Basco 3400-56SOR Installation guide

Brand: Basco

Model: 3400-56SOR

Type: Installation guide

QCI0019 REV. 1 Page 1 of 8 Certied 12/13/06

Unit No. 3400, 3500

Classic Frameless

Sliding Tub/Shower Enclosure

QCI00 19 REV. 1 Page 2 of 8 Certified 12/13/06

Although safety tempered glass is very resistant to breakage, the glass can still

break if unequal pressure is placed on it during installation. Use caution. In addi-

tion, the sharp corners of the panels can damage tile and floor surfaces, so it is best

to handle the glass panels carefully and protect the edges.

MAINTENANCE: Two primary materials are used to manufacture your new Basco enclosure:

tempered glass and anodized aluminum. To assure a long lasting finish on the enclosure, wipe it down

with a towel after each use. Never use a scouring agent to clean the aluminum.

For occasional, more concentrated cleaning efforts, we find that Maintain AquaGlideXP Spray Cleaner

helps minimize water stains and oxidation. Maintain is not only extremely effective at enhancing the

long term performance of glass coated with AquaGlideXP, it can aid in cleaning untreated glass as well.

Ask your distributor about Maintain Spray or visit www.bascoshowerdoor.com/warranty-and-care/care-

and-cleaning.aspx to purchase online.

Many over the counter cleaners, if applied to aluminum and left on, will harm the metal finish and cause

permanent damage, even though their directions indicate safe use on shower doors. Be sure that any over

spray falling on the aluminum frame is rinsed thoroughly and dried.

INSTALLATION NOTES: Unpack your unit carefully and inspect for freight damage. Lay out and

identify all parts using the instruction sheets as a reference. Before discarding the carton, check to see that

no small hardware parts have fallen to the bottom of the box. If any parts are damaged or missing, refer

to the descriptions noted in the instructions when contacting your dealer for replacements.

Handle the glass panels carefully and protect the edges. Safety tempered glass is very resistant to

breakage, but the sharp corners of the panels can damage tile and floor surface

Please wear safety glasses wh

enever drilling or cutting. When drilling holes in the ceramic tile or marble,

use a center punch and hammer to carefully break the surface glaze so the drill can start without skidding.

To install your BASCO Shower Door you will need the following: tape measure, level, #2 Phillips

screwdriver, 3/16” wrench, drill, 1/8” and 3/16” drill bits, hacksaw, pencil, and caulking (clear silicone

recommended). Optional tools include a miter box for cutting parts to length, files, center punch, and

masking tape.

NOTE: Tempered glass cannot be cut.

For drilling tile a 3/16” masonary bit is recommened.

3$576/,67

$7XE7UDFNZLWK9LQ\O

%:DOO-DPEV

&3ODVWLF:DOO$QFKRUV

'[´7UXVV+HDG6FUHZV

(1\ORQ6SDFHUV

)+HDGHU

**ODVV3DQHOV

++DQJHU%UDFNHWV3UHDVVHPEOHG

.$FU\OLF7RZHO%DU%UDFNHWV

/7RZHO%DU%DVHV

0[´)ODW+HDG6FUHZV

17RZHO%DU

39LQ\O6KLPV

53XOO+DQGOHV

6%DVFR'HFDOV

71\ORQ%RWWRP*XLGH

8[´3DQ+HDG6FUHZ

99LQ\O-DPE%XPSHUV

:%DVFR'HFDO

"

(

QCI0019 REV. 1 Page 3 of 8 Certified 12/13/06

%84%2)/2

7!,,

*!-"

45"

42!#+

#!5,+

45"

42!#+

,%6%,

0HDVXUHWKHZDOOWRZDOORSHQLQJDWWKHFHQWHURI

WKHWXEULP&XWWKHWXEWUDFN>$@ ´ VKRUW RI WKLV

GLPHQVLRQ$QLQH[SHQVLYHPLWHUER[DYDLODEOHDW\RXU

ORFDOKDUGZDUHVWRUHZLOOKHOS\RXJHWFOHDQVTXDUH

FXWV



3RVLWLRQWKHWXEWUDFNLQWKHFHQWHURIWKHWXEULPZLWK

WKHWDOOOHJWRWKHH[WHULRU,WPD\EHQHFHVVDU\WRILOHD

UDGLXV RQ WKH HQGV RI WKH WXE WUDFN DQG ZDOO MDPEV WR

PDWFKWKHFRUQHUVRIWKHWXE



3UHVV ERWK ZDOO MDPEV >%@ LQWR SRVLWLRQ RYHU WKH WXE

WUDFN 0DVNLQJ WDSH FDQ EH XVHG WR KROG WKH SDUWV LQ

SODFHWHPSRUDULO\





8VHDOHYHOWR SOXPEERWKZDOOMDPEV>%@WKHQ

PDUNWKHSUHGULOOHGKROHORFDWLRQVRQWKHZDOO/LJKWO\

PDUN DORQJ ERWK VLGHV RI WKH WXE WUDFN >$@ ZLWK D

SHQFLOWKHQUHPRYHDOOSDUWV



)RUWLOH RUPDUEOH ZDOOVGULOOVL[ ´ GLDPHWHU KROHV

DQGLQVHUWWKHSODVWLFZDOODQFKRUV>&@$FHQWHUSXQFK

KHOSVORFDWHWKHKROHVDFFXUDWHO\



$WWDFKPHQWVWRILEHUJODVVRUDFU\OLFXQLWVFDQEHPDGH

LQ WZRZD\V,IUHLQIRUFHPHQW LVEXLOWLQWRWKHZDOORI

WKH XQLW GULOO VL[ ´ GLDPHWHU KROHV DQG LQVWDOO WKH

VFUHZVGLUHFWO\LQWRWKHUHLQIRUFHPHQW,IWKHZDOOVDUH

QRWUHLQIRUFHGGULOO´KROHVDQGLQVWDOOSODVWLFZDOO

DQFKRUV RU PROO\ EROWV PROO\ EROWV QRW VXSSOLHG E\

%DVFR



&$87,217KHWUDFNVKRXOGQHYHUEHVFUHZHGWRWKH

WXE7KLVZLOOGDPDJHWKHWXEDQGFDXVHOHDNDJH



%HIRUHUHSODFLQJWKHWXEWUDFN>$@ IRUFH D

VOLJKWGRZQZDUGERZLQWKHH[WUXVLRQ7KLVZLOOHQVXUH

WKH WUDFNILWV WLJKWWRWKHWXE5XQ WZR EHDGV RI FDXON

LQVLGHWKHSHQFLOHGPDUNVRQWKHWXEULP3ODFHWKHWXE

WUDFNLQWKHH[DFWSRVLWLRQPDUNHGLQ6WHSDQGVHDWLW

ILUPO\LQWKHFDXONLQJ



127(,PSURSHUFDXONLQJZLOOUHVXOWLQOHDNV



QCI0019 REV. 1 Page 4 of 8 Certified 12/13/06

7!,,

*!-"

.9,/.

30!#%2

v42533

(%!$3#2%7

(%!$%2

7!,,

*!-"

%84%2)/2

0!.%,

2/,,%2

"%!2).'

%84%2)/2

(%!$%2

',!33

0!.%,

5HSODFH RQH ZDOOMDPE>%@ DQG DWWDFK WR ZDOO

ZLWK D  [  ´ WUXVV KHDG VFUHZ >'@ LQVHUWHG

WKURXJKWKHFHQWHUKROH6OLSDQ\ORQVSDFHU>(@RYHUD

[´WUXVVKHDGVFUHZDQGLQVWDOOLQWKHWRSKROH

RI WKH ZDOO MDPE &KHFN MDPE IRU SOXPE DQG WLJKWHQ

VFUHZV



127('RQRWRYHUWLJKWHQWKHMDPEVFUHZV





7KLVEDWKHQFORVXUHLVHTXLSSHGZLWKVDIHW\WHH

ORFNZDOOMDPEV:KHQLQVWDOOHGSURSHUO\WKHKHDGHULV

SHUPDQHQWO\ ORFNHG WR WKH ZDOO MDPEV DQG FDQQRW EH

DFFLGHQWDOO\GLVORGJHG



0HDVXUHWKHZDOOWRZDOORSHQLQJDWWKHWRSRIWKHZDOO

MDPEV >%@ DQG FXW WKH KHDGHU >)@ ´ VKRUW RI WKLV

GLPHQVLRQ&KHFNWKHKHDGHUIRUILW



6OLGHWKH VDIHW\WHHORFNRIWKHXQPRXQWHGZDOOMDPE

LQWR WKH KHDGHU 7KH FRQWRXUHG VXUIDFH RI WKH KHDGHU

JRHVWRWKHH[WHULRURIWKHXQLW



+ROGLQJWKHKHDGHUDWDQDQJOHHQJDJHWKHHQGRQWRWKH

PRXQWHG ZDOO MDPE 3LYRW WKH KHDGHU LQWR SODFH WKHQ

VOLGH WKH ORRVH ZDOO MDPE WR WKH ZDOO DQG SUHVV LQWR

SRVLWLRQ RQ WKH WXE WUDFN $WWDFK WR WKH ZDOO SHU

LQVWUXFWLRQVLQ6WHS





2EVFXUH JODVV SDQHOV >*@ VKRXOG EH LQVWDOOHG

ZLWKWKHURXJKVXUIDFHRIWKHJODVVWRWKHH[WHULRURIWKH

XQLW (WFKHG JODVV SDQHOV VKRXOG EH LQVWDOOHG ZLWK WKH

SDWWHUQHG VXUIDFH WR WKH RXWVLGH 1RWH WKDW WKH KDQJHU

EUDFNHWV >+@ DUH PRXQWHG LQ RSSRVLWH GLUHFWLRQV WR

FUHDWHDQLQWHULRUDQGH[WHULRUGRRUSDQHO



,IWKHKDQJHUEUDFNHWVDUHQRWIDFWRU\LQVWDOOHGVOLGHWKH

SUHDVVHPEOHG EUDFNHWV RQWR WKH WRS HGJHV RI WKH

LQWHULRU DQG H[WHULRU JODVV SDQHOV  7LJKWHQ WKH WKUHH

VFUHZVRQHDFKEUDFNHWHYHQO\WRVHFXUHO\JULSWKHJODVV

SDQHO &KHFN WKH Q\ORQ UROOHU RQ HDFK EUDFNHW IRU

WLJKWQHVVDQGSURSHUORFDWLRQLQWKHFHQWHURIWKHVORW



v42533

(%!$3#2%7

).4%2)/2

0!.%,

(!.'%2

"2!#+%43

QCI0019 REV. 1 Page 5 of 8 Certified 12/13/06

6OLGH WKH WZR WULP ULQJV >-@ RYHU WKH DFU\OLF

WRZHOEDUEUDFNHWV>.@DQGDWWDFKWRWKHWRZHOEDUEDVHV

>/@ZLWKWZR[´IODWKHDGVFUHZV>0@)RUFH

WKHWRZHOEDU>1@RQWRRQHRIWKHEUDFNHWV$WWKHFHQWHU

RI WKH H[WHULRU JODVVSDQHO SUHVV WKH EDVHZLWKWRZHO

EDU DWWDFKHG DQG WKH YLQ\O VKLP >3@RYHUWKHJODVV

,QVWDOOWKHUHPDLQLQJEDVHLQDVLPLODUPDQQHUORFNLQJ

WKHWRZHOEDULQWRSODFHEHWZHHQWKHWZREUDFNHWV



127(  'R QRW XVH D PHWDO KDPPHU WR LQVWDOO WKH

WRZHOEDU%DVHV





 $OLJQWKHWZRSXOOKDQGOHV>5@DQGYLQ\OVKLPV

>3@ LQWR SODFH RQ WKH LQWHULRU JODVV SDQHO DW WKH VDPH

KHLJKWDVWKHWRZHOEDUEDVHV>/@ZHUHPRXQWHGRQWKH

H[WHULRUSDQHO



127(  'R QRW XVH D PHWDO KDPPHU WR LQVWDOO WKH

SXOOKDQGOHV





%HIRUH LQVWDOOLQJ WKH GRRU SDQHOV WKH SURSHU

RULHQWDWLRQVKRXOGEHGHWHUPLQHG)RUPD[LPXPZDWHU

SURRILQJWKHLQWHULRUSDQHOVKRXOGDOZD\VEHSRVLWLRQHG

FORVHVWWRWKHVKRZHUKHDGDVVKRZQLQWKLVLOOXVWUDWLRQ



42)-

2).'

4/7%,

"!2"!3%

%84%2)/2

05,,

(!.$,%

6).9,

3()-

%84%2)/2

4/7%,

"!2

6).9,

3()-

Xv

&(3#2%7

4/7%,"!2

"2!#+%4

QCI0019 REV. 1 Page 6 of 8 Certified 12/13/06

%84%2)/2

(%!$%2

).4%2)/2

0!.%,

%84%2)/2

0!.%,

45"

42!#+





/LIW WKH LQWHULRU JODVV SDQHO LQWR SRVLWLRQ ZLWK

WKH UROOHUV HQJDJLQJ WKH JURRYH LQ WKH KHDGHU >)@

5HSHDWIRUWKHH[WHULRUSDQHO,ISDQHOVDUHQRWSDUDOOHO

WR WKHLU UHVSHFWLYH ZDOO MDPEV UHPRYH DQG DGMXVW WKH

UROOHUVXSRUGRZQLQWKHLUVORWVWRFRPSHQVDWH





/RFDWH WKH Q\ORQ ERWWRP JXLGH >6@ LQ WKH

PLGGOHRIWKHWXEWUDFN>$@ZLWKWKHJODVVSDQHOVLQWKH

SRVLWLRQ VKRZQ :LWK D ´ ELW GULOO WZR KROHV LQWR

WKH9JURRYHWKURXJKWKHPRXQWLQJKROHVLQWKHJXLGH

,QVWDOOWKHERWWRP JXLGH ZLWK WZR  [ ´ SDQ KHDG

VFUHZV>7@WKUXWKHGULOOHGKROHVDVVKRZQ





 6OLGHWKHVWDLQOHVVVWHHOEXPSHULQVHUWV>8@LQWR

WKHIRXUVRIWYLQ\OMDPEEXPSHUV>9@$OLJQWKHVORWVLQ

WKHEXPSHUVZLWKWKHJODVVSDQHOVDQGVQDSWKHEXPSHUV

GRZQZDUG RYHU WKH WRS DQG ERWWRP ZDOO MDPE VFUHZV

>'@ZLWKWKHVSDFHUV>(@





-/,$%$

"5-0%2

7!,,

*!-"

3#2%7

30!#%2

).3%24

45"

42!#+

',!:%$

0!.%,3



#%.4%2

'5)$%

).4%2)/2

8h

0!.(%!$

3#2%7

QCI0019 REV. 1 Page 7 of 8 Certified 12/13/06

#!5,+

#!5

7!,,

*!-"

45"

42!#+

 1HDWO\ FDXON HDFK HQG RI WKH WXE WUDFN >$@

ZKHUHLWPHHWVWKHZDOOMDPEV>%@DQGWKHLQWHULRUHGJH

RI WKH ZDOO MDPEV DV VKRZQ 5XQ D EHDG RI FDXONLQJ

DORQJWKHLQWHULRUHGJHRIWKHWXEWUDFN



127(  7KH FDXONLQJ VKRXOG EH DOORZHG WR FXUH IRU

WZHQW\IRXU KRXUV EHIRUH XVLQJ \RXU QHZ EDWK

HQFORVXUH



 3HHO WKH EDFNLQJ IURP WKH %DVFR GHFDO >:@

DQGSODFHLWDWWKHHQGRIWKHKHDGHU>)@RQWKHLQWHULRU

IDFH





$%#!,

7!,,

*!-"

).4%2)/2

&!#%/&

(%!$%2

QCI0013 REV. 1 Page 8 of 8 Certified 12/13/06

Basco 3400-56SOR Installation guide

Basco 3400-56SOR Installation guide

Basco 3400-56SOR Installation guide

Related papers

Other documents