Kenmore 30'' Under-Cabinet Range Hood - Black ENERGY STAR Owner's manual

Use & Care / Installation Manual

Manual de Uso y Cuidado / Instalación

English / Español

P/N 99044817B

Sears Brands Management Corporation,

Homan Estates, IL 60179 USA

www.kenmore.com

www.sears.com

Models/Modelos 233.5580*

Kenmore

Range Hood

Campana de cocina

* = color number, número de color

WARNING

TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR

INJURY TO PERSONS, OBSERVE THE FOLLOWING:

1. Usethisunitonlyinthemannerintendedbythe

manufacturer.Ifyouhavequestions,contactthe

manufacturerattheaddresslistedinthewarranty.

2. Beforeservicingorcleaningunit,switchpowero

atservicepanelandlocktheservicedisconnect-

ingmeanstopreventpowerfrombeingswitched

onaccidentally.Whentheservicedisconnecting

meanscannotbelocked,securelyfastenapromi-

nentwarningdevice,suchasatag,totheservice

panel.

3. Installation work and electrical wiring must be

donebyaqualiedperson(s)inaccordancewith

all applicable codes and standards, including

re-ratedcodesandstandards.

4. Sucientairisneededforpropercombustionand

exhaustingofgasesthroughtheue(chimney)of

fuelburningequipmenttopreventbackdrafting.

Follow the heating equipment manufacturer’s

guidelineandsafetystandardssuchasthosepub-

lishedbytheNationalFireProtectionAssociation

(NFPA),andtheAmericanSocietyforHeating,

Refrigeration and Air Conditioning Engineers

(ASHRAE),andthelocalcodeauthorities.

5. Whencuttingordrillingintowallorceiling,do

notdamageelectricalwiringandotherhidden

utilities.

6. Toreducetheriskofreorelectricshock,donot

use this range hood with an additional speed

controldevice.

7. Ductedfansmustalwaysbeventedtotheout-

doors.

8. Toreducetheriskofre,useonlymetalductwork.

9. Usewithapprovedcord-connectionkitonly.

10.Thisunitmustbegrounded.

TO REDUCE THE RISK OF A RANGE TOP GREASE FIRE:

1. Neverleavesurfaceunitsunattendedathighset-

tings.Boiloverscausesmokingandgreasyspill-

oversthatmayignite.Heatoilsslowlyonlowor

mediumsettings.

2. AlwaysturnhoodONwhencookingathighheat

orwhencookingamingfoods.

3. Cleanventilatingfansfrequently.Greaseshould

notbeallowedtoaccumulateonfanorlter.

4.Useproperpansize.Alwaysusecookwareap-

propriateforthesizeofthesurfaceelement.

WARNING

TO REDUCE THE RISK OF INJURY TO PERSONS IN

THE EVENT OF A RANGE TOP GREASE FIRE, OBSERVE

THE FOLLOWING:*

1. SMOTHERFLAMESwithaclose-ttinglid,cookie

sheet,ormetaltray,thenturnotheburner.BE

CAREFULTOPREVENTBURNS.Iftheamesdo

notgoout immediately, EVACUATEANDCALL

THEFIREDEPARTMENT.

2. NEVERPICKUPAFLAMINGPAN-Youmaybe

burned.

3. DONOTUSEWATER,includingwetdishclothsor

towels-aviolentsteamexplosionwillresult.

4.UseanextinguisherONLYif:

 A. YouknowyouhaveaClassABCextinguisher

andyoualreadyknowhowtooperateit.

 B. The re is small and contained in the area

whereitstarted.

 C. Theredepartmentisbeingcalled.

 D. Youcanghttherewith

yourbacktoanexit.

* Basedon“KitchenFiresafetyTips”publishedbyNFPA.

CAUTION

1. Forindooruseonly.

2. For general ventilatinguse only. Do not use to

exhaust hazardous or explosive materials and

vapors.

3. Toavoidmotorbearingdamageandnoisyand/

or unbalanced impellers, keep drywall spray,

constructiondust,etc.opowerunit.

4.Forbestcaptureofcookingimpurities,yourrange

hoodshouldbemountedsothatthetopofthe

hoodis24-30”abovethecookingsurface.

5. Useonlywithrangehoodcord-connectionkitsthat

havebeeninvestigatedandfoundacceptablefor

usewiththismodelrangehood.

6. Please read specication label on product for

furtherinformationandrequirements.

TABLE OF CONTENTS

SECTION........................................................................PAGE

SafetyInstructions................................................................2

Warranty...............................................................................3

Operation..............................................................................3

Cleaning.................................................................................3

PartsIncludedWithHood.................................................. 4

PartsNotIncludedWithHood.......................................... 4

ToolsNeeded....................................................................... 4

NOTE

If hood is to be installed Non-Ducted:

• Purchase a set of (2) non-ducted lters from your

local distributor or retailer and attach them to the

aluminum mesh lters.

INTENDED FOR DOMESTIC COOKING ONLY

! !

READ AND SAVE THESE INSTRUCTIONS

SAFETY INSTRUCTIONS

SECTION ........................................................................PAGE

EquivalentDuctLengthChart.............................................5

PrepareTheHoodLocation................................................6

PrepareTheHood.............................................................7, 8

ConnectTheWiring.............................................................9

InstallTheHood..................................................................10

ServiceParts.........................................................................11

FAN

The3-positionrockerswitch(ontheleft)controlsthe

fan.Theleftpositionislowspeed,centerpositionis

o,andrightpositionishighspeed.

LIGHT

The3-positionrockerswitch(ontheright)controlsthe

lights.Theleftpositionislowlightintensity,center

positioniso,andrightpositionishighlightintensity.

OPERATION

Safety CleaningOperation Installation Service Parts

Whenthisapplianceis installed, operatedand

maintainedaccordingtoallsuppliedinstructions,

the following warranty coverage applies. To

arrangefor warranty service,call 1-800-4-MY-

HOME

(1-800-469-4663).

• For one year from the date of purchase,any

partofthisproductthatfailsduetoadefectin

materialorworkmanshipwillreceivefreerepair

orreplacementif repairproves impossible.The

lengthofthiscoveragedoesnotapplytothenish

ofanypaintedorbrightmetalpart.

• For thirty days date of purchase,anypaintedor

brightmetalpartofthisproductwillbereplaced

freeofchargeifitsnishisdefectiveinmaterial

orworkmanship.

Allwarrantycoverageisvoidifthisproductisever

usedforotherthanprivatehouseholdpurposes.

This warranty covers only defects in material and

workmanship, and will NOT pay for:

1. Consumable parts that can wear out from

normaluse,includingbutnotlimitedtolters,

belts,lightbulbs,andbags.

2. Aservicetechniciantoinstructtheuserincor-

rectproductinstallation,operationormainte-

nance.

3. Aservicetechniciantocleanormaintainthis

product.

4.Damagetoorfailureofthisproductifitisnot

installed,operatedormaintainedaccordingto

theallinstructionssuppliedwiththeproduct.

5. Damagetoorfailureofthisproductresulting

fromaccident,abuse,misuseoruseforother

thanitsintendedpurpose.

6.

Damagetoorfailureofthisproductcaused

bytheuseofdetergents,cleaners,chemicals

orutensilsotherthanthoserecommendedin

allinstructionssuppliedwiththeproduct.

7. Damagetoorfailureofpartsorsystemsresult-

ingfromunauthorizedmodicationsmadeto

thisproduct.

Disclaimer of implied warranties; limitation of

remedies

Customer’ssoleandexclusiveremedyunderthis

limitedwarrantyshallbeproductrepairaspro-

videdherein.Impliedwarranties,includingwarran-

tiesofmerchantabilityortnessforaparticular

purpose,arelimitedtooneyearortheshortest

periodallowedbylaw.Searsshallnotbeliable

forincidental orconsequentialdamages.Some

statesandprovincesdonotallowtheexclusionor

limitationofincidentalorconsequentialdamages,

orlimitationonthedurationofimpliedwarranties

ofmerchantabilityortness,sotheseexclusions

orlimitationsmaynotapplytoyou.

Thiswarrantygivesyouspeciclegalrights,and

youmayalsohaveotherrightswhichvaryfrom

statetostate.

Sears Brands Management Corporation,

Homan Estates, IL 60179

KENMORE LIMITED WARRANTY

Warranty

LOW OFF HIGH NITE OFF HIGH

TOOLS NEEDED FOR HOOD INSTALLATION

Screwdriver

(Flat&Phillips)

Pencil

Tape

Measure

Drill

Sabre

Saw

Keyhole

Saw

-or-

1/4”

Nutdriver

DuctTape

Wire

Stripper

DuctingAccessories

(See “Equivalent Duct

LengthChart”onpage

5forDuctingAccessory

ModelNos.

“PartsNotIncluded

WithHood”available

bycallingSearsat

1-800-4-MY-HOME

PARTS NOT INCLUDED WITH HOOD*

OPTIONAL PARTS (purchase separately)

FluorescentLightBulb

(1perhood)

7-inchRoundDamper

(Forusewith7-inchRoundDuct)

SearsPartNo.59183

Splashplate

SearsPartNos.

58120 30”Black/Biscuit

58128 30”White/Almond

CordKit

(Allowshoodtobe

pluggedintoastandard

120VACwalloutlet)

SearsPartNo.50300

CLEANING

ALUMINUMMESHFILTERS

Cleanfrequentlyusinghotwaterandamilddetergent

orinyourdishwasher.Thealuminummeshltersshould

bewashedapproximatelyeverymonthdependingon

theamountofusage.Washmoreoftenifyourcooking

stylegeneratesgreatergrease-likefryingfoodsorwok

cooking.

PAINTEDHOODSURFACES

Wipingregularlywithmildsoap/detergentandwarm

watershould protect painted hood surfaces. Be cau-

tiousaboutusing“NewandImproved”cleaningagents.

Yourhoodisinstalledoverhotcookingequipment.Most

chemicalsfoundincleaningagentsreactwithheatto

loosenpaint.

STAINLESSSTEELHOODSURFACES

Stainlesssteelhoodsshouldbewashedregularlywitha

cleancloth,warmwaterandmildsoapordishdetergent.

Cleaninthedirectionofthepolishlines.Rinsewellwith

clearwaterandwipedryimmediately.Youmaywishto

applylightoilusedforfurniturepolishingtoemphasize

it’sbrightnish.

FANASSEMBLY

Fanbladecanbecleanedwithadampclothandmild

detergent.Usecarewhencleaningfanblade-itmustnot

becomebentormisaligned.DONOTALLOWWATER

TOENTERMOTOR.Makesureallsurfacesarecom-

pletelydrybeforere-installingltersandrestoringpower.

Motorispermanently lubricated.

Do

notoil or disas-

semblemotor.

WARNING: To reduce the risk of electric

shock,disconnectfrompowersupplybefore

cleaning.

PARTS INCLUDED WITH HOOD

7-inchRound

DuctAdapter

3¼”x10”

Damper/DuctConnector

AluminumGreaseFilter

(2perhood)

PartsBag

(4hoodmountingscrewsinside)

NightLightBulb

(1perhood)

EQUIVALENT DUCT LENGTH CHART

BroanModel401

StraightDuct

3¼-in.x10-in.x2-ft.long

Equivalentlength

2ft.

BroanModel406

StraightDuct

6-in.roundx2-ft.long

Equivalentlength

2ft.

BroanModel415

7-in.RoundElbow

Equivalentlength

8ft.

SearsModel59581

3¼-in.x10-in.to

6-in.RoundTransi-

tion

Equivalentlength

5.5ft.

BroanModel428

3¼-in.x10-in.

Right-angleElbow

Equivalentlength

8.5ft.

BroanModel429

3¼-in.x10-in.

Right-angleFlat

Elbow

Equivalentlength

24ft.

BroanModel430

3¼-in.x10-in.

Right-angle

Short

EaveElbow

Equivalentlength

15ft.

BroanModel

431

3¼-in.x10-in.

Right-angle

Long

EaveElbow

Equivalent

length

15ft.

SearsModel59691

6-in.Round

WallCap

Equivalentlength

34ft.

(6-ft.w/odamper)

SearsModel

59391

3¼-in.x

10-in.

WallCap

Equivalent

length

45ft.

(7-ft.w/o

damper)

Sears

Model59091

RoofCap

(accepts7-in.round

or3¼-in.x10-in.duct)

Equivalentlength

30ft.(7-ft.w/odamper)

WarrantySafety CleaningOperation Installation Service Parts

Kenmorerangehoodsaredesignedtoperformecientlywhenattachedtolongrunsofduct.Asapointof

reference,thishoodwillfunctionatapproximately80%ofitsratedairowwhen200equivalentfeetof7”

roundductworkisattached.Usethischarttocalculatetheequivalentductlengthofyoursystem.

BroanModel407

StraightDuct

7-in.roundx2-ft.long

Equivalentlength

2ft.

BroanModel419

6-in.RoundElbow

Equivalentlength

8ft.

BroanModel412H

3¼-in.x10-in.to

7-in.Round

Transition

Equivalentlength

5.5ft.

BroanModel647

7-in.Round

WallCap

Equivalentlength

34ft.

(6-ft.w/odamper)

Sears Model “Ducting Accessories” available by calling:

Sears at 1-800-4-MY-HOME

Broan Model “Ducting Accessories” available by calling:

1-800-558-1711.

1. Determinewhetherhoodwilldischargevertically

(3¼”x10”or7”Round),horizontally(3¼”x10”

only).

 Forverticalorhorizontaldischarge,runductwork

betweenthehoodlocationandaroofcaporwall

cap.

 Forbestresults,useaminimum numberoftransi-

tionsandelbows.

PREPARE THE HOOD LOCATION

3. Runhousewiringbetweenservicepanelandhood

location.

2. Usethesediagramsforproperplacementofduc-

tworkandelectricalcutoutincabinetorwall.

 Foranon-ductedinstallation,DONOTcutaduct

accesshole.

3¼”X10”

VERTICALDUCTING

7”ROUND

VERTICALDUCTING

3¼”X10”

HORIZONTALDUCTING

3. RemoveDamper/DuctConnectorfrominsidethe

hood.Setconnectoraside-withmountingscrews

andpartsbag.

4.RemoveWiringCoverfrominsidethehood.Set

coverandmountingscrewaside.

DAMPER/DUCT

CONNECTOR

WIRING

COVER

1. Remove7”RoundDuctPlatefromtopofhood.

Setductplateaside-withmountingscrews.

2. RemovetapeholdingFiltersinplace.Pulldown

onltertabsandliftltersout.Setltersaside.

7”ROUND

DUCTPLATE

PREPARE THE HOOD

WarrantySafety CleaningOperation Installation Service Parts

FILTERS

5. Removeeithertoporbackwiringknockoutand

installapprovedElectricalCableClamp.

ELECTRICAL

CABLE

CLAMP

6. RemoveappropriateDuctKnockout(s)fromtop

orbackofhood.

REAR

RECTANGULAR

DUCTKNOCKOUT

(REMOVEFOR3¼”X10”

HORIZONTALDISCHARGE)

TOPRECTANGULAR

DUCTKNOCKOUT

(REMOVEFOR3¼”X10”

VERTICAL&FOR7”

ROUNDDISCHARGE)

SEMI-CIRCULAR

DUCTKNOCKOUT

(REMOVEFOR7”

ROUNDDIS-

CHARGE)

8. 7”RoundDuctedDischargeOnly:

 Re-install7”RoundDuctPlateremovedinStep

#1under“PREPARETHEHOOD”section.Installa

7”rounddamper(purchaseseparately).Damper

apmustopenfreelyindirectionofairow(away

fromrangehood).

7. 3¼”x10”DuctedDischargeOnly:

 Attach Damper/Duct Connector over knockout

opening.MakesuredamperPivotis nearestto

Top/Back Edge of hood. Remove Tape from

damperap.

DAMPER/DUCT

CONNECTOR

(VERTICAL

DISCHARGE

POSITIONSHOWN)

TAPE

UPTO1”

SIDE-TO-SIDE

ADJUSTMENT

PIVOT

TOP/BACK

EDGE

NOTE

To accomodate o-center ductwork, the Damper/

Duct Connector can be installed up to 1-inch on

either side of hood center or the 7” Round Duct

Plate can be installed up to ½” on either side of

hood center. In extreme o-center installations,

one end of the duct connector may need to be

trimmed to clear the electrical cable clamp.

Warranty Safety CleaningOperation Installation Service Parts

WARNING: To reduce the risk of electric

shock, make sure power is switched o at

the service panel. Lock or tag service panel

to prevent power from being switched on

accidentally.

1. ConnectHouseWiring(120VAC)tohood.Use

apieceofCardboardtoprotectthecooktop,if

necessary.

2. Connecthouseblacktohoodblackwire,housewhite

tohoodwhitewire,andhousegroundunderGreen

Ground Screw. Securely tighten cable clamp onto

housewiring.

GREEN

GROUND

SCREW

3. Replacewiringcover.

CONNECT THE WIRING

OPTION

A Cord Kit is available - which enables the hood

to plug into a standard 120 VAC wall outlet.

See page 4 for Cord Kit information.

Cord Kit available by calling Sears

at 1-800-4-MY-HOME

Use only with range hood cord-connection

kits that have been investigated and found

acceptable for use with this model range

hood.

KEYHOLE

(4)

MOUNTING

SCREW

(4)

1.Hanghoodfrom(4)MountingScrews(fromparts

bag).Slidehoodtowardswalluntilmountingscrews

areengagedinnarrowendof(4)Keyholes.Tighten

mountingscrewssecurely.

2. Connectductworktohood.UseDuctTapetomake

jointssecureandairtight.

DUCT

TAPE

CAUTION: Do not push on fan blade! Pushing

on the blade may cause it to interfere with

other hood parts.

INSTALL THE HOOD

See page 4 for Bulb information.

Bulbs available by calling Sears at

1-800-4-MY-HOME

LIGHT

LENS

2. GraspLampatbase,tiltdownandpulloutto

remove.Replacewith42WFluorescentLamp

GX24Q-4.NightLightuses4W,C-7bulb.

1. PullTabonLightLensforwardandpulldownto

removelens.

CAUTION: Bulbs may be hot! Refer to bulb

packaging for further information.

42W

FLUORESCENT

LAMPGX24Q-4

3. Replacelightlens.

NIGHTLIGHT

C-7BULB

LAMP REPLACEMENT

SERVICE PARTS

WarrantySafety CleaningOperation

Installation

Service Parts

KEYNO. PARTNO. DESCRIPTION

 1 R740013 Damper/DuctConnector

   (includeshardware)

 2 R602017 Screw,#8-18x¼Hex*

   (2inpackage,6req.)

 3 R561116 RockerSwitch,White

   (2inpackage)

  R561117 RockerSwitch,Black

   (2inpackage)

 4 R627497 Nameplate,White

  R627499 Nameplate,Stainless

  R627575 Nameplate,Black

 5 R607657 Lens

 6 R602533 GroundScrew(2req.)

 7 R680504 WiringCover(includeshardware)

 8 * Rivet,Pop.125dia.(3req.)

 9 R169016 FilterSpringKit

 10 R169002 MotorMountingScrew

   (3eachpart)

 11 R99080535 Motor

   (includesMotorMountingKit)

 12 R531075 FanBlade(Includeshairpinclip)

 ** R99420635 HairpinClip

 13 99010299 FilterKit(2perbag)

 14 R169004 IndicatorLight

   (includes2wirenutsandlens)

 15 99111515 LightLens

 16 99271358 Lamp,42WFluorescent

 17 99770154 BallastAssembly

 18 99770150 WireHarness

 19 97018489 ReectorAssembly

 20 98010817 LightPanel,White

  98010818 LightPanel,Black

  98010814 LightPanel,Stainless

 21 R602534 Screw,8-18x3/8”*

   (2inpackage,5req.)

 22 R680508 7”RoundDuctPlate

   (includeshardware)

 23 99271426 Lamp,4W,C-7

OrderreplacementpartsbyPARTNO.-notbyKEYNO.

*Standardhardware-maybepurchasedlocally.

**Notillustrated.

Page is loading ...

Kenmore 30'' Under-Cabinet Range Hood - Black ENERGY STAR Owner's manual

Related papers

Other documents