFNVFUHZV/LIWRIIWKHSLHFHWRHNLFN

STEP 4 INSTALL POWER CORD

Skip this step if dishwasher will be direct wired.

8VH3RZHU&RUG.LW:;;DYDLODEOHIRUSXUFKDVH

IURPDQDXWKRUL]HG*($SSOLDQFHV'HDOHU7KHSRZHUFRUG

DQGFRQQHFWLRQVPXVWFRPSO\ZLWKWKH1DWLRQDO(OHFWULFDO

&RGH6HFWLRQDQGRUORFDOFRGHVDQGRUGLQDQFHV

0D[LPXPSRZHUFRUGOHQJWKLV

&RQQHFWLQFRPLQJSRZHUFRUGZKLWHRUULEEHGWR

dishwasher white, black (or smooth) to black and ground

WRGLVKZDVKHUJUHHQZLUH8VH8/OLVWHGZLUHQXWVRI

appropriate size.

5HSODFHMXQFWLRQER[FRYHU%HVXUHZLUHVDUHQRWSLQFKHG

under the cover.

Figure K

Figure J

Figure L

STEP 5 INSTALL 90° ELBOW

:UDSHOERZZLWKWKUHDGVHDOWDSH

,QVWDOODHOERZRQWRWKHZDWHUYDOYH

'RQRWRYHUWLJKWHQHOERZZDWHUYDOYHEUDFNHWFRXOG

EHQGRUZDWHUYDOYH¿WWLQJFRXOGEUHDN

3RVLWLRQWKHHQGRIWKHHOERZWRIDFHWKHUHDURIWKH

dishwasher.

Adjust to

Installation

Height

Remove

4 Toekick

Screws

White

Ground

Black

Check That White, Black and

Green Dishwasher Wires Are Threaded

Thru Hole in Back

Remove

Junction Box

Cover

Insert Power

Cord Wires Thru

Strain Relief

and Tighten

Use UL Listed

Wire Nuts

90°

Elbow

Fill

Hose

Thread

Seal Tape

Water

Valve

Bracket



Installation Instructions

STEP 6 POSITION WATER LINE AND

HOUSE WIRING

3RVLWLRQZDWHUVXSSO\OLQHDQGKRXVHZLULQJRQWKHÀRRURI

the opening to avoid interference with base of dishwasher

and components under dishwasher.

Figure M

Figure N

Figure O

STEP 7 INSTALL DRAIN HOSE

THROUGH CABINET

• Stand the dishwasher upright and position in front of the

opening. Insert drain hose into cabinet wall hole. If a power

cord is used, guide the end through a separate hole.

TIP:3RVLWLRQZDWHUOLQHDQGKRXVHZLULQJRQWKHIORRUWR

avoid interference with base of dishwasher.

STEP 8 SLIDE DISHWASHER

PARTIALLY

INTO CABINET

DO NOT PUSH AGAINST FRONT PANEL WITH KNEES.

DAMAGE WILL OCCUR.

• Slide dishwasher into the opening a few inches at a time.

• As you proceed, pull the drain hose through the opening

under the sink. Stop pushing when the dishwasher is a

IHZLQFKHVIRUZDUGRIDGMDFHQWFDELQHWU\

• Make sure drain hose is not kinked under the dishwasher

and there is no interference with the water line and wiring

or any other component.

Water

Line

House

Wiring

Power Cord

(If Used)

Water

Line

House

Wiring

Drain

Hose

Insulation

Blanket

Maximum

Drain Hose

Length 10”

Do Not Push Against

Front Door Panel With

Knee. Damage to The

Door Panel Will Occur.



Countertop

Dishwasher

Door

1/2”

Min.

Installation Instructions

STEP 9 POSITION DISHWASHER

UNDER COUNTERTOP

3XVKWKHGLVKZDVKHULQWRWKHFDELQHW

3XVKWKHVLGHVZLWK\RXUKDQGV'RQRWXVH\RXUNQHH

against the door since door damage will occur.

&KHFNWKDWWKHWXELQVXODWLRQEODQNHWGRHVQRWJHW

³EXQFKHGXS´RULQWHUIHUHZLWKWKHVSULQJVDV\RXVOLGHLW

into the cabinet.

&HQWHUWKHGLVKZDVKHULQWKHRSHQLQJ

)URQWRIGRRUSDQHOVKRXOGEHÀXVKZLWKIDFHRIFDELQHW

&DUHIXOO\RSHQDQGFORVHWKHGRRUWRHQVXUHWKDWWKHGRRU

panel does not catch or rub on the cabinet frame.

,IWKHGRRUFDWFKHVRUUXEVRQWKHIUDPHUHSRVLWLRQDQG

RUOHYHOWKHXQLWVHH6WHSXQWLOWKHGRRUPRYHVIUHHO\

and does not contact the cabinet frame.

The controls on these models are designed to be hidden by

\RXUFRXQWHUWRS$OLJQWKHGLVKZDVKHUDVVKRZQLQ)LJXUH

4/HDYHDPLQLPXPJDSEHWZHHQWKHXQGHUVLGHRIWKH

countertop and the top of the dishwasher door as shown in

)LJXUH7

Note: If the drain hose gets trapped behind the unit it can

prevent the controls from being hidden by the countertop.

Note:,IWKLVGLVKZDVKHULVUHSODFLQJDQH[LVWLQJ

dishwasher, the old countertop bracket screw holes may

not be in the correct position to accept a top-control model.

New holes may be required.

Tip: The leveling legs can be used to increase or decrease

the amount of gap between the controls and the countertop

affecting the visibility of the controls.

IMPORTANT – Leave a 1/2" minimum gap between

the controls and the underside of the countertop to

prevent condensation and damage to the control panel

from screwheads.

Figure P

Figure Q

Figure R

Figure S Figure T

AT_^bXcX^]3XbWfPbWTa

Qh6aPb_X]V1^cW

BXSTbFXcW7P]Sb

3^=^c?dbW0VPX]bc

5a^]c3^^a?P]T[FXcW

:]TT3P\PVTc^CWT

3^^a?P]T[FX[[>RRda

3^^a

5XcbP]S

BfX]Vb

1PRZ

1TWX]S

2PQX]Tc

5aP\T

2^aaTRc

0[XV]\T]c

3^^a2PcRWTb

^]2PQX]Tc5aP\T

8]R^aaTRc

0[XV]\T]c

Countertop

Control

Panel

OFF

DELAY

START

LOW RINSE AID

1 - 24 HRS.

Top View

Controls Hidden

by Countertop



Installation Instructions

STEP 10 LEVEL DISHWASHER

IMPORTANT – Dishwasher must be level for proper dish

rack operation and wash performance.

0DNHVXUHPLQLPXPJDSLVPDLQWDLQHGVHH)LJXUH7

3ODFHOHYHORQGRRUWRFKHFNWKDWWKHGLVKZDVKHULVOHYHO

VLGHWRVLGH3ODFHOHYHORQUDFNWUDFNLQVLGHWXEWRFKHFN

that the dishwasher is level front-to-back.

DbT

;TeT[c^

2WTRZ

BXST

c^BXST

DbT

;TeT[c^

2WTRZ

5a^]c

c^1PRZ

,IWKHGLVKZDVKHULVQRWOHYHODGMXVWWKHIRXUOHYHOLQJOHJV

individually.

7LS3XOOORZHUUDFNRXWDERXWKDOIZD\&KHFNWREHVXUH

the rack does not roll forward or back into dishwasher. If

the rack rolls in either direction, the dishwasher must be

leveled again.

• If door hits the tub, the dishwasher is not installed

FRUUHFWO\$GMXVWOHYHOLQJOHJVWRDOLJQGRRUWRWXE

IMPORTANT – After leveling, verify that the dishwasher is

still in the correct position shown in

6WHS

Figure U

Figure V

STEP 11 SECURE DISHWASHER TO

COUNTERTOP OR CABINET

In this step you will

need the 2 Phillips

special head screws

set aside prior to Step

1. The dishwasher

must be secured to the

countertop or the cabinet

VLGHV:KHQFRXQWHUWRSV

are made of wood,

XVH0HWKRG:KHQ

countertops are granite

or other materials that

will not accept screws,

XVH0HWKRGWRVHFXUH

dishwasher at the sides.

IMPORTANT –

Drive screws straight

DQGIOXVK3URWUXGLQJ

screw heads will

scratch the top or

sides of the control

panel and can interfere

with door closing.

Method 1

Secure dishwasher to wood countertop

)DVWHQWKHGLVKZDVKHUWRWKHXQGHUVLGHRIWKHFRXQWHUWRS

ZLWKWKH3KLOOLSVVSHFLDOKHDGVFUHZVSURYLGHG

Method 2

Secure dishwasher with side-mounting brackets

• Remove plug buttons (one on each side).

• Install screws through the dishwasher side mount bracket

DQGLQWRWKHDGMDFHQWFDELQHWRQHDFKVLGH5HLQVWDOOSOXJ

buttons.

Figure Y

1aPRZTcb

F^^S2^d]cTac^_

Figure Z

!

<X]

2^d]cTac^_

3XbWfPbWTa3^^a

Figure AA

Figure W

:KHQVWHSLVFRPSOHWHFORVHGLVKZDVKHUGRRUDQGYHULI\

that gap between countertop and top of dishwasher door is

DWOHDVW

Either Method

Figure X

Screws

Plug Buttons

Granite Countertop

Turn Legs

to Adjust

Countertop

Mounting

brackets

Side-Mounting

Bracket



Installation Instructions

STEP 12 CONNECT WATER SUPPLY

&RQQHFWZDWHUVXSSO\OLQHWRHOERZ

• Slide compression nut, then ferrule over end of water line.

• Insert water line into

HOERZ

• Slide ferrule against

elbow and secure with

compression nut.

Figure BB

Figure CC

STEP 13 CONNECT DRAIN LINE

FOLLOW ALL LOCAL CODES AND ORDINANCES.

7KHPROGHGHQGRIWKHGUDLQKRVHZLOOILWWKURXJK

diameter inlet ports on the air gap, waste tee or disposer.

• Determine size of inlet port

&XWGUDLQKRVHFRQQHFWRURQWKHPDUNHGOLQHLIUHTXLUHG

WR¿WWKHLQOHWSRUW

,IDORQJHUGUDLQKRVHLVUHTXLUHGDGGXSWRRIOHQJWK

IRUDWRWDORIWRWKHIDFWRU\LQVWDOOHGKRVH8VHRU

LQVLGHGLDPHWHUKRVHDQGDFRXSOHUWR

connect the two

hose ends.

Secure the

connection with

hose clamps.

Figure DD

• Secure the drain hose to the air gap, waste tee or disposer

with clamps.

Note:727$/'5$,1+26(/(1*7+0867127(;&(('

)253523(5'5$,123(5$7,21

:DVWH7HH,QVWDOODWLRQ

Figure EE

Disposer Installation

:DVWH7HH,QVWDOODWLRQ

Figure FF

Disposer Installation

Method 2 – Drain Hose Routing

5RXWHWKHGUDLQKRVHRIWKHGLVKZDVKHUWRDPLQLPXPKHLJKWRI

IURPWKHÀRRUZLWKWKHVXSSOLHGKDQJHUDVVKRZQ

IMPORTANT±:KHQFRQQHFWLQJ

drain line to disposer, check to be sure

that drain plug has been removed.

',6+:$6+(5:,//127'5$,1,)

3/8*,6/()7,13/$&(

Tip: Avoid unnecessary service call charges. Always

be sure disposer drain plug has been removed before

attaching dishwasher drain hose to the disposer.

AT\^eT

7^__Ta

?[dV

7^bT2[P\_

2^d_[Ta

7^bT2[P\_

18"

Min.

32"

Min.

ggpp

IMPORTANT – Either one of the above methods must be

used or dishwasher will not operate properly.

Method 1 – Air gap with waste tee or disposer

Insert the drain hose to air gap as shown.

32"

Min.

18"

Min.

ggpp

IMPORTANT±&KHFNWREHVXUHWKDWGRRUVSULQJGRHV

not rub or contact the fill hose or water supply line. Test

by opening and closing the door. Re-route the lines if a

rubbing noise or interference occurs.

DRAIN LINE INSTALLATION

&RQQHFWGUDLQOLQHWRDLUJDSZDVWHWHHRUGLVSRVHUXVLQJ

either previously determined method.

Ferrule

90° Elbow

Compression Nut

Hot Water

Supply Line

Cutting Lines

3/4"

5/8"

IMPORTANT: Do not cut corrugated

portion of hose



Installation Instructions

STEP 14 CONNECT POWER SUPPLY

Skip this step if equipped with power cord.

Verify that power is turned off at the source.

5HPRYHMXQFWLRQER[FRYHU³$´

/RFDWHWKHWKUHHGLVKZDVKHUZLUHVZKLWHEODFNDQG

green) with stripped ends. Insert dishwasher wires through

WKHVPDOOKROHLQWKHMXQFWLRQER[³%´

6HFXUHKRXVHZLULQJWRWKHERWWRPRIWKHMXQFWLRQER[ZLWK

DVWUDLQUHOLHI³&´

• Use wire nuts to connect incoming ground to green, white

WRZKLWHDQGEODFNWREODFN³'´

5HSODFHMXQFWLRQER[FRYHU³(´&KHFNWREHVXUHWKDW

wires are not pinched under the cover.

STEP 15 PRETEST CHECK LIST

Review this list after installing your dishwasher to

avoid charges for a service call that is not covered by

your warranty.

 &KHFNWREHVXUHSRZHULV2))

Open door and remove all foam and paper packaging.

 /RFDWHWKH2ZQHU¶V0DQXDOLQWKHOLWHUDWXUHSDFNDJH

Read the Owner’s Manual for operating instructions.

 &KHFNGRRURSHQLQJDQGFORVLQJ,IGRRUGRHVQRW

open and close freely or tends to fall, check spring

DGMXVWPHQWV6HH6WHS

 &KHFNWREHVXUHWKDWZLULQJLVVHFXUHXQGHUWKH

dishwasher, not pinched or in contact with door springs

RURWKHUFRPSRQHQWV6HH6WHS

 &KHFNGRRUDOLJQPHQWZLWKWXE,IGRRUKLWVWXEOHYHO

GLVKZDVKHU6HH6WHS

 3XOOORZHUUDFNRXWDERXWKDOIZD\&KHFNWREHVXUH

it does not roll back or forward on the door. If the rack

PRYHVDGMXVWOHYHOLQJOHJV6HH6WHS

 &KHFNGRRUDOLJQPHQWZLWKFDELQHW,IGRRUKLWVFDELQHW

UHSRVLWLRQRUUHOHYHOGLVKZDVKHU6HH6WHS

 9HULI\ZDWHUVXSSO\DQGGUDLQOLQHVDUHQRWNLQNHGRULQ

FRQWDFWZLWKRWKHUFRPSRQHQWV&RQWDFWZLWKPRWRURU

GLVKZDVKHUIUDPHFRXOGFDXVHQRLVH6HH6WHS

Turn on the sink hot water faucet and verify water

temperature. Incoming water temperature must be

EHWZHHQ)DQG)$PLQLPXPRI)

temperature is required for best wash performance. See

³3UHSDUH+RW:DWHU/LQH´SDJH

 $GGTXDUWVRIZDWHUWRWKHERWWRPRIWKHGLVKZDVKHUWR

lubricate the pump seal.

 7XUQRQZDWHUVXSSO\&KHFNIRUOHDNV7LJKWHQ

connections if needed.

Remove protective film if present from the control panel

and door.

Avoid service call charges by ensuring there is an air gap

RUGUDLQKRVHURXWHGWKURXJKWKHUHTXLUHGPLQLPXP

height.

Figure GG

White

Ground

Black

Check That White, Black and

Green Dishwasher Wires Are Threaded

Thru Hole in Back

Remove

Junction Box

Cover

Insert Power

Cord Wires Thru

Use UL Listed

Wire Nuts



- Electrical Shock Hazard

WARNING

,IKRXVHZLULQJLVQRWZLUHZLWKJURXQGDJURXQGPXVWEH

SURYLGHGE\WKHLQVWDOOHU:KHQKRXVHZLULQJLVDOXPLQXP

EHVXUHWRXVH8//LVWHGDQWLR[LGDQWFRPSRXQGDQG

aluminum-to-copper connectors

Installation Instructions

STEP 16 DISHWASHER WET TEST

Turn on power supply (or plug power cord into outlet,

if equipped).

Start the unit to check for leaks.

±3UHVV212))EXWWRQWRWXUQXQLWRQ

±3UHVV&<&/(6(/(&7EXWWRQXQWLOOLJKWEHORZ5,16(

cycle illuminates

 &ORVHGRRU

 &KHFNWREHVXUHWKDWZDWHUHQWHUVWKHGLVKZDVKHU,I

water does not enter the dishwasher, check to be sure

that water and power are turned on.

 &KHFNIRUOHDNVXQGHUWKHGLVKZDVKHU,IDOHDNLVIRXQG

turn off power supply, then tighten connections. Restore

power after leak is corrected.

 &KHFNIRUOHDNVDURXQGWKHGRRU$OHDNDURXQGWKHGRRU

could be caused by door rubbing or hitting against

DGMDFHQWFDELQHW5HSRVLWLRQWKHGLVKZDVKHULI

QHFHVVDU\6HH6WHS

 7KHGLVKZDVKHUZLOOGUDLQDQGWXUQRIIDERXWWR

PLQXWHVDIWHUWKHILUVWILOO&KHFNGUDLQOLQHV,IOHDNVDUH

found, turn power off at the breaker and correct plumbing

as necessary. Restore power after corrections are

PDGH6HH6WHS

Open dishwasher door and make sure most of the water

has drained. If not, check that disposer plug has been

UHPRYHGDQGRUDLUJDSLVQRWSOXJJHG6HH6WHS

Also check drain line for kinking.

Run the dishwasher through another fill and drain cycle.

&KHFNIRUOHDNVDQGFRUUHFWLIUHTXLUHG

 $WWKHHQGRIGUDLQRSHQGRRUDQGSUHVV212))EXWWRQ

to turn unit off.

Figure HH

STEP 17 REPLACE TOEKICK

3ODFHSLHFHWRHNLFNDJDLQVWWKHOHJVRIWKHGLVKZDVKHU

3ODFHWKHLQQHUWRHNLFNSLHFHZLWKVORWVDJDLQVWWKH

toekick bracket. The slots should align with toekick

EUDFNHWVFUHZKROHV$OORZWKHWRHNLFNWRWRXFKWKHÀRRU

3ODFHODUJHUWRHNLFNRYHUWKHLQQHUSLHFHDQGLQVWDOO

toekick screws.

8VHDGGLWLRQDOVFUHZVIRULQVWDOODWLRQVRYHUKLJK

• Use both toekick pieces for all installation heights.

STEP 18 LITERATURE

• Be sure to leave complete literature package and

Installation Instructions with the consumer.

63(&,),&$7,21668%-(&772&+$1*(:,7+287127,&(

2-Piece Toekick

Adjust Up

or Down

Use Top 4

Screw Holes



Page is loading ...

Haier QDT125SSL0SS Installation guide

Brand: Haier

Model: QDT125SSL0SS

Category: Dishwashers

Type: Installation guide

This manual is also suitable for

Download PDF

report

in other languages

français: Haier QDT125SSL0SS Guide d'installation

Haier QDT125SSL0SS Installation guide

This manual is also suitable for

Haier QDT125SSL0SS Installation guide

in other languages

Related papers

Other documents