© 2000-7 PRINTED IN JAPAN
B51-7638-00(S) 1889
SERVICE MANUAL
CD CASSETTE RECEIVER
GX-608EF2
POWER
TUNE/TRACK
REW LOUDFF
MUTE
SCN DISP
T. I NEWS
TONE/BAL
VOLUME
CD
BAND
CHR
TAPE
COMPACT
DIGITAL AUDIO
B NR REP RDM PROG
RELEASE
AUTO-REVERSE
DOLBY B NR
AME LOCAL
VOL ADJ REG
Front glass assy
(B10-3165-13)
Panel assy
(A64-2014-22)
TEL MUTE
A19
SUBARU GENUINE
Sub panel assy
(A22-2807-13)
Cassette lid
(A53-1679-03)
Cord with plug (ANT)
(E30-4809-15)
Cord with connector
(Tel mute)
(E30-4810-05)
GX-608EF2
2
BLOCK DIAGRAM
L12
FM:223mV
AM:180mV
FM
AM
TAPE:345mV
CD:1200mV
CH:1200mV
0dB
0dB
0dB
AM:
FM:
TAPE:
CD:
CH:
-6.0dB
-9.0dB
-12.0dB
0.0dB
0.0dB
315Hz 0dB
1kHz 40kHzdev.
400Hz 30%mod.
1kHz 0dB
1kHz 0dB
F/E
ANT
SW AMP
IC21
FM
AM
EQ-DOLBY
CD-MECHA
CD-CH
IC22
E-VOL
-12dB
-12dB
IC31,32
FIX EQ
+34dB
+34dB
IC41
REAR
SP
SP
FRONT
MPX
AN7550NZNJM2060M
ATT
ATT
TDA7400D
BA3129F
0dB
CASSETTE
MECHA
ANT
F/E
IF/NC
PLL
FM+B
AM+B
A11 Q101
Q103
RDS
NOISE AMP
IC12
IC13
LOUD
BASS
TREBLE
ATT
FADER
ISO-AMP
SELECTOR
MPX
IC22
E-VOL
SW AMP
EQ,DOLBY
IC21
IC1 (D40-1079-05)
MECHA
(X92-3590-01)
CD MECHA
CASSETTE
FIX-EQ
IC31,32
IC81
EEPROM
IC84
CHANGER
SYSTEM u-COM
DRIVER
MOTOR
POWER IC
IC41
SP-OUT
MUTE Dr
IC83
Q709
BU DET.
Q904
ACC DET.
ACC
P-ANTANT-CON
Q94
PANEL u-COM
IC1
VFD KEY MATRIX LAMP
(X25)
TDF
RST
RST
IC92
MECHA
Q701
AVR
A8V
AVR
Q704
AVR
VREF
IC72
BU5V
AVR
Q706
BACK UP
Q708
PON5V
SW
LAMP
A61
Q605,606
SMALL IN
TEL MUTE
DC/DC
Level difference of each sauce
GX-608EF2
3
●SYNTHESIZER UNIT(X14-6212-70)
Ref.No. Component Name Application/Function Operation/Condition/Compatibility
IC1 HA12216FP Dolby B
Playback EQ, Dolby B, blank space detection
IC2 BA6219BFP-Y Motor driver For cassette mechanism
IC12 NJM4565M-TE2 Operational amplifier For RDS noise amplifier
IC13 TDA7479D RDS decoder For RDS decoding
IC21 BA3129F SW operational amplifier For CD/TAPE switching
IC22 TDA7400D Electronic control BASS, TRE, MPX, EVOL
IC31,32 NJM2060M Operational amplifier For FIX-EQ
IC41 AN7550NZ Power amplifier 4-channel 35W power amplifier
IC71 M5237ML AVR control For AUDIO +8V power supply
IC72 NJM4580MD Operational amplifier 1/2 VCC output
IC81 UPD784216GF526 System microprocessor System control
IC82 PST9130NR Reset IC Reset detection
IC83 TC74HC02AF NOR circuit (4) For hard muting
IC84 BR24C01AF EEP-ROM For memory backup
Q1 2SB1443
Cassette mechanism main motor power switch
For cassette mechanism main motor
Q2 DTC114EK
Cassette mechanism main motor power switch
Pch-SW
Q3 DTC144EK Gain switching during tape searching Pch-SW, on during tape playback
Q4 DTA144EK Gain switching during tape searching Nch-SW, on during tape playback
Q5 DTC144EK Motor driver power switch Pch-SW
Q6 DTA114EK Motor driver power switch Nch-SW
Q7 2SB1443 Motor driver power supply For cassette mechanism submotor driver
Q8 2SC2412K(S) Motor driver power supply control For cassette mechanism submotor driver
Q9 DTC144EK Kick switch
On for emergency eject when submotor locked
Q101 2SB1188(Q,R) FM power switch For FM 8V
Q102 DTC124EK FM power switch Pch-SW
Q103 2SB1188(Q,R) AM power switch For AM 8V
Q104 DTC124EK AM power switch Pch-SW
Q107 DTC124EK IF mode forced switching switch Lo output at WIDE
Q108 2SC2412K(S) Noise amplifier Noise detection output buffer
Q109 DTC114TK Noise amplifier Constant switching when noise detected
Q110 DTA124EK Noise amplifier Constant switching when noise detected
Q201 DTC114EK Source switch switching Lo output at TAPE
Q202 2SA1037K Mute switch For CD muting
Q203 DTC144EK Mute switch For IC II 3 hard muting
Q204 DTC343TK Mute switch For CD muting, Rch
Q205 DTC343TK Mute switch For CD muting, Lch
Q601 DTC124EK DC/DC AVR switch Pch-SW
Q602 DTA124EK DC/DC AVR switch Nch-SW
Q603 2SB1184 DC/DC AVR For 13V AR
Q604 2SC2412K(S) DC/DC AVR control For 13V AR
Q605 2SB1565(E,F) Lamp AVR For 10V AR
Q606 2SB1565(E,F) Lamp AVR For 10V AR
Q607 DTA124EK Lamp AVR switch Nch-SW
Q608 2SC2412K(S) Lamp AVR control For 10V AR
Q609 DTC144EK Small detection Lo output at small ON
COMPONENT DESCRIPTION
GX-608EF2
4
●SWITCH UNIT(X25-8502-70)
Ref.No. Component Name Application/Function Operation/Condition/Compatibility
IC1 UPD78011FGC599 Display control microprocessor VFD control, key take in
Q1 DTC114EK 5V control Nch-SW
Q2 DTA114YK VFD power switch Pch-SW
Q3 DTC114YK 5V control VFD protection SW
Q4 DTC114EK VFD control VFD control
COMPONENT DESCRIPTION
Ref.No. Component Name Application/Function Operation/Condition/Compatibility
Q610 DTC114EK Lamp AVR switch P-CH-SW
Q701 2SB1565(E,F) CD mechanism AVR For 7.5V AVR
Q702 2SC2412K(S) CD mechanism AVR control For 7.5V AVR
Q703 DTA124EK CD mechanism AVR switch For 7.5V AVR
Q704 2SB1565(E,F) AVR For 8V AVR
Q705 DTA124EK AVR switch For 8V AVR
Q706 2SB1565(E,F) Microprocessor AVR For 5.6V AVR
Q707 2SC2412K(S) Microprocessor AVR control For 5.6V AVR
Q708 2SA1037K P-ON 5V switch P-ON 5V SW
Q709 2SC2412K(S) BU detection Lo output at BU ON
Q802 DTA114EK DSI control Hi output when DSI lit
Q803 DTC144EK AVR control switch On when P-ON 5V on
Q901 2SA1037K P-ANT circuit protection Antenna short-circuiting protection
Q902 DTA124EK P-ANT circuit protection Antenna short-circuiting protection
Q903 DTC144EK P-ANT circuit control switch P-ANT circuit control
Q94 2SB1443 P-ANT circuit control switch P-ANT circuit control
Q904 2SC2412K(S) ACC detection Lo output at ACC ON
GX-608EF2
5
SYSTEM MICROCOMPUTER : UPD784216GF526 (IC81 : X14-6212-70)
●Terminal Description
Pin Function I/O Description
1 AM+B O AM power output
2 FM+B O FM power output
3 P_MUTE O Power IC mute
4 P_STBY O Power IC standby
5 CD_SW3 I CD mechanism SW3
6 CD_MOTOR O CD mechanism loading motor
7 CD_LO/EJ I/O CD mechanism load/eject control
8 CD_MSTOP O CD mechanism mechanism stop
9 VDD -
10-23 CD_MRST O CD mechanism mechanism reset
11 CD_MUTE_L I Mute request from CD mechanism
(Lch)
12 BEEP O Beep output
13 CD_MDET I CD mechanism detection
14 CD_DATA_P I/O CD mechanism data line
15 CD_CLK O CD mechanism clock line
16 NC -
17 CD_MUTE_R I Mute request from CD mechanism
(Rch)
18 NC -
19 NC -
20 REF_CONT O A/D reference voltage control
21 CH_REQH I Communications request from
CDCH CH
22 TEST -
23 TYPE1 I Tuner setting 1
24 TYPE2 I Tuner setting 2
25 CD_SW1 I CD mechanism SW1
26 CD_SW2 I CD mechanism SW2
27 MUTE O Audio mute
28 P_ON O Peripheral power control
29 CH_ON O CDCH control output
30 CH_RST O CDCH reset
31 CH_MUTE I CDCH mute
32 ANT_CON O Antenna control
33 DC/DC O DC/DC
34 PACK_DET I
Cassette mechanism back detection
35 CS_STBY I Cassette mechanism standby
position detection
36 M_MOTOR O Cassette mechanism main motor
control
37 VDD -
38 X2 -
39 X1 -
40 VSS -
41 XT2 -
42 XT1 -
43 RESET I
44 BU_DET I BU detection
45 CD_SREQ I CD mechanism SIO
communications request
46 ACC_DET I ACC detection
47 ILLM_OUT O Illumination control
48 CH_REQC O Communications request from
CDCH CH
49 SC_REQ I
Communications request from panel
MICROCOMPUTER'S TERMINAL DESCRIPTION
Pin Function I/O Description
50 R_CLK I RDS CLK
51 AVDD -
52 AVREFO -
53 SMALL I SMAALL input
54 PHONE I Telephone detection
55 REEL_S I
Cassette mechanism reel pulse input
56 REEL_T I
Cassette mechanism reel pulse input
57 NC -
58 NOISE I Noise level
59 SMETER I S-meter level
60 MODE I
Cassette mechanism mechanism
position mode pulse input
61 AVSS -
62 SC_CON O Panel control output
63 SC_BUSY I Panel busy input
64 AVREF1 -
65 CH_DATAC I CDCH SIO input
66 CH_DATAH O CDCH SIO output
67 CH_CLK O CDCH SIO CLK
68 SC_DATA I CDCH SIO input
69 MC_DATA O CDCH SIO output
70 MC_CLK O CDCH SIO CLK
71 MC_REQ O Communications request to panel
72 NC -
73 PLL_CE O PLL SIO CE
74 PLL_DATA O PLL SIO output
75 PLL_CLK O PLL S10 CLK
76 DSI O Security LED control
77 TDF I Panel detach detection
78 SUB_P O
Cassette mechanism submotor control
79 SUB_M O
Cassette mechanism submotor control
80 KICK O Cassette mechanism kick control
81 R_DATA I RDS data
82 QUAL I RDS quality
83 PACK_IN I
Cassette mechanism tape insertion
detection
84 MUSIC O Cassette mechanism blank space
detection
85 MSGV O
Gain switching during tape search on
Cassette mechanism
86 F/R O
Cassette mechanism F/R switching
87 METAL I
Cassette mechanism metal detection
88 DOLBY O
Cassette mechanism Dolby switching
89 EQ_MUTE O Cassette mechanism EQ mute
90 NC -
91 NC -
92 AFC I AFC
93 IF_MODE O K21 IF status detection
94 WIDE O K21 control wide
95 NARROW O 21 control narrow
96 FM_SD I SD
97 SDA_IC2 I/O IC2 SDA
98 SCK_IC2 O IC2 SCK
99 A_SEL O Audio select
100 VSS -
GX-608EF2
6
Pin Function I/O Description
1 SC_BUSY O SYSCON panel busy output
2-8 NC -
9 VSS -
10,11 NC -
12-14 KR2-KR4 I Key read line
15-18 NC -
19-23 KS0-KS4 O Key scan line
24 VSS -
25-33 NC -
34 SC_REQ O Communications request to
SYSCON
35 RESET -
36 MC_REQ I Communications request from
SYSCON
37 KR1 I Key read line
38 KR0 I Key read line
39 SC_CON I SYSCON panel control
40 VDD -
41 X2 -
42 X1 -
43 IC -
44 XT2 -
45 NC -
46 AVSS -
47-54 NC -
55 AVDD -
56 AVREF -
57 VFD_ON O VFD power control
58 VFD_DATA O VFD SIO output
59 VFD_CLK O VFD SIOclock
60 VFD_LAT O VFD SIO latch
61 VFD_BLK O VFD blanking
62 MC_DATA I SYSCON SIO input
63 SC_DATA O SYSCON SIO output
64 MC_CLK I SYSCON SIO clock
MICROCOMPUTER'S TERMINAL DESCRIPTION
PANEL MICROCOMPUTER : UPD78011FGC599 (IC1 : X25-8502-70)
●Terminal Description
GX-608EF2
7
Pin Function I/O Description Processing Operation
1 BDO I Dropout signal input H: detected (Photodetector signal input 1)
2 OFT I Off track signal input H: detected (Photodetector signal input 2)
3 /RFDET I RF detection signal input H: detected (Photodetector signal input 3)
4 VDET I Vibration detection signal input H: detected (Photodetector signal input 4)
5 LDON O Laser on signal output H: ON (Photodetector RF signal adding input)
6 NC - No connection (RF amplifier filter terminal 1)
7 NC - No connection (RF amplifier filter terminal 2)
8 AVSS3 I Analog circuit GND
9 AVDD3 I Analog circuit power supply
10 FBAL O Focus balance adjustment output Laser diode monitor input
11 TBAL O Tracking balance adjustment output Laser diode drive output
12 FE I Focus error signal input (DA input)
13 NC - No connection (Tracking filter filter terminal 1)
14 NC - No connection (Tracking filter filter terminal 1)
15 TE I Tracking error signal input (analog input)
16 NC - No connection (Track cross comparator filter terminal)
17 NC - No connection
18 NC - No connection RF signal input (for RF detection)
19 RFENV I RF envelop signal input
20 VREF I VREF input terminal
21 ARF I RF signal input (for DSL)
22 DRF I DSL bias terminal
23 DSLF I/O DSL loop filter terminal
24 IREF I Reference voltage input terminal
25 PLLF I/O PLL loop filter terminal
26 PLFF2 I/O PLL loop filter properties switching terminal
27 VCOF I/O VCO loop filter terminal
28 VCOF2 I/O Digital servo 33.8688 MHz generating
VCO loop filter terminal
29 TRV O Traverse forced feeding output
30 TVD O Traverse drive output
31 PC O Spindle motor on detection L: ON
32 ECM O Spindle motor drive output (forced mode output)
(DA output)
33 ECS O Spindle motor drive output
(Servo error signal output)
34 KICK O Kick pulse output
35 TRD O Tracking drive output
36 FOD O Focus drive output
37 TOFS O Tracking offset adjustment output
38 AVDD2 I Analog circuit power supply
(for DSL, PLL, AD and DA sections)
39 AVSS2 I Analog circuit GND
(for DSL, PLL, AD and DA sections)
40 DVSS2 I Digital circuit GND
41 EFM or CK384 O EFM signal output Default : EFM signal output
When command executed : 16.9344 MHz clock
output
42 PCK or DSLB O PLL sampling clock output Default : PLL sampling clock output
When command executed : DSL balance output
43 /CLDCK O Subcode frame clock signal output
44 FCLK O Crystal frame clock signal output
45 IPFLAG O Interpolation flag signal output H: interpolation
46 FLAG O Flag signal output
47 TRCRS O Track cross signal input (Track cross signal output)
MICROCOMPUTER'S TERMINAL DESCRIPTION
MECHANISM MICROCOMPUTER : MN662770KA7 (IC2 : X32-4600-00)
●Terminal Description
GX-608EF2
8
Pin Function I/O Description Processing Operation
48 STOUT O Monitor signal serial data output
(OFT, VDET, BDO, RFDET, etc.)
49 STLD O Monitor signal load signal output
50 SMCK O Monitor signal bit lock signal output
51 CSEL I Crystal oscillator frequency setting terminal L: locked
H: 33.8688 MHz L: 16.9344 MHz
52 TEST1 I Test terminal 1 L: locked (normal)
53 TEST2 I Test terminal 2 L: locked (normal)
54 IOSEL I Audio DAC external data input mode setting
terminal
55 /NRST I Reset input L: reset
56 BCLK O SRDATA bit clock output
57 LRCK O L/R identification signal output
58 SRDATA O Serial data output
59 SUBC O Subcode serial output
60 SBCK I Subcode serial output clock input
61 DQSY O CD-TEXT read enable signal output
62 DEMPH O Deemphasis detection signal input L: ON
63 TX O Digital audio interface signal output
64 SRDATAIN I SRDATA input/test terminal
65 LRCKIN I LRCK input/SMCK output frequency switching
66 BCLKIN I BCLK input When not used: VDD
67 DVDD1 I Digital circuit power supply
68 X1 I Crystal oscillator circuit input terminal
69 X2 O Crystal oscillator circuit output terminal
70 DVSS1 I Digital circuit GND
71 XSUB1 I Microprocessor clock input terminal
72 XSUB2 O Microprocessor clock output terminal
73 DVDD2 I Digital circuit power supply
74-78 NC O No connection
79 CLVS O
Spindle servo phase synchronization signal output
H = CLV L = rough servo
80 TEST I Test mode switching terminal
81 ASEL I Audio output polarity detection terminal
82 PON O Audio and digital power supply control terminal
83 SEARCH O Servo IC gain switching control terminal
84 VER/HOR O Vertical/horizontal installation switching monitor
terminal
85 SW3 I Limit switch detection terminal
86 /MUTE_L O Lch analog mute control terminal
87 /MUTE_R O Rch analog mute control terminal
88 CD_R O CD-R control terminal
89 /RST I System reset input terminal
90 NC I No connection
91 /MSTOP I Standby detection terminal
92 NC O No connection
93 DATA I/O 12C bus data line
(communications line with system microprocessor)
94 /CLK I/O 12C bus clock line
(communications line with system microprocessor)
95 HOT I Temperature protection detection terminal
96 VREF+ I A/D converter power supply
97 OUTR O Rch audio output
98 AVDD1 I Analog circuit power supply
(for audio output section (both Lch and Rch))
99 OUTL O Lch audio output
100 AVSS1 I Analog circuit GND
MICROCOMPUTER'S TERMINAL DESCRIPTION
GX-608EF2
9
RDS function Market model SUBARU GENUINE model
AF search Can be switched on and off. Fixed to on.
· Default: On · AF search cannot be disabled.
·
With the auto memory function, only RDS stations can
be set in the memory for the FM band.
AUTO TP search Can be switched on and off. Fixed to off.
· Default: On · Even when TI is turned on, if the station currently
tuned in is not a TP station, it is never interrupted for
traffic announcements.
Auto antenna No auto antenna control for the E type. Auto antenna control is conducted.
· Even when set to another source, if an FM station is
tuned in in the background, the auto antenna output
is turned on.
UP/DOWN key versions
The UP/DOWN key operation is set with the menu.
When pressed normally: 1 step up/down
When pressed and held in: Auto seek
· No continuous manual up/down
· No AUTO 2
PRESET SCAN No preset scan function SUBARU GENUINE model preset scan is conducted.
· Tuning switches up to the next preset channel every
10 seconds. Once all the channels have been
scanned once, preset scan does not stop but
continues in the same band.
Source switching during TI and alarm interruption TI, news and alarm interruptions
interruption If the source is switched during an interruption, If the source is switched during an interruption,
the source to which the unit returns after the the interruption is suspended and to which
interruption changes, but the interruption the unit has been the source switched is played.
continues. If the source is set to all off, This suspension of the interruption is canceled
all off is set after the interruption is finished. under the following conditions:
(1) When the interruption broadcast
(TA ON or PTY = 1 or PTY = 31) ends.
(2) When RDS data could not be received for
15 seconds.
(3) When the power is turned off/on, ACC is
turned off/on or there is an instantaneous
power failure.
(4) If the TI interruption function is turned
off/on with the TI key while the TI interruption
is suspended.
(5) If the news interruption function is turned
off/on with the NEWS key while the news
interruption is suspended.
(6) When TEL MUTE is turned on/off.
(7) When the band or the frequency is switched
(included preset call) while interruption is
suspended on the FM band.
However, if the station is switched with AF
search, suspension continues.
News interruption News interruption disable time
If the source is switched during an interruption, The news interruption disable time cannot
the interruption is suspended, and after the be set.
disable time the unit interrupts if PTY = 1.
If the disable time is set to 0 minutes,
the unit re-interrupts after 10 seconds.
TEL MUTE during interruption TEL MUTE during interruption
(for TI, news and alarm interruptions) (for TI, news and alarm interruptions)
When TEL MUTE is generated, the interruption The operation during TEL MUTE is the same
is suspended and the unit returns to the as for the market model.
source prior to the interruption once TEL MUTE
is canceled, but if the broadcast is still on,
a new interruption is generated.
Differences in the RDS function between the overseas market model and the SUBARU GENUINE model
RDS DESCRIPTION
GX-608EF2
10
ADJUSTMENT
TEST MODE : ON While holding the preset "1" key and preset "3" key, reset the unit.
(Forced Narrow) Press "BAND" key. FM mode ON.
Press preset "5" key. "REP" goes ON.
Press preset "6" key. "RDM" goes OFF.
INPUT OUTPUT TUNER ALIGNMENT
No ITEM SETTINGS SETTINGS (RECEIVER) POINTS ALIGN FOR FIG.
SETTINGS
FM SECTION 98.1MHz TEST MODE:ON
SEPARATION 1kHz, ±40kHz dev Connect a (Forced Narrow) VR11 Adjust it so that the
1(NARROW) Pilot: ±6.0kHz dev AC voltmeter (X14-) crosstalk from L to R and R
Selector:L or R to SP OUT FM 98.1MHz to L become minimum.
60dBµ(ANT input) While holding preset "1" key,
98.1MHz TEST MODE: ON press and hold preset "6"
2 ANRC 0 dev – Preset "1" key, key for a few seconds.
35dBµ(ANT input) FM and preset "6" key "ADJ OK" is displayed if the
98.1MHz adjustment is OK and "ADJ NG"
is displayed if it is not good.
AM SECTION While holding preset "1" key,
999 kHz TEST MODE: ON press and hold preset "6"
(1) SD VOLTAGE 0% mod – Preset "1" key, key for a few seconds.
35dBµ(ANT input) AM and preset "6" key "ADJ OK" is displayed if the
999 kHz adjustment is OK and "ADJ NG"
is displayed if it is not good.
CASSETTE DECK SECTION
TCC-153 Connect a Head Azimuth Adjust the azimuth for each
[1] AZIMUTH 10kHz AC voltmeter TAPE PLAY Screw Lch/Rch or FWD/RVS
to SP OUT becomes maximum
PLAY BACK Connect a VR1 (L)
[2] LEVEL TCC-130 AC voltmeter TAPE PLAY VR2 (R) 300mV (a)
to CN1 (X14-)
F/E
CASSETTE MECHANISM VR11
VR2
CN1
VR1
R
G
L
(X14-6212-70)
(a) 300mV
AC voltmeter
Set the controls and switches as follows.
BALANCE :center position BASS :center position LOUD :OFF DOLBY NR :OFF
FADER :center position TREBLE :center position
11 12
ABC ED F G IH
1
2
3
4
5
6
7
PC BOARD (Component Side View) PC BOARD (Foil Side View)
CD PLAYER UNIT CD PLAYER UNIT
A.5V
BU.+5V
R16
C14
IOP+ IOP-
VREF
GND
RF
ARF
C23
TE
TR.IN R18
LDON
NC
C17TE
C5
C7
R14
R13
C32
16
C15
Vcc
R5
VR
R11
C6
R10
PD
CN1
FCS+
R2
PD2
R3
R15
E
+
FE
R1
PD1
R6
1
F
FCS-
S.+B
TRK-
R12
TRK+
LD
A.+B
CP3
Care!
22
AL
Rch
CN2
R34
R36
R38C25 R37
C26
C28
C62
C21
C24
C35
R35
C33
R32
R54
C54
C22
X1
D.OUT
R205
R31
R46
/MSTOP
BE
R47
L2
C31
CP2
CP1
Lch
A.GND
SPDL-
R104
R102
SPDL+
D.GND
/RST
C56
R45
/MRST
C66
R108
R106
8
I
G
O
5
C64
E
BE
B
SW2
/CLK
SW1
C65
R107
R101
R103
R94
BU.5V
C55
R93
C61
DATA
R92
R91
C63
1
4
R105
R82
C45
C101
LOAD
SLED+
S.GND
SW3
SLED-
EJECT
1
R51
R75
R74
R71
C102
R203
R72
C43
R79
R73
R81
C44
R80
R204 R83
R50
R77
C34
R44
EB
MUTEL
MUTER
R76
C41
LO/EJ
MOTOR
C53
R78
Q3
D2
D3 Q4
Q5
Q2
IC6
IC5
/RFDET BDO
C16
R17
TRCRS
DE
OFT
R202
C13
VDET
B
C8
C9
C1
R8
L1
C4
18
C12
C11
C10
1E
R9
C19
R19
C2
19
C20
R21
C18
R20
R39
36
R7
R40
A
R4 C40 B
C
EB
C3
IPFLAG
26 25
C29
FLAG
ST-O
51 50
C46
76
TEST
1
100
75
DQSY
R42
R52 R49
C51
14
1
15
28
Q1
IC1
Q6
D1
S1
IC2
S2
S3
IC4
X32-4600-00 (J74-0888-12)
BU.+5V
TRK-
AL
E
Rch
NC
VREF
RF
TE
IOP-
ARF
IOP+
GND
SW3
S.+B
S.GND
Vcc
PD1
VR
LD
FCS+
FCS-
A.+B
FE
/CLK SW1
BU.5V
SPDL-
/MSTOP
/MRST
A.GND
F
A.5V
D.OUT
MOTOR
LO/EJ
/RST
DATA
SW2
SLED+
LOAD EJECT
SLED-
TRK+
PD
TE
LDON
TR.IN
MUTER
MUTEL
D.GND
Lch
SPDL+
PD2
1
1
+
8
IGO
Care!
C41
X1
CP1
CN2
R32
R35
C24
R36
C26
R34
R77
R37 C28
C101
C25
R46
R73
R74
C21
R75
R80
CP2
CP3
R50
R54
C22
C43
C23
R72
R71
R205
R31
C44
R81
R79
R83
C45
R82
C33
L2
R47
C32
C31
R78
R76
R102
R44
R92
R18
R6
R3
R13
R51
C53
R104
R94
C17
C62
C64
R45
R15
C15
C14
R16
R106
C61
R12
R10
R14
C7
C6
R11
C5
R5
R93 C63
R103
R101
R1
R105
C56
R91
R108
R107
C66
C65
C55
C34
C35
C54
CN1
R2
R204
C102
R203
R38
EB
BE
EB
EB
22
1
54
16
Q4
IC5
D2
D3
IC6
Q3
Q2
Q5
IC2
IC1
IC4
D1
S3
Q1
S2
S1
Q6
OFT
/RFDET BDO
TRCRS
A
VDET
DE
C
B
1
1
1
25 26
100
ST-O
FLAG
IPFLAG
DQSY
TEST
76 75
51
C4
L1
R7
C29
C46
R52 R49
R42
R9
R4
C20C19
R20
R8
C1
C8
C12
C10
C9
C11
C3
C51
C2
C18
R17
C16
C13
R19
R202
R21
C40
R40
R39
E
BBE
50
18 19
36
14 15
28
X32-4600-00 (J74-0888-12)
Refer to the schematic diagram for the values of resistors and capacitors.
CD PLAYER UNIT
(X32-4600-00)
.ON.feR sserddA
CIQ
1A4
2B4
4C2
5C3
6C3
1A4
2C4
3C3
4B3
5C4
6B4
.ON.feR sserddA
CIQ
1H4
2G4
4F2
5F3
6F3
1H4
2F4
3F3
4G3
5F4
6G4
CD PLAYER UNIT
(X32-4600-00)
RQPN OMLJ K
1
2
3
4
5
6
7
13 14
Refer to the schematic diagram for the values of resistors and capacitors.
SYNTHESIZER UNIT SWITCH UNIT
PC BOARD (Component Side View)
C134
R919
R307
R4
R7
R8
R9
R5
R811
R723
R724
R722
R11
R1
R2
R3
R10
R843
R836
R838
R844
R853
R852
R833
R817
R819
R812
R600
R830
R317
R318
R319
R315
R316
R320
R304
R301
R302
R303
R311
R312
R701
R703
R606 R607
R609
R704
R404
R405
R406
R401
R402
R403
R407
R420
R601
R408
R410
R235
R33
R34
R29
R30
R114
R115
R116
R104
R106
R21
R14
R22
R26
R23 R24
R25
R203 R204
R227
R130
R201
R202
R228
R232
R231
R120
R121
R122
R719 R718
R717
R123
R128
R125
R716
R894
C216
C217
C222
C223
C221
C220
R908
R907
R909
R906
R905
R902
C311
C312 C310
C308
C309
C13
C229
C307
C303
C304
C30
C31 C29
C27
C28
C32
C104
R915
C103
C101
C102
C18
R918
C17 C24 C23
C123
C122
C120
C125
C129
R912
C128
C126
C112
C113
C111 C108
C109
C119
C117
C115
C116
C4
C725
C809
R868
C808
C806
C807
C710
R874
C723
R871
C1
R101
C2
R861
R859
R855
C902
C901
C812
C904
R866
C709
C402
C419
R882
C601
C403
C404
R883
C11
R884
R881
C615
C702
C704
C705 C706
C611
C605
C606
C401
R506
R507
R605 R504
R603
R511
R512
R608
R510
R509 R712
R604 R502
C411
C412
C413
C414
C418
C724
C415
C416
C417
R415
R414
R413
R418
R417
R416
R412
R101
R411
C219
R103
R126
R127
R129
C719
C5
R708
R207
C814
R308
C501
C33
C815
R614
C616
R205
C502
W400
R726
R727
R728
R729
BE
EB
BE
BE
EB
EB
BE EB
EB
EB
BE
EB
EB
BE
BE
EB
EB BE
BE
EB BE
BE
BE
BE
BE
EB
BE
EB
BE
D202
D503
D504
D502
D204
Q201
Q604
Q607
Q602
Q601
Q5
Q6
Q4
Q2
Q3
Q104
Q107
Q102
Q8
Q9
Q608
Q803
Q802
Q709
Q901
Q903
Q902
Q702
Q610
Q609
Q703
Q708
Q707
Q705
D205
R13 C8
F2 F1
R
GND
RESET
HIUP
L
LR
FR
RR
RL
FL
4.332MHz
X11
W11
C215
R611
R612
R610
C714
L11
C703
R37
R38
R36
R35
R901
R903
R904
R720
R6
C133
C810
C903
C130
C127
C132
C131
C406 C407
C405
C715
C408
C612
C12 C15 C16
C7 C9
C10
C124
C214
C22
C212
C410
C409
C610
C208C206 C207
C209
C203 C204
C205
C21
C210 C211
C213 C218
C3
C614
C613
C707
C722
C718
C711
C604
C602
C608
C721
L71
L72
L12
C202
C201
C720
L61
GND
VPP
VR2
VR1 VR11
DOLBY
L21
L14
L13
L17
L801
L15
L16
R807
R808
R809
R810
R806
R800
R721
R805 R801
R803
R804
R842
R837
R839
R850
R849
R846 R845
R848 R847
R816
R815
W81
R828
R829
R823
R826
R702
R710
R711
R713
R705
R707
R709
R419
R32
R31
R102
R105
R15
R16
R12
R27 R28
R851
R229 R230
R715
R714
R124
R832
R895
R897
R896 R893
R911 R910
R899
R898
R900
C313
C14
R889
C314
R890
R892
R891
C19 C20
C25 C26
R914
C121
R913
C114
C118
C713
R873
C712
C716
R869
R870
R872
R860
R856
R857
R858
R867
C813
R863R862
R864 R865
W82
C603
R602
R888
R887
R886
R885
R877
R876 R875
C708
R878
R880
R879
R508
R503
R505
R706
C803
R119
R117
R118
X81
R802
R820
X82
R208
R725
R206
R922
R920
C905
C906
L62
R840
R818
R209
R835 W12
R834
W201
R921
R831
W317
W318
R841
R923
R822
R821
C800
C801
BE
BE
BE
BE
BE
BE B
E
BE
BE
BE
BE
22 1
13
1717
14 814 8
85
14
5
8
1
4
1
7
814
1
30
31
50 51 80 81
100
1
7
8
14
28 15
14
1
10 40
20 31
1
30
21
11
1
4
8
5
18
16 9
1
13
14 25
13
45
BE
19
6
1
2
119
20
31
24
12
1
1
25
24
2
1
1
7
34
14
6
3612
13 57
8249
110 11
1
4
58
B
EB
E
B
E
BE
E
BEB
BE
BE
D701
D902
D705
Q202
E1
D802
D712
D804
D901
Q704
Q706
Q606
Q605
Q701
D710
D713
D903
D708
Q94
Q7
Q1
D707
D4
D3
D601
D703
D604
D2
D709
D1
D702
A11
IC41
J2
J1
CN2
CN81
A61
CN1
(J74-1018-22)
X14-6212-70
Q603
IC83
IC22
IC13
IC84
D201
D103
D706
D203
D501
Q103
Q101
IC32
IC31
IC12
IC72
Q110
Q108 Q109
Q203
Q904
IC82
IC21
IC2
IC71
IC1
IC81
IC90
D208
Q205
Q905
D206
D207
Q204
D904
D602
CN82
R22
R19
R20
R25
R26
R23
R24
R11
R12 R17
R18
R16
R27
R38
R39
R36
R37
R43
R40
R41
R30
R31
R28
R29
R34
R35
R32
R33
R1
R2
R3
C1
L1
R4
R8
R9
R10
R6
R7
R5
C6
C3
X1
R44
EB
EB BEBE
1
64 16 17
32
33
48
49
2
1
19
20
D6
D1
D2
Q1
Q4Q3Q2
D5
D4
D9 D7
IC1
CN1
D8
PL6
PL6
PL7
PL2
PL1
PL3
PL4
PL8
POWER
MUTE
TONE
VOL+ RESET
VOL-
123456
PL5
CS EJ
TDF
DISP
NEWS
SCN
T.I
CHR
TAPE
CD
BAND
CD EJ
13 14
61715
D3
S1
ED1
S10 S5
S15
S20
S3 S24
S8
S13 S18 S23 S4 S9 S14
S21
S25
S11
S16
S19
S6
S17
S12
S7
S2
S22
X25-8502-70 (J74-1019-22)
.ON.feR sserddA
CIQ
1Q4
1Q3
2Q3
3Q3
4Q3
SWITCH UNIT
(X25-8502-70)
SYNTHESIZER UNIT
(X14-6212-70)
.ON.feR sserddA
CIQ
1L5
2K5
21M4
31N5
12L4
22M4
13L3
23M3
14M1
17N2
27L3
18K4
28K5
38K3
48L3
09K3
1J3
2J4
3L5
4L5
5K5
6J5
7K5
8K5
9K5
49J2
101M3
201N3
301M3
401N3
701M3
801N4
901N4
011N4
102L4
202L3
302L3
402L4
502L4
106J3
206J3
306J3
406J3
506J5
606J5
706J5
806J5
906J4
016K4
107K1
207K2
307K2
407N2
507N2
607K1
707K2
807K3
907K3
208K4
308K3
109K3
209J3
309J3
409K3
509K3
STU WV X Y AAZ
1
2
3
4
5
6
7
15 16
Refer to the schematic diagram for the values of resistors and capacitors.
PC BOARD (Foil Side View)
SWITCH UNIT SYNTHESIZER UNIT
R36
R43
R34
R26
R19
R10
R18
R8
R25
R7
R20
R37
R40
R11
R12
R39
R38
R44
1
2
49
64
R16
R35
R17
R24 32
R23
R22
17
R28
R33
33
R29
X1
48
16 1
L1
R32
R30
R31
R27
EEBB
20
19
C6
R2
R6
R41
BE
BE
R5
R9
R4
R3
C3
C1
R1
D8
D4
D7
D6 IC1
D9
Q4 Q3
CN1
D5
D1
Q2
Q1
D2
DISP
NEWS
SCN
CHR
PL8
T.I
TDF
PL7
TAPE
CD
BAND
CD EJ
65
PL5
CS EJ
43
PL6
17 15
PL1
21
PL4
VOL-
PL3
RESET VOL+
TONE
14 631
MUTE
PL2
POWER
S11
S16
D3
S19
S17
S6
S25
S12
S7
S2
S22
S14 S9
S21
S4 S23
ED1
S13
S18 S8
S24
S20
S3
S15
S5 S10
S1
X25-8502-70 (J74-1019-22)
EB
C723
C309
C310
R907
R717
R318
R317
R722
B
R607
R606
R600
R605
BE
R609
R608
R603
E
R604
C611
R909
BE
R33
EB
E
C606 C615
C605
R833
R836
R614
C616
R3
R2
R1
R5
R9
R7
R4
C1
C2
EBE
B
R843
C806
C807
E
R830
R838
B
BE
R8
BE
R882
R866
R852
R853
C28
C27
BE
B
R884
R34
C32
C30
C31
C29
C4
EB
EB
R11 C33
C11
C13
R14
R23
R21
C17
C18
R812
R817
R883
R855
C812
R859
R861
C808
R868
R871
R874
C815
C814
EB
R881
R894
R918
R906
R844
R819
R811
BE
R719
EB
R718
R912
R908
R905
C904
C216
R232
R228
R201
R10
R207
R231
R227
R24
R22
EB
R202
R205
R512
R308
R312
R304
C217 C304
R316
R320
C308
C312
C119
R123
R26
R126
C122
C23
R25
R29
C24
C129
R127
R129
R122
C125
C126
C128
C123 C120
R125
C115
C112
R204
R30 R203
C229
C223 C222
C221
C220
C219
R235
C5
C116
R120 R128
R311
R303
R307
C303
C311
R319
R315
C307
EB
R103
B
R101
E
C101E
C102
R116
R115
C117
R121 R114
C113
C111
C109
C108
R130
C103
R104
R106
C104
B
R509
R601
B
E
C601
C901
C902
R902
E
B
BE
R507
R506
R504
R502
C719
EB
E
R716
R724
C705 C706
R415
R915
C809
R723
R919
BE
C501
C502
R511
R510
C704
R701
EB
C412
C414
C413
C411
C725
R712
C418
C416
R418
C415
R414
R412
R413
R411
R416
C419
R406
R405
R302
R301 R726
R727
R728
C134
B
R729
C702
R417
C417
C404
R408
C401
C402
C403
R407
R402
R401
R403
R404
R101
C710
R703
C724
R708
C709 R704
W400
R420
EB
R410
Q609
Q610
Q607
Q608
Q6
Q5
Q2
Q601
Q604
Q903
Q8
Q9
Q4 Q3
Q802
Q803
Q708
Q201
D205
D204
D202
Q107
Q104
Q902
D504
Q602
D503
D502
Q901
Q703
Q707
Q709
Q702
Q102
Q705
8
E
C612
R901
R610
RR
W81
R850
R856
C810
C608
C614
B
EEB
R612
R611
E
1
6
X81
19
R846R848
R839
R849
R847
R845
R842
R829
RESET
X82
R837
C604
L62
C613
R602
B
EB
R6
R828
R832
C720
8
C206
110
C813
R867
R858
R857
R860
R889
R12 C3
R16
4
3
5
1
21
C610
20
19
EB
14
13
R863R862
R864
R870
R872
25
1
R851
R876
R878
R879
R880
R38
C8
R35
R36
R37
C9 C7
C21 C12C15
20
R13
21
11
30
31
40
R887
R888
R892
R890
R898
R899
R910
R895
R823
VPP
R865
51 50
R869
R875
R873
31
30
R891
R885
R886
R877
80
81
R900
R896
R897
1
100
R800
R893
R913
R911
R914
R831
R820
R821
R822
R834
R835
C800
R826
C801
R815
R816
W82
R840
GND
14
4
R808
R807
R805
R806
R810
R809
5
C803
R804
R803
R801
EB
R818
R802
28
R206
C201
C10
C203
E
E
B
B
1
R229
14
R230
C209
C14
C204
R15
C210
C214 7
8
1
1
C202 8
C213
R209
BE
B
C215
R715
L21
C218
C205
14
1
C716
C313
5
4
R117
C121
C26
R124
R32
R
C127
4.332MHz
C16
L17
R31
C19
R27
C25
C20
R28
C130
X11
C124
8
1
VR1
8
DOLBY
16
9
L
3
1
R
GND
1VR2
L
R119 C132
15
C212
C22
C211
14
L16
R118
1
C118
C133
C314
C207
C208
7
FL
1
FR
14
7
RL
8
L14
12
W12
L15
R105
EB EB
L13
HIUP
EB
C114
EB
E
B
VR11
24
R841
C903
C602
C603
R505
L61
R508
R903
L801
B
E
R904
R725
C718
12
C712
R706
5133
76
R709
R707
11 1
98
10
42
R503
C713
R711
R720
B
E
W318
L71
22
R721
7
1
C721
C722
1
8
R922
C906 4
5
R921
C905
R920
BE
R923
C703
L72
C707
R710
7
13
R714 W201
R208
C714
R713
5
C715
4
8
1
C405 C406
1
C408
4
14
6
B
E
F2
F1
2
24
R702
C711
W317
C407
L12
C131
R102 L11
1
C409
W11
1
C7081
R705
3
R419
C410
25
BE
D903
D2
E1
Q605 Q606
D604
D602
Q603
A61
D1
Q1
CN81
IC2
IC82
Q7
D4
D3
IC1
Q203
IC84
IC81
Q904
Q204
D201
D207
Q205
D206
IC21
Q202
D203
IC31
IC12
IC13
CN1 D103
Q110
IC22
CN2
IC32
Q103
Q101
Q109
Q108
A11
X14-6212-70 (J74-1018-22)
D703
J1
D601
D901
Q94
D705
D902
D706
D501
D712
D710
D709
Q706
D904
Q905
IC83
D804
D802
D713
IC90
D702
D701
J2
D208
D708
IC72
CN82
Q701
D707
IC71
Q704
IC41
.ON.feR sserddA
CIQ
1X5
2Z5
21W4
31W5
12Y4
22X4
13X3
23X3
14X1
17W2
27X3
18Z4
28Z5
38Z3
48Y3
09Z3
1Z3
2Z4
3Y5
4Y5
5Z5
6Z5
7Z5
8Z5
9Z5
49Z2
101X3
201W3
301X3
401W3
701W3
801W4
901W4
011W4
102Y4
202Y3
302Y3
402Y4
502Y4
106AA3
206AA3
306AA3
406AA3
506AA5
606AA5
706AA5
806AA5
906Z4
016Z4
107Z1
207Z2
307Z2
407W2
507W2
607Z1
707Z2
807Z3
907Z3
208Y4
308Z3
109Z3
209Z3
309Z3
409Z3
509Z3
.ON.feR sserddA
CIQ
1T4
1T3
2T3
3T3
4T3
SWITCH UNIT
(X25-8502-70)
SYNTHESIZER UNIT
(X14-6212-70)
CAUTION:For continued safety, replace safety critical components only with
manufacturer’s recommended parts (refer to, parts list). Indicates safety critical
components. To reduce the risk of electric shock, leakage-current or resistance
measurements shall be carried out (exposed parts are acceptably insulated from
the supply circuit) before the appliance is returned to the customer.
ABCDEFG IH
1
2
3
4
5
6
7
123 1110987 654
12 13 14
REQ H
CH-CON
MUTE
A.GND
D GND
6
5
3
4
2
1
DATA C
GND
REQ H
CH CON
MUTE
A GND
Rch
RST
Lch
CLK
RESET 13
7
12 DATA H
DATA C
REQ C
Rch
B.U. 10
11
9
8
2
4
3
812
7
6
11
10
159
DATA H
Lch
CLK
REQ C
10
12
13
9
13 62
51
48
11 7 3
BU
R502 47
R503 4.7K
R504 4.7K
R505 2.2K
R511 10
R507 2.2K
R510 10
R506 2.2K
R508 47
R509 47
C501 1200P
C502 1200P
R512 20
7
6
5
21
29
30
31
66
65
67
48
SMALL
FR-
FR+
FL-
FL+
ACC
GND
RR-
RR+
RL-
RL+
P-ANT
BU
NC
RL+
RR+
RR-
FR+
FR-
RL-
FL-
FL+
5A
F2
170uH
L72
2
4
6
8
10
12
14
16
18
20
22
24
GND
VCC
GND
GND
NC
VCC
GND
STBY
BEEP
GND
GND
MUTE
1
3
5
7
9
11
13
15
17
19
21
23
25
OUT+
OUT-
OUT+
OUT-
OUT+
OUT-
OUT+
OUT-
IN
IN
IN
IN
RIP FIL
7.5K
R706
R709 1K
R725 47K
0.01
C712
R707 22K
R710 3.9K
4.7K
R711
C713 0.022
3900P 3900P
10K 10K
W400
1.6K
R408
1.6K
R406
100
R420
2.2u50
C410
+
C401C402
R402 R401
3900P3900P
10K
R404 10K
R403
C404 C403
2.2u35
+
C408
+
C406
2.2u35
0.1
C416
0.1
C415
0.1
C418
0.1
C417
0.1
C412
0.1
C413
0.1
C411
0.1
C414
2.2
R416
2.2
R415
2.2
R418
2.2
R417
2.2
R412
2.2
R413
2.2
R411
2.2
R414
C409 47u16
+
2.7K
1000P
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
SW3
SGND
S7.5V
MOTOR
LO/EJ
Rch
AGND
Lch
A+8V
MSTOP
MRST
MUTE L
MUTE R
D.GND
BU+5V
NC
MECHA
DATA
CLK
SW1
SW2
DOUT
9
8
7
6
5
4
3
2
1
DET
MTL
GND
M+B
STBY
DGND
REELT
REELS
SW5V
114
2
4
3
VCC
13
12
6
5GND 10
11
9
78
VCC
GND
5
6
8
7
2
4
3
1
PHONE
L71
170uH F1
10A
C701 4700u16
+
C702 0.022
R726 13K
R727 13K
R729 13K
R728 13K
470
R701
C705 0.1
C704 0.022
C703 2200u18
+
0.1
C706
C707 100u10
+
C708 0.1
IN OUT
GND
C724 0.1
8.2K
R708 15K
R703
15K
R704
220
R702
C709 1R705 4.3K
C710 0.1
C711 100u10
+
RR+
RL+
RR-
RL-
FL+
FL-
FR-
FR+
270
R1
100K
R2
100K
R3
55
56
87
34
35
R4 100K
R7 100K
10K
R8
1K
R6
10
25
26
15
14
45
17
11
8
1
14
6
5
2.2
R720
100
R717
C719 0.22
22K
R724
C721 330u6.3
+
0.047F5.5
C720
+
10u16
C718
+
+
C722 100u10
47K
R718
R719
100
R716
78
69
5
4
10
11
3
2
114
13
12
13
2
1/2W
R915 10K
C809
0.1
1 2 3 4 5 6 7 8 9 1011121314151617181920
LAMP-
LAMP-
FDC+
FL +B
FDC-
FL-GND
D-GND
D-GND
RESET
BU 5V
SC-REQ
SC-DATA
MC-DATA
MC-CLK
SC-CON
SC-BUSY
MC-REQ
RST SW
TDF
DSI
1200P
C723
13K
R723
C904
1200P
R908
13K
2.2K
R905
22uH
L61
36
6
4
3
5
2
1
GND
VCC
BU
GND
+B
FDC-
GND
FDC+
22uH
L62
22K
R614
330u10
+
C614
C615 0.1
C616 0.1
C608 100u35
+
R612 5.6K
R611 5.6K
C605 0.1
C604 100u16
+
+
C612 4.7u35
C606 0.01
C603 0.1
R602 10K
470
R601
2.2 1W
R610
68
69
70
62
63
71
77
76
4
5
10u25
+
C610
0.22
C611
R609 22K
R603 4.7
R604 4.7
R608 4.7
R605 4.7
4
5
4
100
2.2u35
C405
+
R405
1.6K
R407
1.6K2.2u35
C407
+
W318
W317
3
R302
10K
R410
C419
C310 330P C312 330P
R320 4.7K
10K
R304
R316 130K
R312 430
C308 0.15
C304
0.15 R308
2.2K
21
4.7uH
5
4
VCC
OUT
1
2
3
NC
SUB
GND
44
43
R909 4.7K
R810 4.7u16
+
R852
4.7K
2.2K
R853
L801
GND
10V
15
16
17
18
19
20
21
22
23
24
25
26
27
28
OUTL
OUTR
QUAL
SMUT
SCL
SDA
GND
VCC
OUTRR
OUTRL
OUTFR
OUTFL
AC
AC
14
13
12
11
10
9
8
7
6
5
4
3
2
1
MPOUT
MPIN
LEVEL
MPX
AM
PH+
PH-
CHL
CHG
CHR
R
L
CREF
VRFE
8
9
10
11
12
13
14
VCC
SW2
ROUT
RIN2
RIN1
7
6
5
4
3
2
1
GND
SW1
LOUT
LIN2
LIN1
C714 220u10
+20
R712
17
17
21
8
9
10
11
12
13
14
7
GND VCC
6
5
4
3
2
1
R315 130K
R311 430
C307 0.15
R307
2.2K 0.15
C303
C311 330P C309 330P
R319 4.7K
10K
R301
R303
10K
R318 4.7K R317 4.7K
0.1
C216
100K
R201
47K
R202
2.2K
R232
47K
R228
47K
R230 47K
R229
2.2K
R231
47K
R227
7
12
3
14
1
R419 12K
23
25
26
24
24
23
26
25
C314 0.1
R714
5.1K
R715
470
10K
R713
10u6.3
+
C715
0.01
C725
0.1
C718
OUTR
OUTL
C217
0.1
4.7uH
L21
47u16
C218
+
3.9K
R204
97
98
C206 4.7u16
+
C205 4.7u16
+
C208 3.3u16
+
C207 3.3u16
+
W201
C229 0.015
C219 0.47 4.7K
3.3u16
+
1K
R205
C209
R207
270
R206
270
0.47u50
C202
0.47u50
C201
100
R606 100
R607
0.082
C220
R203 4.7K
C221 0.1
C222 120P
C223 0.033
R235
10K
R209
1u50
+
C215
10K
R208
11
10
13
C211 0.47u50
C213 47u16
+
C210 3.3u16
+
+
4.7u16
5
7
6
C212 0.47u50
C214
10u16
C203
+
10u16
C204
+
470
R5
0.01
C1
0.01
C2 470
R9
PACK
1/2W
4.7K
10K
R906
22K
R907
22K
R722
10K
R721
33
R843 100K
R840 100K
46
47u16
+
C602
0.1
C601
1/2W
1/2W
C613 100u16
+
47K
R919
SW IN
RES
DET IN
BU
C313
0.1
47
43
49
8
9
7
6
5
4
3
2
1
E39-0132-05
SUB+ 1
MODE
P-IN
SUB-
4
3
2
55V
SGND
DGND 7
6
9
8
F-L
R-L
SGND 10
R-R 12
11
F-R
21
22
18
19
20
15
16
17
12
13
14
9
10
11
7
8
4
5
6
2
3
1
E39-0307-05
PIN No. PIN NAME PIN No. PIN NAME
J2
J1
D501
D502
D504
D503
D706
W2
D705
CN82
E1
D707
D702
BU 5V
D703
D701
MECHA
7.5V
Q704
Q705
Q701
Q702
Q703
D1 D709 Q706
Q707
D710
D712 Q708
MUTE
FIRST
D802
D804
CN81
D713
D903
Q1
Q2
Q603
Q604 Q602
Q601
D601
D602
D604
Q605
Q606
Q608
+36dB
35W 4ch
MPX E.VOL
LAMP AVR
Rch
Q607
Q609
Q610
RESET
Lch
FR RR RL FL
Q201
INPUT
SELECTOR
D206 D207
Q204 Q205
D204 D201
Lch FIX EQRch FIX EQ
D708
VREF
Q203 D208
D203
D205
Q202
D202
5V
P.ON
Q709 Q904
ACC
DET
DET
BU
DC/DC AVR
DC/DC
Lch Rch
CD
CD
CS
CS
LEAD WIRE
CASETTE MECHA
(D40-1079-05)
CN2
CD MECHA
(X32-4600-00)
FLAT CABLE
(X14-6212-70)
IC41
IC32
IC72
IC31
IC71
IC83
A61
IC82
IC22
IC21
22K
22K
22K
22K
10K
10K
22K
22K
22K
22K
22K
22K
10K
47K
10K
47K
10K
10K
47K
47K
4.7K
4.7K
5V
0V
5.0/0V 0V
5.0/0V
5.0/0V
0/5.0V
0/5.0V
5.0/0V
5.0/0V
5.0/0V
0/5.0V
0/5.0V
5.0/0V
5.0V
0/5.0V
13.2V
0V 1.3V
6.5V 0V
13.2V6.5V
0V
0V
6.5V
6.5V
0V
6.5V
6.5V
6.5V
13.2V
0V
4.1V
0V
0V
0/5.0V
6.5V
0V
0V
13.2V
0V
0V
1V
4.0V
0V
4.0V
4.0V
8.0V
0V
8.0V
4.0V
8.0V
4.0V
4.0V
4.0V
4.0V
4.0V
0V
4.0V
4.0V
4.0V
4.0V
4.0V
8.0V
4.0V
4.0V 4.0V
4.0V
4.0V 4.0V
4.0V
4.0V
4.0V
4.0V
4.0V
4.0V8.0V
4.0V
0V
4.0V
3.6/0V 4.0V
0-5.0V
0-5.0V
5.0V
5.0V0V
0V
5.0V
4.0V
4.0V
4.0V
0V
0V
8.0V
8.0V
4.0V
4.0V
4.0V
8.0V
4.0V
4.0V
4.0V
4.0V 4.0V
4.0V 4.0V
4.0V 4.0V
4.0V 4.0V
0/8.0V 0/8.0V
8.0V 0V
4.0V
DC voltages are as measured with a high impedance voltmeter. Values may vary slightly
due to variations between individual instruments or/and units.
JKLMNOP RQ
1
2
3
4
5
6
7
GX-608EF2
1/2
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
CH RST
CH ON
P ON
MUTE
CD SW2
CD SW1
TYPE2
TYPE1
TEST
CH REQH
REF CONT
NC
NC
CD MUTE R
NC
CD CLK
CD DATAM
NC
BEEP
CD MUTE L
CD MRST
VDD
CD MSTOP
CD LO/EJ
CD MOTOR
CD SW3
P STBY
P MUTE
FM+B
AM+B
VSS
A SEL
SCK IC2
SDA IC2
FM SD
NARROW
WIDE
IF MODE
AFC
NC
NC
EQ MUTE
DOLBY
METAL
F/R
MSGV
MUSIC
PACK IN
QUAL
R DATA
AVDD
AVREF0
SMALL
PHONE
REEL S
REEL T
TEMP
NOISE
SMETER
MODE
AVSS
SC CON
SC BUSY
AVREF1
CH DATAC
CH DATAH
CH CLK
SC DATA
MC DATA
MC CLK
MC REQ
NC
PLL CE
PLL DATA
PLL CLK
DSI
TDF
SUB P
SUB M
KICK
CH MUTE
ANT CONT
DC/DC
PACK DET
CS STBY
M MOTOR
VDD
X2
X1
VSS
XT2
XT1
RESET
BU DET
NC
ACC DET
ILLM OUT
CH REQC
SC REQ
R CLK
1RF GND
FM ANT
2
3AM ANT
L12 10uH
3.3uH
L13
22K
R102
10u10
+
C101 0.01
3.3uH
L14
18
R130
10u10
C133
+
0.01
C111
1K
R101
C134 150P
52mH
L11
FM VCC
4
AM VCC
5
AM LO/DX
6
7FM LO/DX
REQUEST
IF SELECT
RDS OUT
10
9
8
11 K2IVth
10u10
+
C102 0.01
2
1
95
94
96
59
0.01
C108
L15 4.7uH
470P
C109 100K
16
1M
1
15K
0.01
15
14
13
12
17
19
20
21
22
23
24
FSD OUT
VCO GND
FM SD
FM DET OUT
AM DET OUT
IF MODE OUT
COMMON +B
IF GND
HI UP ADJ
PLL CE
PLL DATA
P-ON 5V
PLL CLK
D GND
93
11
10
R105
22K
1K
R103
C131C132
9
10
R104
C103
R106
C104
2.7K
VR11
W12
4.7uH
L16 74
73
75
10
9
8
7
6
5
4
3
2
1
40
39
38
37
36
35
34
33
32
31
21
22
23
24
25
26
27
28
29
30
11
12
13
14
15
16
17
18
19
20
T/R
N.C
DET(R)
N.C
PBOUT(R)
RAI(R)
BIAS
DIN(R)
EQOUT(R)
M-OUT(R)
NFI(R)
RIN(R)
VREF
FIN(R)
GND
GND
FIN(L)
RIP
RIN(L)
NFI(L)
MSGV(R)
N.C
DET(L)
N.C
PBOUT(L)
RAI(L)
N.C
DIN(L)
EQOUT(L)
M-OUT(L)
NR OFF/ON
NOR/MTL
F/R
MSGV
MSOUT
VCC
MSDET
MSI
MAOUT
MSGV
12
11
10
9
8
7
6
5
4
3
2
1
F-R
R-R
SGND
F-L
R-L
SGND
DGND
5V
MODE
P-IN
SUB-
SUB+
1
2
3
Rch
GND
Lch
1u50
C12
+
15
24
470
R16
430K
R24 16K
R22 18K
C18
0.012
10K
VR2
R26 R30
150
C24
0.1
0.33u50
C16
+
18K
R15
0.1
C14
10K
VR1
R21 18K
R23 16K
0.012
C17
R25 430K 150
R29
0.1
C23
R12
10K
88
87
86
C13
0.1
0.33u50
C15
+
22u6.3
C10
+
R14
68K2200P
C11
2.2K
R13
0.47u50
C9
+
0.01
C8
0.47u50
C7
+
R11 220K
89
C4 0.039
84
0.01
C5
83
60
0.1
C33
100u10
+
C3
R885 2.2K
R886 2.2K
1K
1K
4.7K
22K
R918
R893
R894
R890
81
82
83
R887
R892
R891
92
96
93
94
95
13
12
11
10
9
8
7
6
5
4
3
2
1
CD2
N.C
VCC2
VCC1
N.C
IN2
GND
IN1
N.C
VR
N.C
CD1
N.C
14
15
16
17
18
19
20
21
22
23
24
25
N.C
OUT2
N.C
N.C
N.C
GND
FIN
GND
N.C
N.C
N.C
OUT1
N.C
24
15
C30 0.22C28 0.22
0.1
0.022
79
78
80
1/2W
4.7
1/2W
4.7
R37R38
1/2W 1/2W
C27
C31 0.01
C32 0.1
C29
100K
R34
1.5K
R33
R36 R35
4.74.7
8
7
6
5
4
3
2
1
FILOUT
ARI
GND
OSEL
MPX
VREF
RDDA
QUAL
9
10
11
12
13
14
15
16
FSEL
TM
EXTRES
VCC
OSCI
OSCO
T57
RDCK
1VDD 8
7
2
4
3
GND
6
5
82
81
12P
C128
12P
C126
10u10
+
C127
C130 10u10
+
C129 0.01 C125 270P
22
R128
1200P
C121
2.7K
R124
10K
R125
120P
C122
470P
C123
10K
R127
10K
R129
10u10
+
C124
6P
C120
82K
R123
X11
4.332MHz
R126
10K
C119 18P
R122 33K
470P
C115
82P
C116
15K
R121
C114
1000P R119
5.6K
10K
100K
R115
10K
R120
2.2K
R116
10
R117
8200P
C112
2200P
C113
10K
R114
58
92
C118 1200P
5.6K
R118
13
0.022
C117
R884 1K
R882 1K 78
79
80
R881 1K
470
R889 0.01
C813
R888 100K
R880 2.2K
R879 2.2K
R851 10K
R878 2.2K
75
74
73
R873 470
R875 470
R876 470
R877 470
R874 100K
R871 100K R872 47
67
R870 47
66
R868 100K R869 100
65
R866 100K R867 470
R865 470
R864 1KR863 100K
R862 27K
R861 120K
C812 1000P
58
59
R860 2.2K
R859 10K
C808 0.1
55
56 R858 1K
R857 1K
R850 1K
77
87
89
88
87
84
86
1
2
R803 4.7K R802 100K
R805 2.2K R804 2.2K
5
6
R806 1K
R807 1K 7
8
R808 2.2K
10
11
R810 2.2K
R809 1K
R815 1K R820 4.7K
14
15
R831 4.7KR816 100
17
R811 100KR812 100
R828 2.2K
2.2K 26
R835 100K
470
R822
0.015
C801
25
C800
0.015 R821
470
R834 100K
R823
R819 47K
R817 47K
W82
R826
2.2K
W81
12MHz
X81
X82
32.768KHz
R838
680K
C806 22P
C807 22P
R839 1K
R841 1K
R849 470R848 100K
R847 100R846 100K
48
71
68
69
70
63
62
R845 1K
R842 2.2K
45 R844 100K
C814
0.1
C815 0.1
30
29
21
31
R830 100K
R829 470
R837 1K
R836 1K
R833 1K
35
36
34
8
7
6
5
VCC
TEST
SCL
SDA
1
2
3
4
A0
A1
A2
GND
1K
R895 22K
R896 22K
R898 4.7K
R897 1K
R900 1K
R899 1K
R910 1K
R913 1K
R911 1K
R914 10K
R912 10K
97
98
C803 0.1
100
3.3u50
C903
+
1/2W
1.2K
1.2K
R903
0.1
C902
0.068
C901
22K
R902
1K 1/2W
R901
47K
R855
R856
4.7K
4
98
97
3
12
3
R904
1/2W
4.7uH
L17
9
98
97
47
R10
33
R818 100K
R832 47
R801 1K
R800
1K
10K
22K
33u10
+
C21
820P
C20
47K
R28
47K
R32
820P
C26
47K
R27
820P
C19
47K
R31
820P
C25
33u10
+
C22
(S)
49
46
47
44
76
100K
R883
60
W11
Q101
Q102
A11
D101
FM 8V
AM 8V
Q104
Q107
Q103
CN2
CN1
Q4
Q3
D3
D4
Q9
Q8
Q7
Q6
D2
Q5
D103
Q108
Q109
Q110
Q802
Q803
Q902
D901
Q903
P-ANT
Q94
Q901
D902
-ROM
EEP
IC1 : HA12216F
IC2 : BA6219BFP-Y
IC12 : NJM4565M-TE2
IC13 : TDA7479D
IC21 : BA3129F
IC22 : TDA7400D
IC31,32 : NJM2060M
IC41 : AN7550NZ
IC71 : M5237ML
IC72 : NJM4580MD
IC81 : UPD784216GF526
IC82 : PST9130NR
IC83 : TC74HC02AF
IC84 : BR24C01AF
Q1,7,94 : 2SB1443
Q2,5,201,610,803,903
: DTC114EK
Q3,9,203,609 : DTC144EK
Q4 : DTA144EK
Q6,802 : DTA114EK
Q8,108,604,608,702,
707,709,904 : 2SC2412K(S)
Q101,103 : 2SB1188(Q,R)
Q102,104,107,601 : DTC124EK
Q109 : DTC114TK
Q110,602,607,703,705,
902 : DTA124EK
Q202,708,901 : 2SA1037K
Q204,205 : DTC343TK
Q603 : 2SB1184
Q605,606,701,704,706
: 2SB1565(E,F)
D1,702,709,712 : AM01Z
D2 : MA4220-L
D3 : MA4075-L
D4 : MA4110-L
D101 : SA-C2012-101TB
D103,205 : DAN202K
D201-204 : RD6.8MW
D206-208 : DAP202K
D501-504 : MA3068WA
D601 : MA4130-M
D602 : DA204K
D604 : MA4110(N)-M
D701,705,902 : 1SR154-400
D703 : MA4082(N)-L
D706 : HZM4.7N(B2)
D707 : RM10ZLF
D708,710 : HZC6C3L
D713,903 : HZS7A3L
D802,804,901 : 1SS133
GND LINE
SIGNAL LINE
FRONT-END
2/2
X25-
CN1
IC81
IC1
IC2
IC13
IC12
IC84
A
22K
22K
22K
22K
22K
22K
47K
47K
47K
47K
10K
10K
10K
10K
47K
47K
22K
22K
10K
10K
22k
22k
10K
10K
10K
10K
10K
0/5.0V
12.4V
12.4V
0/5.0V
0V
0/5.0V
7.5V
0V
0V
7.5V
0/9.3V
0/9.3V
0/5.0V
0/5.0V
0/5.0V
0/5.0V
0/5.0V
0/2.0/8.0V
0/5.0V
0/5.0V
5.0V
0/5.0V
0/5.0V
0V
5V
0V
5V
0/5.0V
5.0V
5V
0V
0V
0V
0V
0/5.0V
0/5.0V
0/5.0V
0/4.0V
0/5.0V
0/5.0V
0/5.0V
0/5.0V
0/5.0V
0/5.0V
0/5.0V
0/5.0V
5.0V
12MHz
12MHz
0V
32.788kHz
32.788kHz
0/5.0V
0/5.0V
5.0V
0/5.0V
0/5.0V
0V
5V
0V
5V
5V
0V
5.0V
5.0V
0/5.0V
0.5/1.5V
0V
5V
0V
0/5.0V
0-4.0V
0V
5V
0V
0V
5.0V
5.0V
0V
5V 0V
5V
0V
5V 0V
5V
0V
5.0V
5.0V
0/5.0V
0/5.0V
0/5.0V
5.0V
0V
5V
0.7/5.0V
0/5.0V
0/5.0V
0/4.5V
0/5.0V
0/5.0V
0/5.0V
0V
2.0V
5.0V
0V
5V
0/5.0V
0V
4.0V
4.0V
4.0V
4.0V
0V 4.0V
4.0V
8.0V
0V
5V
2.4V
5.0V
2.4V
0V
0V
0V
0V
5.0V
4.332MHz
0V
5V
3.7V
3.7V
4.0V
0V
0.3V
4.0V
2.4V
0V
0/4.0V
0/4.1V
0/4.4V
0/4.1V
8.0V
0/4.7V
3.7V
4.0V
4.0V
4.0V
3.7V
3.7V
4.0V
4.0V
0V
2.4V
4.0V
4.0V
4.0V
3.7V
0V
0V
4.0V
4.0V
0V
4.0V
4.0V
0V
0V 5V
0V0V
0V
0V
0V
5V
0/7.5V
B LINE
STU VWXY AAZ
1
2
3
4
5
6
7
2/2
2SB1443
CE
B
2SA1037K
B
C
E
DTC124EUA
IN
GND
OUT
NJM4565M-TE2
NJM4565MD
DAN202K
DAN202U
2SB1565
BCE
DTA114EK
DTA114YK
DTA124EK
DTA114EK
DTA114EK
DTC114EK
DTC114TK
DTC124EK
DTC343TK
2SA1362
2SA1576A
2SC2412K
B
C
E
2SB1188
BCE
2SB1184
CE
B
CAUTION:For continued safety, replace safety critical components only
with manufacturer’s recommended parts (refer to, parts list). Indicates
safety critical components. To reduce the risk of electric shock, leakage-
current or resistance measurements shall be carried out (exposed parts
are acceptably insulated from the supply circuit) before the appliance is
returned to the customer.
DC voltages are as measured with a high impedance voltmeter. Values may
vary slightly due to variations between individual instruments or/and units.
GX-608EF2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
BUSY
NC
NC
NC
NC
NC
NC
NC
VSS
NC
NC
KR2
KR3
KR4
NC
NC
NC
NC
KS0
KS1
KS2
KS3
KS4
VSS
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
AVSS
XT1
XT2
IC
X1
X2
VDD
SC CON
KR0
KR1
MC REQ
RESET
SC REQ
NC
MC CLK
SC DATA
MC DATA
VFD BLK
VFD LAT
VFD CLK
VFD DATA
VFD ON
AVREF
AVDD
REF CONT
NC
NC
NC
NC
NC
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
LAMP-10V
LAMP-GND
FDC+
FL +B
FDC-
FL-GND
D-GND
D-GND
RESET
BU 5V
SC-REQ
SC-DATA
MC-DATA
SC-CON
SC-BUSY
MC-REQ
RST SW
TDF
DSI
MC-CLK
KS0
KR0
KR1
KR2
KR3
KR4
KS2
KS4
KS1
KS3
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
F1(-)
F1(-)
F1(-)
(DRY)
VDD2
VSS
VSS
CLK
BLK
LAT
NC(SO)
VDD1
(LOG)
DATA
F2(+)
F2(+)
F2(+)
KS0
R22 1K
R23 1K KS1
R24 1K KS2
R25 1K KS3
R26 1K KS4
KR2
KR3
KR4
R10
100K
100K
R8
100K
R7
470
R34
8.38MHz
X1
1K 1K
R18
R19
1K
R20
1K
R16
100K
R12
R17
R11
100K 1K
R44
47K R33
470
R35
47047K
R38
470
R28
R40
100K
R29
470
34
35
36
39
61
60
59
58
R31
470
R30
470
R32
470
R37
47K
47K
R39
R2 1K
R3
R4 1K
60
59
C1
58 R5 1K
61
C3
0.22
22
R1
R6 1K
1K
R9
2.2K
0.22
16
18
17
17
16
18
39
36
34
PL2 PL1
PL3PL4
PL6 PL5
PL8 PL7
C6 1
L1
4.7uH
64
63
62
62
64
63
2.2K
R43
680
R36
R41
82K
R27
1K
35
KR0
KR1
SC
(BOTTOM VIEW)
CN1
S1
POWER
a
(1) (2)
(11)
(3)~(10)
b
c
d
e
f
gh
a
a
b
b
li
njm
k
c
cd
d
e
e
f
f
g
gh
h
klb
c
e
fkl
m
n
D6 BAND
S2
VOL+
S3
4
S4 S5
T.ID7
S6
CD 5VOL-
S9 S10S8S7
DISP TAPE 61 MUTE
S11 S12 S13 S14 S15
NEWSD8 CHR SCN2 TONE
S16 S17 S18 S19 S20
CS EJ CD EJ 3
S21 S22 S23
ED1(CN1927G)
Q1
D2D1
VFD
D5 D9
S24
RESET
TDF S25
D3
D4
Q4Q3
Q2
IC1 : UPD78011FGC599
Q1,4 : DTC114EK
Q2 : DTA114YK
Q3 : DTC114YK
D1,2 : 1SR154-400
D3 : B30-1417-05
D4 : DAN202K
D5,9 : MA3056-M
D6-8 : DA227
GND LINE
1/2
X14-
CN81
R
IC1
(X25-8502-70)
A
10K
10K
10K
10K
47K
10K
47K
10K
(1) (2)
(3) (4) (5) (6) (7) (8) (9) (10) (11)
G1 G2
BNR
LOUD
TI
ST D.REP RDM TP TA SCN NEWS
ch
CHR
CD
TAPE
BAND
B LINE
0/5.0V 0V
0V
4.2V
0/
5V
0V
0V
0V
5.0V
0V
0/5.0V
5V
0V
5V
0V
0V
5V 0V
5V
0V
5V
0V
5V
5.0V
0V
5V
0V
5V
0V
5.0/0V
5V
0V
4.2V
0V
0/
0/5.0V
5.0V
0.8V
3.4V
S1 S2 S3
col2col1 col3
dp S6
S5 S4
S7
TA78L05F
DAP202K
DA204K
DA227
TC74HC02AF
BA3129F
NJM2060M
BR24C01AF
PST9130NR
M5237ML
AN8806SB
TDA7479D
CAUTION:For continued safety, replace safety critical
components only with manufacturer’s recommended parts
(refer to, parts list). Indicates safety critical components.
To reduce the risk of electric shock, leakage-current or
resistance measurements shall be carried out (exposed parts
are acceptably insulated from the supply circuit) before the
appliance is returned to the customer.
DC voltages are as measured with a high impedance voltmeter.
Values may vary slightly due to variations between individual
instruments or/and units.
AB AC AD AE AF AG AH AJAI
1
2
3
4
5
6
7
CD PLAYER UNIT GX-608EF2
(X32-4600-00)
CD PLAYER UNIT
Q5 Q2
D2
Q4
CN1
D1
Q1
IC6
(2/2)
(1/2)
IC6
Q3 LOADING &
SLED MOTOR
CN2
D1,2
Q2,5
Q1,3,4
IC6
IC5
IC4
IC2
IC1
: DAN202U
: DTC124EUA
: 2SA1362(Y)
: NJM4565MD
: TA78L05F
: BA5917AFP
: MN662770KA7
: AN8806SB
: 2SA1576A
D3 : DA204K
Q6
RF AMP
APC
A. 8V SW
D. 5V SW
SPINDLE
MOTOR
DM2
DM1
MAIN
CN1
To
UNIT
Q6
M
M
GND LINE
SIGNAL LINE
S2
S1
S3 DOWN &
SWITCH
LIMIT
SIGNAL
PROCESSOR
MOTOR ON
TE
MOTOR
5V AVR
L.P.F.
P ON
LEVEL SW
DRIVER
S2: 12C
DISC DET.
S1: LOAD DET.
OP. OUT
OP. IN+ 13
14
15
GND
SLED+
10
11
12
SLED-
VCC
SP. IN SL. IN
FIN
4
7
VREF
FIN
GND 9
VCC MUTE
8
FC. IN
FCS+
6
FCS- TR. IN
5
GND
3
TRK-
TRK+ 2
1
17
19
18
20
21
23
22
29
26
24
25
27
28
30
OP. IN-
16
R77
39K
C41
2.2
LOAD
SLED+
SLED-
EJECT
6.2K
10K
R471K
R46
1
2
28
29
PD1(A+C)
PD2(B+D)
E
PD
VR
GND
LD
NC
VCC
VC
F
AL
TRK-
TRK+
FCS-
FCS+
R1 24K
R2 18K
R5
91
Iop2Iop1
L1 10uH
10
R9
4.7
R8
VDET
C.SBRT
16
OFTR
13
14
15
BDO
TEBPF C.SBDO
CROSS
10
11
12
C.ENV
C.EA
TE-
TEOUT
ARF
FEOUT
4
7
FBAL
RFIN
C.AGC 9
FE- RFOUT
8
TBAL
PDFR VCC
RF- 6
PDER
LDP
5
PDF
LDON 3
PDE
PD
LD 2
PDBD
PDAC 1
35
19
36
20
23
22
29
26
24
25
27
28
30
31
32
17
NRFDET
GND 18
VREF
ENV
34
33
1.5M
R4
150K
R3
R7
1.5M
150K
R6
C1
3.9K
R202 R17
39K
R18
3.9K
R20
R21
C2
C18
R19
33K
390P
C17
4700P
C13
0.027
100P
R16
22K
0.047
C15
R15
820K
4700P
C14
TE
C20 0.1
C19 0.1
C8 1
100P
4700P
6800P
2200P
5.6K
R12
9.1K
R10
22P
C5
C6
2P 68K
R13
0.1
C7
820K
R14
9.1K
R11
C3
10u16
+
C9
C10
C11
C12
ARF
RF
470P
C61 470P
C62
20K
20K
68P
C63
R105
20K
R103
20K
68P
C64
330
R107
2200P
C65
R108
330
2200P
C66
20K
R106
6
5
7
4
3
2
1
8
R91
3.3K
C55 1
R93
5.6K
10u16
+
C51 3.3
5.1K
10K
R45
GND
IN OUT
C56 1
5.6K
R94 3.3K
R92
D. OUT
SW2
SW1
CLK
DATA
MECHA
NC
BU+5V
D. GND
MUTE R
MUTE L
MRST
MSTOP
A. +8V
Lch
A. GND
Rch
LO/EJ
MOTOR
S. 7.5V
S. GND
SW3
FE
TRK+
FCS+
TRK-
FCS-
R76
R83
680
9.1K
R71
0.1
C102
R82
6.8K
240K
R204 240K
R203
C101
180P
1.2K
R72
39K
R73
C43
0.01
0.018
C45
2
1
28
29
10u6.3
C4
+
SPDL+
SPDL-
2K
2.4K
33K
0.1
C44
C32
0.01
C16
22K
22K
22K
22K
20K
R44
SPDL+
SPDL-
R78
15K
21 OFF
LD
10
11
12
15
19
4
220K
100K
36
35
34
29
33
32
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
C53
R104
1
4.7K
R51
1M
R40
R39
2.2M
470P
C40
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
DVSS2
SMCK
STLD
STOUT
TRCRS
FLAG
IPFLAG
FCLK
CLDCK
PCK or DSLB
EFM or CK384
AVSS2
AVDD2
TOFS
FOD
TRD
KICK
ECS
ECM
PC
TVD
TRV
VCOF2
VCOF
PLLF2
PLLF
IREF
DSLF
DRF
ARF
VREF
RFENV
NC
NC
NC
TE
NC
NC
FE
TBAL
FBAL
AVDD3
AVSS3
NC
NC
LDON
VDET
RFDET
OFT
BDO
NC
NC
NC
NC
TEST
ASEL
PON
SEARCH
VER/HOR
SW3
AMUTE L
AMUTE R
CD-R
RST
NC
MSTOP
NC
DATA
CLK
HOT
AVREF
OUT R
AVDD1
OUT L
AVSS1
CSEL
TEST1
TEST2
IOSEL
NRST
BCLK
LRCK
SRDATA
SUBC
SBCK
DQSY
DEMPH
TX
PSEL
MSEL
SSEL
DVDD1
X1
X2
DVSS
XSUB1
XSUB2
DVDD2
NC
NC
X1
16.9344MHz
220
R205
0.1
C22
10u16
C21
+
4.7K
R42
86
85
89
87
4.7K
R49
C46
0.047
TEST
0.1
C35
C54
0.1
94
93
91
5
4
3
2
1
0.1
C33
150
R36 1
C26
0.022
C24
68K
R34
100K
R35
100K
R32
470
R37
R38
220K
0.012
C25
C28
1
29
30
32
33
34
35
36
R102
R101
CP3
100
100
CP2
CP1
100
87
89
91
86
93
94
1K
R50
L2
C31
0.01
85
89 R52
100K
R54
100K
2
3
1
20
33K
10K 30
C29
0.1
1K
R31
10
19
20
15
12
11
3.3
C34
1000P
C23
5
R80
R79
R81
R75
R74
IC4
IC1
IC5
(T25-0209-05)
DPU1
PICKUP
OPTICAL
(X92- )
(X92- )
(X92- )
IC2
D3
B LINE
4.0V2.5V8.0V
2.5V
4.0V
2.5V 2.5V
FE
5Vpp
0V or 5.0V
2.4V
3.4V
2.5V
1.2Vpp
2.5VTE
2.4V
0.8Vpp
2.0V
4.0V 5.0V
4.0V
4.0V
3.4V
3.5V
3.0V 3.6V
2.5V
5.0V
0.1V0V5.0V
3.5V
0V or 5.0V
0V or 5.0V
0V or 5.0V
0V or 5.0V
5.0V
0V
5.0V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
1.0V
1.0V
0V
1.0V
2.5V
0V
5V
0V
0V
5.0V
0V
0V or 5.0V
0V
0V
5V
0V
5.0V
0V
0V or 5.0V
5.0V
5.0V
5.0V
5.0V 5.0V
0V
5V
0V
0V
2.5V
5.0V
2.5V
5.0V
2.5V 0V
2.5V
2.5V 8.0V
2.5V
5.0V
0V
8.0V
4.0V
S3
A
B
C
D
E
F
G
H
J
M1.7x2.5
2x3.5
M1.7x4
M2x2
2x6
WASHER 1.2
WASHER 1.6
WASHER 1.6
M2x2
: N09-4249-05
: N09-4172-05
: N09-4202-05
: N38-2020-46
: N09-4294-05
: N19-2023-04
: N19-2058-04
: N19-2093-04
: N39-2020-46
DJ
G
B
B
HE
E
H
E
E
E
E
H
Ex2
E
F
E
B
F
GB
Cx2
B
B
B
Ax2
S1 S2
418
414
454
402
413
483
451
446
450
446451440
415
405A
472
470
452
475 452
873
405
885
453
437
438
439
465 480
417
466
412
471
418
411
454
454
479
477
419
443
460
460
420
DPU1
444
441
403
409
410
447x
2
435
458
467 478
DM2
DM1
424
455
434
432
431
427 429
449
436
430
421
463
464
482 422
461
461
476
433
407 401
462
408
406 460
460
469
445
416
CD
1
2
3
66
4
7
92
65
2
60
42
86
87x2 114
119
104
89
90
93
113 137
3
100
x2
48
x2
103
x2
101
CM1
16
30
55
101
138
139
139
877
878
102
107 104
30
55
39
53
107
52
801
85
85
19
18
58
106
70
49
23
37
17
104
118
112
12
12
117
115 HD1
24
S2
S4
PH2
58
38
54
102
102
101
823
101
40
50
96
96
96
96
22
106
102 102
38
85
x2
102
126 611
64
PH3
830
5
21
34
35
57
10
28
111
102
101
101
101
101
33
89
32
25
113
61
36
31
90
x2
88
x2
CM2
S1
S3
PH1
AB
1
2
3
2625
GX-608EF2 GX-608EF2
EXPLODED VIEW (CD MECHANISM)EXPLODED VIEW (CASSETTE MECHANISM)
Parts with exploded numbers larger than 700 are not suppied.
Parts with exploded numbers larger than 700 are not suppied.
S3
A
B
C
D
E
F
G
H
J
M1.7x2.5
2x3.5
M1.7x4
M2x2
2x6
WASHER 1.2
WASHER 1.6
WASHER 1.6
M2x2
: N09-4249-05
: N09-4172-05
: N09-4202-05
: N38-2020-46
: N09-4294-05
: N19-2023-04
: N19-2058-04
: N19-2093-04
: N39-2020-46
DJ
G
B
B
HE
E
H
E
E
E
E
H
Ex2
E
F
E
B
F
GB
Cx2
B
B
B
Ax2
S1 S2
418
414
454
402
413
483
451
446
450
446451440
415
405A
472
470
452
475 452
873
405
885
453
437
438
439
465 480
417
466
412
471
418
411
454
454
479
477
419
443
460
460
420
DPU1
444
441
403
409
410
447x
2
435
458
467 478
DM2
DM1
424
455
434
432
431
427 429
449
436
430
421
463
464
482 422
461
461
476
433
407 401
462
408
406 460
460
469
445
416
CD
1
2
3
66
4
7
92
65
2
60
42
86
87x2 114
119
104
89
90
93
113 137
3
100
x2
48
x2
103
x2
101
CM1
16
30
55
101
138
139
139
877
878
102
107 104
30
55
39
53
107
52
801
85
85
19
18
58
106
70
49
23
37
17
104
118
112
12
12
117
115 HD1
24
S2
S4
PH2
58
38
54
102
102
101
823
101
40
50
96
96
96
96
22
106
102 102
38
85
x2
102
126 611
64
PH3
830
5
21
34
35
57
10
28
111
102
101
101
101
101
33
89
32
25
113
61
36
31
90
x2
88
x2
CM2
S1
S3
PH1
AB
1
2
3
2625
GX-608EF2 GX-608EF2
EXPLODED VIEW (CD MECHANISM)EXPLODED VIEW (CASSETTE MECHANISM)
Parts with exploded numbers larger than 700 are not suppied.
Parts with exploded numbers larger than 700 are not suppied.
ED1
PA1
M2.6x3.5 (BLK)
M3x8 (BLK)
2x6 (BLK)
3x6
3x8
2x5 (BLK)
2x5
3x8 (BLK)
: N09-1492-05
: N35-3008-45
: N80-2006-45
: N83-3006-46
: N89-3008-46
: N80-2005-45
: N80-2005-46
: N83-3008-45
A
B
C
D
E
F
G
H
(X14)
(X14)
(X14)
(X14)
(X14)
(X14)
IC41
W11
A61
X14-
6212-70
A11
F1
F2
(X14)
W2
FC1
DME1
205
CME1
236
221
241
244
240
209
247 203
228
227 243
214
215
242
211
245
246 249
248
213
CL1
226
234
220
E
x2
B
x2
Bx2
Hx2
D
x2
D
D
Dx2
E
E
B
E
729
729
731
719
707
708
712
704
735
752
723
701
X25-8502-70
718
722
751
730
756
755
702 BE
D
D
E
E
E
E
C
C
x2
C
C
x4
C
A
A
D
C
C
G
G
C
C
F
C
EF
1
2
3
28
GX-608EF2
GX-608EF2 PARTS LIST
Ref.No. Parts No. Description
A
d
d
A
d
d
N
e
w
Dest
inati
on
Ref.No. Parts No. Description
A
d
d
A
d
d
N
e
w
Dest
inati
on
∗ New Parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohane Parts No. werden nicht geliefert.
E: Europe K: North America M: Other Areas W: Without Europe indicates safety critical components.
GX-608EF2
EXPLODED VIEW (UNIT)
27
Parts with exploded numbers larger than 700 are not suppied.
203 3E ∗A22-2807-13 SUB PANEL ASSY
205 1E ∗A52-0763-02 TOP PLATE
CL1 3F ∗A53-1679-03 CASSETTE LID
PA1 3E ∗A64-2014-22 PANEL ASSY
209 3E ∗B10-3165-13 FRONT GLASS
211 3F ∗B19-2025-12 LIGHTING BOARD
213 3E ∗B19-2027-04 LIGHTING BOARD (CD)
214 3F ∗B19-2028-14 LIGHTING BOARD (CST)
215 3F ∗D10-4479-14 LEVER
CME1 1F D40-1079-05 CASSETTE MECHANISM ASSY
FC1 2E ∗E39-0307-05 FLAT CABLE (CD)
220 1F F12-0691-04 SHIELDING TUBE
221 2E ∗F19-1356-04 BLIND PLATE
226 2E G01-2371-04 TORSION COIL SPRING
227 3F ∗G01-3009-04 TORSION COIL SPRING
228 3F ∗G01-3010-04 EXTENSION SPRING
234 2F J19-4695-05 HOLDER
236 2E ∗J90-0972-23 GUIDE
240 2E ∗K24-3564-04 KNOB (POWER)
241 3E ∗K24-3565-14 KNOB (VOL)
242 3F ∗K24-3566-04 KNOB (CD-EJ)
243 3F ∗K24-3567-04 KNOB (CST-EJ)
244 2E ∗K25-1124-03 KNOB (MUTE)
245 3F ∗K25-1125-03 KNOB (BAND)
246 3F ∗K25-1126-12 KNOB (PRI)
247 3E ∗K25-1128-03 KNOB (TI)
248 3F ∗K27-3557-03 KNOB (LEVER)
249 3F ∗K29-7012-04 KNOB
A 3E N09-1492-05 MACHINE SCREW (2.6X3.5)
B 2F N35-3008-45
BINDING HEAD MACHINE SCRE(M3X8)
C 3F N80-2006-45 PAN HEAD TAPTITE SCREW(2X6)
D 1E N83-3006-46 PAN HEAD TAPTITE SCREW(3X6)
E 2F N89-3008-46 BINDING HEAD TAPTITE SCREW(3X8)
F 3E N80-2005-45 PAN HEAD TAPTITE SCREW(2X5)
G 3F N80-2005-46 PAN HEAD TAPTITE SCREW(2X5)
DME1 1E X92-3590-01 CD MECHANISM ASSY(DXM-1331)
X14-621
C1 ,2 CK73GB1H103K CHIP C 0.010UF K
C3 CE04CW1A101M ELECTRO 100UF 10WV
C4 ∗CK73GB1E393K CHIP C 0.039UF K
C5 CK73GB1H103K CHIP C 0.010UF K
C7 C90-2606-05 ELECTRO 0.47UF 50WV
C8 CK73GB1H103K CHIP C 0.010UF K
C9 C90-2606-05 ELECTRO 0.47UF 50WV
C10 CE04CW0J220M ELECTRO 22UF 6.3WV
C11 CK73GB1H222K CHIP C 2200PF K
C12 C90-2608-05 ELECTRO 1.0UF 50WV
C13 ,14 CK73FB1H104K CHIP C 0.10UF K
C15 ,16 C90-2605-05 ELECTRO 0.33UF 50WV
C17 ,18 CK73GB1H123K CHIP C 0.012UF K
C19 ,20 CK73GB1H821K CHIP C 820PF K
C21 ,22 CE04CW1A330M ELECTRO 33UF 10WV
C23 ,24 CK73FB1H104K CHIP C 0.10UF K
C25 ,26 CK73GB1H821K CHIP C 820PF K
C27 CK73FB1H104K CHIP C 0.10UF K
C28 CK73FB1C224K CHIP C 0.22UF K
C29 CK73GB1H223K CHIP C 0.022UF K
C30 CK73FB1C224K CHIP C 0.22UF K
C31 CK73GB1H103K CHIP C 0.010UF K
C32 ,33 CK73FB1H104K CHIP C 0.10UF K
C101,102 CK73GB1H103K CHIP C 0.010UF K
C103 CK73FB1C105K CHIP C 1.0UF K
C104,108 CK73GB1H103K CHIP C 0.010UF K
C109 CC73GCH1H471J CHIP C 470PF J
C111 CK73GB1H103K CHIP C 0.010UF K
C112 CK73GB1H822K CHIP C 8200PF K
C113 CK73GB1H222K CHIP C 2200PF K
C114 CK73GB1H102K CHIP C 1000PF K
C115 CC73GCH1H471J CHIP C 470PF J
C116 CC73GCH1H820J CHIP C 82PF J
C117 CK73GB1H223K CHIP C 0.022UF K
C118 CK73GB1H122K CHIP C 1200PF K
C119 CC73GCH1H180J CHIP C 18PF J
C120 CC73GCH1H060D CHIP C 6.0PF D
C121 CK73GB1H122K CHIP C 1200PF K
C122 CC73GCH1H121J CHIP C 120PF J
C123 CC73GCH1H471J CHIP C 470PF J
C124 C90-2594-05 ELECTRO 10UF 10WV
C125 CC73GCH1H271J CHIP C 270PF J
C126 CC73GCH1H120J CHIP C 12PF J
C127 C90-2594-05 ELECTRO 10UF 10WV
C128 CC73GCH1H120J CHIP C 12PF J
C129 CK73GB1H103K CHIP C 0.010UF K
C130 C90-2594-05 ELECTRO 10UF 10WV
C131,132 C90-2528-05 ELECTRO 10UF 10WV
C133 C90-2594-05 ELECTRO 10UF 10WV
C134 CC73GCH1H151J CHIP C 150PF J
C201,202 C90-2807-05 NP-ELEC 0.47UF 50WV
C203,204 C90-2597-05 ELECTRO 10UF 16WV
C205,206 C90-2535-05 ELECTRO 4.7UF 16WV
C207-209 C90-2534-05 ELECTRO 3.3UF 16WV
C210 C90-2534-05 ELECTRO 3.3UF 16WV
C211,212 C90-2807-05 NP-ELEC 0.47UF 50WV
C213 CE04CW1C470M ELECTRO 47UF 16WV
C214 C90-2535-05 ELECTRO 4.7UF 16WV
C215 C90-2860-05 ELECTRO 1.0UF 50WV
C216,217 CK73FB1H104K CHIP C 0.10UF K
C218 CE04CW1C470M ELECTRO 47UF 16WV
C219 CK73FB1C474K CHIP C 0.47UF K
C220 CK73GB1C823K CHIP C 0.082UF K
C221 CK73FB1H104K CHIP C 0.10UF K
C222 CC73GCH1H121J CHIP C 120PF J
C223 CK73GB1E333K CHIP C 0.033UF K
C229 CK73GB1H153K CHIP C 0.015UF K
SYNTHESIZER UNIT (X14-6212-70)
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
/