© Copyright 2013, Capital Safety
FORM NO: 5903548
REV: A
Instruction Supplement
The Ultimate in Fall Protection
Adjustable Restraint Lanyard SRL Interfaces
Model Numbers: (See Figure 1)
Figure 1 – Nano-Lok Adjustable Restraint Lanyard SRL Interfaces
Nano-Lok SRL
ANSI or CSA Model
(Purchase Separately)
1231075/1231075C
6 ft. (1.8 m) Lanyard
with 9502116 Snap Hook
1231076/1231076C
3 ft. (0.9 m) Lanyard with
2000210 Rebar Hook
1231077/1231077C
6 ft. (1.8 m) Lanyard with
2000210 Rebar Hook
1231078/1231078C
3 ft. (0.9 m) Lanyard
with 9502116 Snap Hook
Figure 2 – Anchorage Connections
A
Restraint
B
Fall Arrest
12 ft
(3.7 m)
A B
The information in this document supplements the
following Product Instruction Manuals:
5903315 ANSI Nano-Lok Self-Retracting Lifelines
5902126 ANSI Web Lanyards, Rope Lanyards,
D-Ring Extensions
5903406 CSA Nano-Lok Self-Retracting Lifelines
5902206 CSA Web Lanyards, Rope Lanyards,
D-Ring Extensions
2
WARNING: This product is part of a Personal Fall Arrest
1
and Restraint
2
system. The user must follow the manufacturer’s instructions for
each component of the system. These instructions must be provided to the user of this equipment. The user must read and understand these
instructions before using this equipment. Manufacturer’s instructions must be followed for proper use and maintenance of this equipment.
Alterations or misuse of this product or failure to follow instructions may result in serious injury or death.
IMPORTANT: If you have questions on the use, care, or suitability of this equipment for your application, contact Capital Safety. For general
questions, refer to national Standards including the ANSI Z359 family of standards on fall protection, ANSI A10.32, and applicable local, state,
and federal (OSHA) requirements governing occupational safety for more information about fall protection systems.
PRODUCT DESCRIPTION:
Figure 1 illustrates the available Nano-Lok
™
Adjustable Restraint Lanyard SRL Interface models. The Nano-Lok Adjustable
Restraint Lanyard SRL Interface combines the Fall Arrest capabilities of a Nano-Lok Self Retracting Lifeline
3
and the Restraint
capabilities of an Adjustable Positioning Lanyard on a Twin Leg Harness Interface that mounts on a Full Body Harness.
Figure 2 illustrates use of the Adjustable Restraint Lanyard SRL Interface as fall protection for Aerial Lift applications. The
Adjustable Positioning Lanyard is used at lower elevations where clearance is insuffi cient to allow locking of the Nano-Lok SRL
if a fall occurs. When properly adjusted, the Lanyard prevents the user’s center of gravity from reaching a fall hazard. Once
elevated to a height of adequate locking clearance, the Nano-Lok SRL allows greater mobility and provides safe fall arrest in the
event of a fall.
INSTALLATION:
IMPORTANT: The O-Ring on the Positioning Lanyard shall only be attached to the Nano-Lok Twin Leg Harness Interface (see Figure 1). Do
not connect the O-Ring to other hooks or connectors, or use the Positioning Lanyard to extend the Nano-lok SRL (see Figure 2). Do not use the
Positioning Lanyard with SRLs other than Nano-Lok SRLs.
1. Mount the Harness Interface on the Full Body Harness and install the Nano-Lok SRL on the Harness Interface as instructed
in the “Nano-Lok Self Retracting Lifelines Instruction Manual”.
IMPORTANT: Harnesses with a fi xed D-Ring require the alternate Twin SRL Fixed D-Ring Harness Interface (3100107).
2. Substitute the Positioning Lanyard for the second Nano-Lok SRL and install on the Harness Interface as instructed.
USE:
Figure 2 illustrates connection and use of the Adjustable Restraint Lanyard SRL Interface:
1. Connect the Snap Hooks on the Nano-Lok SRL and Positioning Lanyard to valid anchorage connection points. See the
associated “Nano-Lok Self Retracting Lifelines Instruction Manual” and “Web Lanyards, Rope Lanyards, D-Ring Extensions
User Instruction Manual” for anchorage and connection requirements.
2. Adjust the length of the Positioning Lanyard to prevent access to all fall hazards.
3. When elevated suffi ciently to allow SRL locking if a fall occurs, disconnect the Positioning Lanyard’s Snap Hook if additional
mobility is needed.
B
4. When lowered to a height insuffi cient for SRL locking, reconnect the Positioning Lanyard’s Snap Hook to its anchorage
connection point.
A
CAUTION: The Positioning Lanyard on this product is not Arc-Flash rated. Do not use in environments where an arc-fl ash (electrical
explosion) could occur.
CSG USA & Latin America
3833 SALA Way
Red Wing, MN 55066-5005
Toll Free: 800.328.6146
Phone: 651.388.8282
Fax: 651.388.5065
solutions@capitalsafety.com
CSG Canada
260 Export Boulevard
Mississauga, ON L5S 1Y9
Phone: 905.795.9333
Toll-Free: 800.387.7484
Fax: 888.387.7484
info.ca@capitalsafety.com
CSG Northern Europe
5a Merse Road
North Moons, Moat
Reditch, Worcestershire, UK
B98 9HL
Phone: + 44 (0)1527 548 000
Fax: + 44 (0)1527 591 000
csgne@capitalsafety.com
CSG EMEA
(Europe, Middle East, Africa)
Le Broc Center
Z.I. 1ère Avenue
5600 M B.P. 15 06511
Carros
Le Broc Cedex
France
Phone: + 33 4 97 10 00 10
Fax: + 33 4 93 08 79 70
information@capitalsafety.com
CSG Australia & New Zealand
95 Derby Street
Silverwater
Sydney NSW 2128
AUSTRALIA
Phone: +(61) 2 8753 7600
Toll-Free : 1 800 245 002 (AUS)
Toll-Free : 0800 212 505 (NZ)
Fax: +(61) 2 87853 7603
sales@capitalsafety.com.au
CSG Asia
Singapore:
16S, Enterprise Road
Singapore 627666
Phone: +65 - 65587758
Fax: +65 - 65587058
inquiry@capitalsafety.com
Shanghai:
Rm 1406, China Venturetech Plaza
819 Nan Jing Xi Rd,
Shanghai 200041, P R China
Phone: +86 21 62539050
Fax: +86 21 62539060
www.capitalsafety.com
1 Fall Arrest: The action or event of stopping a free fall or the instant where the downward free fall has been stopped.
2 Restraint: The technique of securing an authorized person to an anchorage using a lanyard/lifeline short enough to prevent the person’s center of gravity from
reaching the fall hazard.
3 Nano-Lok SRL: The Nano-lok SRL is not included with the Adjustable Restraint Lanyard SRL Interface. It must be purchased separately.
-
1
-
2
3M DBI-SALA® Nano-Lok™ Edge Twin-Leg Quick Connect Self Retracting Lifeline, Cable, 3500231, 8 ft. (2.4m) Operating instructions
- Type
- Operating instructions
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
3M DBI-SALA® Nano-Lok™ Aerial Work Platform Self-Retracting Lifeline, Web 3101655, Blue, 4.5 ft. (1.4m), 1 EA Operating instructions
-
-
-
DBI-SALA DBI-SALA® Nano-Lok™ Twin-Leg Quick Connect Self Retracting Lifeline, Web 3101278 Operating instructions
-
DBI-SALA DBI-SALA® Nano-Lok™ edge Twin-Leg Tie-Back Quick Connect Self Retracting Lifeline - Cable 3500228, Orange, 9 ft. (2.7 m), 1 EA Operating instructions
-
-
-
-
-