White Mountain Hearth OP32FB2MF-3 Owner's manual

Brand: White Mountain Hearth

Model: OP32FB2MF-3

Category: Fireplaces

Type: Owner's manual

Page 1

INSTALLATION INSTRUCTIONS

AND OWNER'S MANUAL

OUTDOOR VENTLESS FIREBOX

MODELS:

OP32FB2MF-3*

OP36FB2MF-3

OP42FB2MF-3

* Please note, Empire Comfort Systems does not

offer an outdoor gas burner to t the OP32FB2MF

rebox. You will need to nd a suitable burner from

another manufacturer.

GAS-FIRED

FOR USE ONLY WITH A LISTED GAS-FIRED

UNVENTED DECORATIVE ROOM HEATER

NOT TO EXCEED 50,000 BTU/H.

DO NOT BUILD A WOOD FIRE.

Carefully review the instructions supplied

with the decorative type unvented room

heater for the minimum rebox size

requirement.

DO NOT INSTALL AN APPLIANCE IN THIS

FIREBOX UNLESS THIS FIREBOX MEETS

THE MINIMUM DIMENSIONS REQUIRED

FOR THE INSTALLATION.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

WARNING

If the information in this manual is not

followed exactly, a re or explosion may

result causing property damage, personal

injury or loss of life.

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open ame.

3. If odor continues, keep away from the

appliance and immediately call your gas

supplier or re department.

WARNING

Improper installation, adjustment,

alteration, service or maintenance can

cause injury or property damage. Read the

installation, operating and maintenance

instructions thoroughly before installing or

servicing this equipment.

This product complies with ANSI Z.21.91 for outdoor use with

Z21.97 burners, 50,000 BTU Max.

MH45080

33857-4-0117Page 2

SECTION PAGE

BEFORE YOU START .............................................................................................3

CARTON CONTENTS & HARDWARE PACKAGE ..................................................3

IMPORTANT SAFETY INFORMATION ....................................................................4

HOMEOWNER REFERENCE INFORMATION .......................................................5

INTRODUCTION .................................................................................................5 - 6

ACCESSORIES .......................................................................................................6

FIREBOX DIMENSIONS .......................................................................................... 7

CLEARANCES ......................................................................................................8-9

PLANNING INSTALLATION .............................................................................. 10-11

FIREBOX INSTALLATION INSTRUCTIONS ....................................................11-12

INSTALLING HOOD ............................................................................................... 12

GAS LINE CONNECTION .....................................................................................13

MAINTENANCE .....................................................................................................13

PARTS VIEW .........................................................................................................14

PARTS LIST ...........................................................................................................14

MASTER PARTS DISTRIBUTOR LIST .................................................................. 15

HOW TO ORDER REPAIR PARTS ........................................................................15

WARRANTY TERMS .............................................................................................16

TABLE OF CONTENTS

33857-4-0117 Page 3

BEFORE YOU START

Sample Warnings and Denitions:

DANGER

Indicates a hazardous situation which, if not avoided, will result

in death or serious injury.

WARNING

Indicates a hazardous situation which, if not avoided, could

result in death or serious injury.

CAUTION

Indicates a hazardous situation which, if not avoided, could

result in minor or moderate injury.

NOTICE: Indicates information considered important but not

hazard related.

1. Read the Safety Information on page 4.

2. Determinewheretoinstalltherebox.Seepages10-11.

3. Frame the opening. See page 11.

4. Install optional drain tray. (See instructions with drain tray)

5. Installtherebox.Seepages12.

6. Install the gas lines. See page 13.

7. Install hood, optional bifold door or optional extension hood.

8. Install and light the burner (sold seperately).

9. Show homeowner how to do basic maintenance.

HARDWARE PACKAGE & CARTON CONTENTS

Hardware Package

Hood

Note: See parts view and parts list on page 14 for ordering replacement parts.

Note: Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at hardware stores.

SCREW, 10-32 X

TYPE F

PHILLIPS PAN HEAD (QTY 4)

SCREW, 10-24 X

TYPE

PHILLIPS HEX HEAD (QTY 2)

33857-4-0117Page 4

IMPORTANT SAFETY INFORMATION

FOR THE INSTALLER

• Leaveinstructionmanualwiththehomeowner

• ThisreboxcomplieswithANSIZ21.91foroutdoorusewith

Z21.97 burners, 50,000 BTU MAX.

• Installationandrepairshouldbedonebyaqualiedservice

person.Thisreboxshouldbeinspectedbeforeuseandat

leastannuallybyaqualiedserviceperson.

• Duringmanufacture,thisreboxistreatedwithoils,lms

and bonding agents. These are not harmful but may produce

smoke and odor as they burn off during initial operation. This

is normal.

• Anymodicationtothisreboxortocontrolscanbe

dangerous.Improperinstallationoruseofthereboxcan

causeseriousinjuryordeathfromre,burns,explosionor

carbon monoxide poisoning.

• Thereboxhoodmustnotbemodied.

• UseNon-CombustibleMaterialswhereindicatedforthe

reboxinstallation.Non-combustiblematerialsdonotignite.

These include metal, brick, ceramic, concrete, slate, glass,

and plaster. Adhesives must be rated for high temperatures

(300°F +). Any mechanical fasteners used to install material

must also be non-combustible, including wall anchors

and tile spacers. Materials that pass the ASTM E 136 test

(Standard Test Method for Behavior of Materials in a Vertical

Tube Furnace at 750C) are considered non-combustible.

• Whenthereboxisinstalleddirectlyoncarpeting,tileor

othercombustiblematerial,otherthanwoodooring,the

reboxmustbeinstalledonametalorwoodpanelextending

the full width and depth of the enclosure.

FOR THE HOMEOWNER

• Alertchildrenandadultstothehazardsofhighsurface

temperatures. Keep children and other at-risk individuals

away to avoid burns or clothing ignition.

• Carefullysuperviseyoungchildrenwhentheyareinthe

sameareaastherebox.

• Donothangorplaceclothingorotherammablematerials

onorneartherebox.

• DonotallowCombustibleMaterialsadjacenttoorincontact

withfaceoftherebox.Combustiblematerialsincludewood,

orothermaterialsthatwillburnevenwhentreatedwithre-

retardant chemicals.

• Keepreboxareaclearandfreefromcombustiblematerials,

gasolineandotherammablevaporsandliquids.

• Donotallowfanstoblowdirectlyintoorattherebox.

• Avoidanydraftsthatalterburneramepatterns.

• Donotoperatethisreboxwithglassdoorsorweatherdoor

intheclosedposition.Areboxscreenmustbeinplace

when the burner is being used.

• Donotusethisreboxifanyparthasbeenunderwater.

Immediatelycallaqualiedservicetechniciantoinspectthe

reboxandtoreplaceanypartofthecontrolsystemandany

gas control which has been under water.

33857-4-0117 Page 5

Moisture Resistance

Thisoutdoorreboxwillshedmoderateamountsofwater,butis

not waterproof. Water and condensing water vapor may enter the

chase under certain conditions.

Thereboxwillnotperformasanexteriorwall.Moisture

penetration must be considered for construction that places the

reboxinstructurewallsoronmoisturesensitivesurfaces.

When installed next to exterior walls: Empire Comfort Systems

recommendsthereboxchasebeconstructedoutsidethe

structure's weather envelope. Where the platform meets the wall,

useaashingdetailsimilartothatrequiredforattacheddecks.

Chase platforms, including hearths should slope away from the

structureat1/4inchperfoot.Thereboxcanbeshimmedlevel.

When installed on surfaces where water may collect or cause

damage: Empire Comfort Systems recommends a slope of

1/8 inch to 1/4 inch per foot towards the drain port suggested.

Thereboxcanbeshimmedlevel.

Hearthsshouldslopeawayfromthefrontofthereboxand

chase at 1/8 inch to 1/4 inch per foot. Metal safety strips must

be on top of any combustible hearth materials used for moisture

management.

Whenpurchasingareboxwerecommendyoualsobuya

weathercoverorglassdooraccessorytoprotectthereboxfrom

moisture.Neverinstallthereboxwheremoisturecannotdrain

easily.

Screened Porch Installation

ThereboxmaybeinstalledsafelyandisdesigncertiedbyUL

to be installed in a screen porch with the following guidelines.

MinimumPorchArea 96sqft

Minimum Ceiling Height 84 inch

See Pages 10 - 11, Planning Installation.

Instructions to Installer

1. Leave instruction manual with owner after installation.

2. Show home owner Product Registration Card supplied with

rebox.

3. Fill in the Homeowner Reference Information above.

4. Show owner how to start and operate outdoor burner (not

provided).

Always consult your local Building Department regarding

regulations, codes or ordinances which apply to the installation of

anoutdoorrebox.

This application is only for use with the type of gas indicated on

the burner rating plate. Burner sold separately.

WARNING

Any change to this FIREBOX can be dangerous.

Improperinstallationoruseofthereboxcancauseserious

injuryordeathfromre,burns,explosionorcarbonmonoxide

poisoning.

ThisreboxisdesigncertiedinaccordancewithAmerican

National Standard Z21.91 for outdoor use with Z21.97 burners.

Note: This rebox has been tested and approved up to

50,000 BTU’s. DO NOT USE WITH BURNERS OVER 50,000

BTU’s.

Important

All correspondence should refer to complete Model Number, and

Serial Number. Refer to the Homeowner Reference Information

above.

INTRODUCTION

HOMEOWNER REFERENCE INFORMATION

Werecommendthatyourecordthefollowinginformationaboutyourrebox.

Model Number: _____________________________ Date purchased: ________________________

Serial Number: _____________________________  Locationofrebox: ______________________

Dealer Name: ______________________________ Dealer Phone: _________________________

Notes: ______________________________________________________________________________

33857-4-0117Page 6

INTRODUCTION

Qualied Installing Agency

Installation and replacement of gas piping, gas utilization

equipmentoraccessoriesandrepairandservicingofequipment

shallbeperformedonlybyaqualiedagency.Theterm"qualied

agency"meansanyindividual,rm,corporationorcompany

which either in person or through a representative is engaged

in and is responsible for (a) the installation or replacement of

gas piping or (b) the connection, installation, repair or servicing

ofequipment,whoisexperiencedinsuchwork,familiarwithall

precautionsrequiredandhascompliedwithalltherequirements

of the authority having jurisdiction.

Whenthereboxisconnectedtoaxedpipingsystem,the

installation must conform with local codes, or in the absence

of local codes with the National Fuel Gas Code, ANSI Z223.1*/

NFPA 54, or International Fuel Gas Code.

*Available from the American National Standards Institute, Inc.

1430 Broadway, New York, N.Y. 10018.

During manufacture and fabricating, components of this

appliance are treated with oils, lms, and/or bonding

agents. These are not harmful, but may produce smoke and

smells as they are burned off during initial operation of the

appliance. This is normal.

Solidfuelsshallnotbeburnedinthisrebox.

Cleaning Instructions at Installation

Thisreboxisbuiltusingmostlyhigh-gradestainlesssteelto

resist rust-through. In outdoor applications, all stainless steel will

develop a dull patina and, depending on the local environment

and on the materials used in the installation, may develop some

surface oxidation (rust). This does not affect the performance

oftherebox,anddoesnotrequireanyactiontocorrect.Ifyou

preferkeepingyourreboxfrontlookingfactory-fresh,cleanitas

requiredwithstainlesssteelcleaner.

When installation application includes highly acidic applications

such as acid wash or stone etching, do not remove the protective

PVClmfromthestainlesssteeluntilafterthisapplicationis

complete.Oncethelmhasbeenremovedwerecommend

that the appliance be cleaned with a stainless steel cleaner

immediately.

Pleasenotethatareaswherethelmhasbeenformed(corners,

hems,etc.)mayrequireextracleaningduetothepropertiesof

thelm.Ensurethatallprotectivelmhasbeenremovedfrom

thereboxpriortoburningtherebox.

Commonwealth of Massachusetts: The installation must be

madebyalicensedplumberorgastterintheCommonwealth

of Massachusetts.

Sellersofunventedpropaneornaturalgas-redsupplemental

room burners shall provide to each purchaser a copy of 527

CMR-30 upon sale of the unit.

In the Commonwealth of Massachusetts, unvented propane and

naturalgas-redspaceburnersshallbeprohibitedinbedrooms

and bathrooms.

Model Number Description

BD32SS 32-Inch Bifold Glass Door

BD36SS 36-Inch Bifold Glass Door

BD42SS 42-Inch Bifold Glass Door

DT32SS 32-Inch Drain Tray - Stainless Steel

DT36SS 36-Inch Drain Tray - Stainless Steel

DT42SS 42-Inch Drain Tray - Stainless Steel

WD32SS 32-Inch Weather Door - Stainless Steel

WD36SS 36-Inch Weather Door - Stainless Steel

WD42SS 42-Inch Weather Door - Stainless Steel

VB4H32SS 32-Inch Extended Hood - Stainless Steel

VB4H36SS 36-Inch Extended Hood - Stainless Steel

VB4H42SS 42-Inch Extended Hood - Stainless Steel

The following accessory parts can be obtained from your Empire Comfort Systems dealer. Contact your Empire Dealer for more acces-

sory options. If you need additional information beyond what your dealer can furnish, contact Empire Comfort Systems Inc., 918 Freeburg

Ave., Belleville, Illinois 62220-2623.

ACCESSORIES

33857-4-0117 Page 7

FIREBOX DIMENSIONS

INDEX

LETTER

DIMENSION DESCRIPTION DIMENSIONS (in inches)

OP32 OP36 OP42

A Themaximumheightofreboxface(excludingstandoffs) 33-1/16 35-1/16 35-1/16

B Themaximumwidthofthereboxface(excludingnailinganges) 35 40 44

C Themaximumdepthoftherebox 16-9/16 19 19

D Theheightofthereboxopening 22-1/4 24-1/4 24-1/4

E Thewidthofthereboxopening 31 36 40

F Theinteriordepthoftherebox 13-3/16 15-9/16 15-9/16

G Therearexteriorwidthoftherebox 27-7/8 31-7/8 35-7/8

K Height from the bottom of the box to the gas line opening 8-11/16 8-11/16 -11/16

L Depth from the front of the box to gas line opening 11-5/8 14 14

M Depth from rear of box to gas line opening 4-3/4 4-3/4 4-3/4

Q Distancefromoortoreboxopening 6-3/16 6-3/16 6-3/16

S Overall height to header 33-13/16 35-13/16 35-13/16

T Interiorfrontheightofrebox 21-3/8 24-3/16 24-3/16

U Interiorrearheightofrebox 17-7/8 19-1/4 19-1/4

V Interiorfrontwidthofrebox 29-7/16 34-5/16 38-5/16

W Interiorrearwidthofrebox 24 28 32

X Corner installed depth 30-3/16 34-11/16 36-3/4

Y Corner installed wall length 42-11/16 49-1/16 51-15/16

Z Corner installed width 60-3/8 69-5/16 73-5/16

INNER FIREBOX DIMENSIONSINNER FIREBOX DIMENSIONS

TOP VIEW

SIDE VIEW

GAS INLET HOLES

BOTH SIDES

OUTER FIREBOX DIMENSIONS

33857-4-0117Page 8

3/4" GAP REQUIRED

ACROSS ENTIRE TOP

OF FIREPLACE

2 X 4

TOP PLATE

COMBUSTIBLE

FINISHED WALL

OR MANTEL

NON-COMBUSTIBLE

BOARD OR FACING

CLEARANCES

Top Framing and Finishing: Combustible framing materials

requires3/4inchtotopofrebox.See Figure 1.

Sidewall Clearances: The clearance from the inside of the

reboxtoperpendicularcombustiblesidewallshouldnotbe

less than 6 inches. See Figure 2.

Firebox Face Clearance: 3/8 inch from face and back 1 3/4

inches.

Firebox Side and Back Clearances:Thereboxoutercasing

sideandbackangesarezeroclearancetocombustibles.

Firebox Front Clearance: Leave at least 36 inches clearance

fromthefrontofthereboxintotheroom.

Ceiling Clearances: The ceiling height should not be less than

84inchesfromtheoor.See Figure 3.

Mantel Clearances: Firebox models must use the hood supplied

withtherebox,ortheoptionalextensionhoodavailablefor

each model. If a combustible mantel is installed, it must meet

theclearancerequirementsdetailedinFigure 3.

Grate Clearance: The minimum clearance between the front

legsofthegrateandfrontedgeofthereboxis2inches.

MIN.

FIREBOX

(TOP VIEW)

FRONT FACE (SIDE)

3”

MAX.

1 3/4”

PERPENDICULAR

SIDE WALL

COMBUSTIBLE

MATERIALS ALLOWED

IN SHADED AREAS

45°

3/8”GAP REQUIRED

BOTH SIDES

FIREBOX WALL

OUTER WRAPPER

Figure 2

Figure 1 - Clearances to Combustibles

33857-4-0117 Page 9

CLEARANCES

Mantel Chart

Television Considerations

Installingatelevisionaboveanreboxhasbecomeincreasingly

popular;however,theareaaboveanyreboxgetshotandmost

TV manufacturers recommend against placing their products

near a heat source.

Ifyouinstallatelevisionabovethisrebox,EmpireComfort

Systems accepts no responsibility for damage or injuries. Follow

the television manufacturer’s installation instructions, including any

recommendations regarding proximity to heat sources.

IfyouhaveaTVaboveyourrebox,turnoffthereboxandletit

cool completely before servicing or touching any buttons on the TV.

HOOD

FIREBOX

FACE

84”

MIN.

(CEILING TO FLOOR)

CEILING

FLOOR

WALL FACING

9 3/4”

28 1/2”

MIN.

18 3/4”

MIN.

3/4”TO COMBUSTIBLES

REQUIREDACROSS

ENTIRETOP EDGE

OF FIREPLACE

53 1/2”

MIN.

COMBUSTIBLES

ALLOWED

WALL STUD

INDEX

LETTER

Dimensions in inches

DISTANCE FROM

WALL SURFACE

DISTANCE ABOVE

Firebox HOOD

A 2 18 ¾

B 4 21 ½

C 6 24 ¼

D 8 27

E 10 27 ¾

F 12 28 ½

Figure 3

33857-4-0117Page 10

Inplanningtheinstallationfortherebox,itisnecessaryto

determine where the unit is to be installed. Gas supply piping

should also be planned at this time.

Thereboxcanbemountedonanyofthesesurfaces:

1. Aatcombustibleornon-combustiblesurface.

2. A raised platform combustible material.

3. Fourcornersofthereboxsocontactismadeonallfour

perimeter edges on its bottom.

(Example: Four concrete blocks - if allowed by local code.)

Ifthereboxisinstalleddirectlyoncarpeting,tileorother

materialotherthanwoodooring,itshouldbeinstalledona

metal or wood panel extending the full width and depth of the

rebox.

Decide what components to include in your installation.

Thisreboxisintendedforinstallationonanoutdoorpatioor

inyouryard.Thisreboxshallbeusedonlyoutdoorsinawell

ventilated space and shall NOT be used in a building, garage, or

other enclosed area.

Installthereboxinanareashelteredfromdirectwind,which

maycauseerraticamesandmainburneroutage.Erraticames

could also cause soot on logs, walls or ceiling. Flame outages

and sooting are nuisances but pose no safety issues.

Typical installation may include covered patio, gazebo or an

outside wall of a house.

• Minimumporcharea–96sqft

• Minimum ceiling height – 84 inches

Installation in partial enclosures must conform with one of the

following conditions:

• With walls on all sides, but with no overhead cover. See

Figure 4.

FIREPLACE

Figure 4

• Within a partial enclosure which includes an overhead cover

and no more than two side walls. These side walls may be

parallel, as in a breezeway or at right angles to each side.

See Figure 5.

FIREPLACE

Figure 5

• This partial enclosure includes an overhead cover and three

walls, no more than 30% or more of the horizontal periphery

(i.e. perimeter) of the enclosure permanently open. These

openings cannot be screened or have operable windows or

shutters. See Figure 6.

FIREPLACE

Figure 6

Outdoor Firebox Enclosure Requirements

Donotinstallreboxuntilallnecessaryprovisionsaremadefor

combustion and ventilation air. Consult the written instructions

providedwiththereboxforinformationconcerningcombustion

and ventilation air. In the absence of instructions, refer to

the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Air for

Combustion and Ventilation, or applicable local codes.

ATTENTION: Vinyl Soft, Vinyl Ceiling, Vinyl Overhang

Disclaimer

Clearances are to heat resistant material (i.e. wood, metal).

This does not include vinyl. Empire Comfort Systems Inc.

will not be held responsible for heat damage caused to vinyl

overhangs,vinylceilingsorvinylventilated/unventilatedsofts.

PLANNING INSTALLATION

33857-4-0117 Page 11

PLANNING INSTALLATION

Television Considerations

Installingatelevisionaboveareboxhasbecomeincreasingly

popular;however,theareaaboveanyreboxgetshotandmost

TV manufacturers recommend against placing their products

near a heat source.

Ifyouinstallatelevisionabovethisrebox,EmpireComfort

Systems accepts no responsibility for damage or injuries. Follow

the television manufacturer’s installation instructions, including

any recommendations regarding proximity to heat sources.

IfyouhaveaTVaboveyourrebox,turnoffthereboxandletit

cool completely before servicing or touching any buttons on the

TV.

ThemaximumBTUinputforthisreboxis50,000.Verifythat

any burner and/or accessory are rated for use up to 50,000

Btubeforeinstallingitintothisrebox.Followanyspecial

installation instructions that came with the burner or accessory

(i.e. clearances, combustion and ventilation air, and enclosure

information).

WARNING

Improper installation, adjustment, alteration, service or

maintenance can cause property damage, personal injury or

loss of life. Installation and service must be performed by a

qualiedinstaller,serviceagencyorthegassupplier.

FIREBOX INSTALLATION INSTRUCTIONS

InstallonlyanANSIZ21.97burnerintothisrebox.

Any burner must be “For use with approved ANSI Z21.11.2

unvented room heater.”

Inplanningtheinstallationfortherebox,itisnecessaryto

determinewherethereboxistobeinstalledandwhether

optional accessories are desired. Gas supply piping should also

be planned at this time.

FOR

A RAISED HEARTH:

COVER

ANY COMBUSTIBLE

TERIALS WITH

NON-COMBUSTIBLE

TERIAL THE WIDTH

THE FIREPLACE

OPENING

AND EXTENDING

LEAST 16 INCHES FROM

THE FIREPLACE

BOTTOM OF

FIREPLACE

OPENING

COMBUSTIBLE MATERIALS

HEARTH PLATFORM

Figure 7

NOTICE: Hearthisnotrequiredifreboxisinstalledonnished

oor.

Firebox Framing

Fireboxframingcanbebuiltbeforeorafterthereboxisset

in place. Framing should be positioned to accommodate wall

coveringandreboxfacingmaterial.Thereboxframingshould

be constructed of 2 x 4 lumber or heavier. The framing top plate

or header may be as close as 3/4 inch above the top of the

rebox.RefertoFigure 8forreboxframingdimensions.

Deluxe Vent-Free Firebox Framing Dimensions (inches)

A B C

Model Framing

Height

Framing

Width

Framing

Depth

OP32FB2MF 34 36 16-3/4

OP36FB2MF 36 41 19-1/4

OP42FB2MF 36 45 19-1/4

Figure 8

Premium Fireplace Framing Dimensions -

If Installing Optional Drain Tray (inches)

Model A B C

OP32FB2MF 35 36 16-3/4

OP36FB2MF 37 41 19-1/4

OP42FB2MF 37 45 19-1/4

33857-4-0117Page 12

Installing the Hood

Ahoodthatisfurnishedwitheachrebox(oroptionalextension

hood)MUSTbeinstalledbeforethereboxisused.Failuretodo

somaycreateapossiblerehazard.

1. Loosenthetwoscrews(A)holdingreboxtoptofacepanel,

thenslidethehoodangebetweenthereboxtopandface

panel and re-tighten the screws. See Figure 11.

2. Install one screw at each end of the hood as shown (C). See

Figure 11.

Figure 11

Finishing

All joints (top, bottom and sides), where the wall or decorative

facingmaterialmeetsthereboxsurroundmustbesealedwitha

non-combustible material (300°F + Sealant).

NOTICE: When installation application includes highly acidic

applications such as mortar or stone etching, do not remove

theprotectivePVClmfromthestainlesssteeluntilafterthis

applicationiscomplete.Oncethelmhasbeenremovedwe

recommendthatthereboxbecleanedwithastainlesssteel

cleaner immediately.

Cleaning Instructions at Installation

Thisreboxisbuiltusingmostlyhigh-gradestainlesssteelto

resist rust-through. In outdoor applications, all stainless steel will

develop a dull patina and, depending on the local environment

and on the materials used in the installation, may develop some

surface oxidation (rust). This does not affect the performance

oftherebox,anddoesnotrequireanyactiontocorrect.Ifyou

preferkeepingyourreboxfrontlookingfactory-fresh,cleanitas

requiredwithstainlesssteelcleaner.

FIREBOX INSTALLATION INSTRUCTIONS

Locating Firebox

Pry the top standoffs up and bend pieces as shown. Attach

free-end to face top with two hex-head screws from hardware

pack.Placereboxinframingopening.Usethetabsontheside

ofthereboxtoattachreboxtoframing.Differenttablocations

canbeusedfornishingmaterialswiththicknessesof1/2inch

and 5/8 inch. See Figure 9.

Framingtabsshouldtdirectlyagainstframingmaterial.Useat

least one nail per bracket to secure in place.

Checksquarenessofthereboxpriortosecuringtoframed

opening. See Figure 10.

FRAMING

TABS

Figure 9

CHECK TO SEE

THAT BOX IS SQUARE

PRIOR TO ATTACHING TO

FRAMING

FIREBOX OPENING

3/4" GAP

REQUIRED

3/8" GAP

REQUIRED

Figure 10

Extended Hoods

Ifthenon-combustiblefacingmaterialusedtonishthereboxis

over 1 inch thick, an extended hood that extends 2 inches farther

into the room is recommended. Contract your Empire Dealer for

details.

VB4H32SS Stainless Steel Extended Hood

VB4H36SS Stainless Steel Extended Hood

VB4H42SS Stainless Steel Extended Hood

FRAMING HARDWARE

NOT INCLUDED

33857-4-0117 Page 13

GAS LINE CONNECTION

ThereboxisdesignedtoacceptagaslineforanANSI

approvedburner.Havethegaslineinstalledbyaqualied

service person in accordance with all building codes. Consult

local building codes to properly size the gas supply line leading

to the hook-up at the installed burner. The Commonwealth of

Massachusettsrequiresthataexiblegasconnectorcannot

exceed three feet in length.

Gasaccessholesareprovidedonbothsidesoftherebox.See

Figure 12. Carefully remove the knockout in the refractory brick

panel using a large standard screwdriver and hammer. First,

place screwdriver in groove next to plug and pry sideways to

pop out main plug. Then remove the remaining concrete in hole

with gentle tapping with ball peen hammer and/or screwdriver. A

masonry drill and bit may also be used to create a clean hole for

the gas line to pass through. See Figure 13.

Afterthebrickpanelknockoutisremoved,thereboxwrapwill

have a round metal knockout that must be removed also. Use a

screwdriver to punch out the metal knockout.

WARNING: CONNECTION DIRECTLY TO AN

UNREGULATED L.P. SUPPLY CAN CAUSE AN EXPLOSION.

Figure 12

TAP AROUND KNOCK-OUT

TO REMOVE

Figure 13

Note: Use caution when removing the brick panel knockouts to

avoid damaging the brick panel.

MAINTENANCE

Vacuum or brush the control compartment at least twice a year.

Follow the maintenance instructions provided with the burner.

33857-4-0117Page 14

PARTS VIEW

PARTS LIST

USE ONLY MANUFACTURER’S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH.

Index No.

Part No.

Description

OP32FB2MF OP36FB2MF OP42FB2MF

1 33847 33848 33849 Face, Bottom

2 33850 33851 33852 Face, Top

3 33853 33854 33854 Face, Side - Right

4 33855 33856 33856 Face, Side - Left

5 R10387 R10391 R10391 Liner, Side - Left

6 R10388 R10392 R10392 Liner, Side - Right

7 R10386 R10390 R10394 Liner, Rear

8 33885 33885 33885 LinerBracket(2required)

9 21117 21162 33609 Hood

10 R11107 R11036 R11037 Curtain,Rod(2required)

11 R11108 R10765 R10765 Curtain,Screen(2required)

12 R11104 R11105 R11106 Liner, Bottom

13 27338 27338 37338 TopLinerBracket(2required)

33857-4-0117 Page 15

To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.

com. To provide warranty service, your dealer will need your name and address, purchase date and serial number, and

thenatureoftheproblemwiththerebox.

To Order Parts After the Warranty Period, please contact your dealer or one of the Master Parts Distributors listed below.

This list changes from time to time. For the current list, please click on the Master Parts button at www.empirecomfort.

com.

Please note: Master Parts Distributors are independent businesses that stock the most commonly ordered Original

EquipmentrepairpartsforHeaters,Grills,andFireboxsmanufacturedbyEmpireComfortSystemsInc.

MASTER PARTS DISTRIBUTOR LIST

Parts Not Under Warranty

Parts can be ordered through your Service Person, Dealer, or a Master Parts Distributor. See this page for the Master Parts Distribu-

tors list. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the

service person/dealer.

Warranty Parts

Warranty parts will need a proof of purchase and can be ordered by your Service Person or Dealer. Proof of purchase is required for

warranty parts.

AllpartslistedinthePartsListhaveaPartNumber.Whenorderingparts,rstobtaintheModelNumberandSerialNumberfromthe

nameplateonyourequipment.ThendeterminethePartNumber(not the Index Number) and the Description of each part from the fol-

lowing illustration and part list. Be sure to give all this information . . .

Appliance Model Number Part Description

Appliance Serial Number Part Number

Type of Gas (Propane or Natural)

Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store.

Shipmentscontingentuponstrikes,resandallcausesbeyondourcontrol.

HOW TO ORDER REPAIR PARTS

Dey Distributing

1401 Willow Lake Boulevard

Vadnais Heights, MN 55101

Phone: 651-490-9191

Toll Free: 800-397-1339

Website: www.deydistributing.com

Parts: Heater, Hearth and Grills

F. W. Webb Company

200 Locust Street

Hartford, CT 06114

Phone: 860-722-2433

Toll Free: 800-243-9360

Fax: 860-293-0479

Toll Free Fax: 800-274-2004

Websites: www.fwwebb.com & www.victormfg.com

Parts: Heater, Hearth and Grills

East Coast Energy Products

10 East Route 36

West Long Branch, NJ 07764

Phone: 732-870-8809

Toll Free: 800-755-8809

Fax: 732-870-8811

Website: www.eastcoastenergy.com

Parts: Heater, Hearth and Grills

33857-4-0117Page 16

WARRANTY TERMS

Empire Comfort Systems Inc. warranties this hearth product to be free from defects at the time of purchase and for the

periodsspeciedbelow.Hearthproductsmustbeinstalledbyaqualiedtechnicianandmustbemaintainedandoperated

safely, in accordance with the instructions in the owner’s manual. This warranty applies to the original purchaser only and

isnottransferable.Allwarrantyrepairsmustbeaccomplishedbyaqualiedgasappliancetechnician.

Limited Five-Year Parts Warranty – All Components

(Except Remote Controls, Accessories and

Replacement Parts)

• Shouldanypartfailbecauseofdefectiveworkmanship

ormaterialwithinveyearsfromthedateofpurchase,

Empire will repair or replace at Empire’s option.

Limited One-Year Parts Warranty – Remote Controls,

Accessories, and Parts

• Shouldanyremotecontrol,accessory,orotherpartfail

because of defective workmanship within one year from

the date of purchase, Empire will repair or replace at

Empire’s option.

Duties of the Owner

• Theappliancemustbeinstalledbyaqualiedinstaller

and operated in accordance with the instructions furnished

with the appliance.

• Abillofsale,cancelledcheck,orpaymentrecordshould

be kept to verify purchase date and establish warranty

period.

• Readyaccesstotheapplianceforservice.

What Is Not Covered

• Damagesthatmightresultfromtheuse,misuse,or

improper installation of this appliance.

• Travel,diagnosticcostsandfreightchargeson

warranted parts to and from the factory.

• Claimsthatdonotinvolvedefectiveworkmanshipor

materials.

• Unauthorizedserviceorpartsreplacements.

• Removalandreinstallationcost.

• Inoperableduetoimproperorlackofmaintenance.

How To Get Service

• Tomakeaclaimunderthiswarranty,pleasehaveyour

receipt available and contact your installing dealer. Provide

the dealer with the model number, serial number, type

ofgas,andpurchaseverication.Theinstallingdealer

is responsible for providing service and will contact the

factory to initiate any warranted parts replacements.

Empire will make replacement parts available at the

factory. Shipping expenses are not covered.

• If,aftercontactingyourEmpiredealer,servicereceived

has not been satisfactory, contact: Consumer Relations

Department, Empire Comfort Systems Inc., PO Box

529, Belleville, Illinois 62222, or send an e-mail to info@

empirecomfort.com with “Consumer Relations” in the

subject line.

Your Rights Under State Law

• Thiswarrantygivesyouspeciclegalrights,andyou

may also have other rights, which vary from state to state.

www.empirecomfort.com

Empire Comfort Systems Inc.

Belleville, IL

Ifyouhaveageneralquestion

about our products, please e-mail

us at [email protected].

If you have a service or repair

question,pleasecontactyourdealer.

White Mountain Hearth OP32FB2MF-3 Owner's manual

Brand: White Mountain Hearth

Model: OP32FB2MF-3

Category: Fireplaces

Type: Owner's manual

Download PDF

report

White Mountain Hearth OP32FB2MF-3 Owner's manual

White Mountain Hearth OP32FB2MF-3 Owner's manual

Related papers

Other documents