Champion Power Equipment 100179 Owner's manual

Brand: Champion Power Equipment

Model: 100179

Category: Power generators

Type: Owner's manual

OPERATOR'S MANUAL

MODEL #100136

12.5-kW HOME STANDBY GENERATOR

Champion Power Equipment, Inc.

or visit championpowerequipment.com

SAVE THESE INSTRUCTIONS. This manual contains important safety precautions which should be read and understood before operating the product. Failure to do

so could result in serious injury. This manual should remain with the product.

Speciﬁcations, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice.

No part of this publication may be reproduced or used in any form by any means – graphic, electronic or mechanical, including photocopying, recording, taping or

information storage and retrieval systems – without the written permission of Champion Power Equipment (CPE).

at championpowerequipment.com

REV 20231107

PROTECT YOUR INVESTMENT!

REGISTRATION REQUIREMENTS

- Full name

- Address where installed

- Phone number

- Email

- Complete model number*

(generator + transfer switch)

- Generator serial number

- Purchase date

- Tshirt size

In exchange for an honest rating and review of your Champion

product, we'll give you a FREE T-SHIRT!

PLUS, GET A FREE T-SHIRT!

www.championpowerequipment.com/HSB-offer

PROMOTIONAL OFFER VALID FOR ONE HOME STANDBY GENERATOR PURCHASE PER HOUSEHOLD. PLEASE ALLOW UP TO A TOTAL OF 15 BUSINESS DAYS FOR YOUR REGISTRATION TO BE

VERIFIED AND FREE ITEMS TO BE MAILED OUT. YOUR 10 YEAR WARRANTY IS ACTIVATED IMMEDIATELY UPON SUBMITTING PRODUCT REGISTRATION THROUGH OUR WEBSITE.

*COMPLETE MODEL NUMBER CAN BE FOUND ON PURCHASE RECEIPT.

FREE

10 YEAR

WARRANTY

Val

ed at $699

Val

ed at $699

Have questions or need assistance?

Do not return this product to the store!

WE ARE HERE TO HELP!

Visit our website:

www.championpowerequipment.com

for more info:

Product Info & Updates

Frequently Asked Questions

Tech Bulletins

– or –

Call our Customer Care Team Toll-Free at:

1-877-338-0999

Product Registration

This manual must be used with Champion Power Equipment (CPE) manuals:

Installation Manual

Transfer Switch Manual

* We are always working to improve our products. Therefore, the enclosed product may differ slightly from the image on the cover.

100136 - 12.5-KW HOME STANDBY GENERATOR TABLE OF CONTENTS

TABLE OF CONTENTS

Introduction ................................................... 5

Home Standby Generator ...............................5

Safety ............................................................5

Safety Deﬁnitions ................................................. 5

Important Safety Instructions .......................6

Carbon Monoxide Hazards ........................................ 6

Installation Hazards ............................................... 7

Before Starting .................................................... 7

Operation Hazards ................................................ 7

Accidental Starting ................................................ 7

Electrical Shock Hazards ......................................... 8

Fire/Explosion Hazards ........................................... 8

Burn Hazards ...................................................... 8

Entanglement Hazards ............................................ 8

Battery Hazards ................................................... 8

Safety Symbols .................................................... 9

Safety Labels and Hang Tags ....................... 11

Safety label and Hang Tag locations ............................ 13

General Information ..................................... 14

Component Identiﬁcation - 12.5-kW Generator ................. 14

Component Identiﬁcation – Engine .............................. 15

Control Panel ..................................................... 15

FCC Statement ................................................... 17

CAN ICES-002/NMB-002 ........................................ 17

Battery Charger .................................................. 18

Emission Requirements .......................................... 18

Speciﬁcations .................................................... 19

Fuel System ......................................................20

Battery Requirements ............................................ 20

Battery Charging ................................................. 21

Model and Serial Number ........................................ 21

Operation .....................................................21

High Altitude ......................................................21

Enclosure and Access ............................................ 21

Pre-Start Checklist ............................................... 21

Turning OFF the Generator .......................................21

Maintenance ................................................22

Scheduled Maintenance Chart ...................................22

Spark Plug Speciﬁcations ........................................ 22

Oil Filter Speciﬁcations ..........................................22

Engine Oil .........................................................22

Changing the Engine Oil ......................................... 23

Inspect and Clean Engine Air Cleaner ...........................23

Spark Plug ........................................................ 23

Battery Maintenance ............................................. 24

Corrosion Protection ............................................. 24

Maintenance After Submersion .................................. 24

Storage ........................................................... 24

Return to Service after Storage ................................. 25

Troubleshooting HSB ...................................26

Additional Information .................................28

Identify/Select Standby Circuits ................................. 28

Surge Protection ................................................. 28

Customer Familiarization Summary ............................. 28

HSB, ATS Model & Serial Reference ATS Back-up Circuits .....29

Maintenance and Service Record ...............................30

FOR PARTS BREAKDOWN

Search by model number at

championpowerequipment.com

100136 - 12.5-KW HOME STANDBY GENERATOR INTRODUCTION

HOME STANDBY GENERATOR

This home standby generator is intended exclusively for outdoor

installation. This generator will operate using either liquiﬁed

petroleum gas (LPG) or natural gas (NG).

This generator is designed to supply typical home load such as:

Induction motors – sump pumps, refrigerators, air conditioners,

furnaces

Electronic items – televisions, computers

Household lighting

Microwaves

This generator is not intended for use in critical life support

applications.

Proper sizing of the generator is required to ensure safe operation

of appliances. Some appliances require additional wattage to start

and must be considered in the sizing of the generator.

SAFETY

Safety Deﬁnitions

The purpose of safety symbols is to attract your attention to

possible dangers. The safety symbols, and their explanations,

deserve your careful attention and understanding. The safety

warnings do not by themselves eliminate any danger. The

instructions or warnings they give are not substitutes for proper

accident prevention measures.

 DANGER

DANGER indicates a hazardous situation which, if not avoided,

will result in death or serious injury.

 WARNING

WARNING indicates a hazardous situation which, if not

avoided, could result in death or serious injury.

 CAUTION

CAUTION indicates a hazardous situation which, if not avoided,

could result in minor or moderate injury.

 NOTICE

NOTICE indicates information considered important, but not

hazard-related (e.g., messages relating to property damage).

INTRODUCTION

Congratulations on your purchase of a Champion Power Equipment

(CPE) product. CPE designs, builds, and supports all of our

products to strict speciﬁcations and guidelines. With proper

product knowledge, safe use, and regular maintenance, this

product should bring years of satisfying service.

Every effort has been made to ensure the accuracy and

completeness of the information in this manual at the time of

publication, and we reserve the right to change, alter and/or

improve the product and this document at any time without prior

notice.

CPE highly values how our products are designed, manufactured,

operated, and serviced as well as providing safety to the operator

and those around the generator. Therefore, it is IMPORTANT to

review this product manual and other product materials thoroughly

and be fully aware and knowledgeable of the assembly, operation,

dangers and maintenance of the product before use. Fully

familiarize yourself, and make sure others who plan on operating

the product fully familiarize themselves too, with the proper safety

and operation procedures before each use. Please always exercise

common sense and always err on the side of caution when

operating the product to ensure no accident, property damage,

or injury occurs. We want you to continue to use and be satisﬁed

with your CPE product for years to come.

When contacting CPE about parts and/or service, you will need to

supply the complete model and serial numbers of your product.

Transcribe the information found on your product’s nameplate

label to the table below

CPE TECHNICAL SUPPORT TEAM

1-877-338-0999

MODEL NUMBER

100136

SERIAL NUMBER

DATE OF PURCHASE

PURCHASE LOCATION

100136 - 12.5-KW HOME STANDBY GENERATOR IMPORTANT SAFETY INSTRUCTIONS

IMPORTANT SAFETY INSTRUCTIONS

 WARNING

Cancer and Reproductive Harm – www.P65Warnings.ca.gov

Carbon Monoxide Hazards

 DANGER

Generator exhaust contains carbon monoxide, a colorless,

odorless, poisonous gas. Breathing carbon monoxide will

cause nausea, dizziness, fainting or death. If you start to feel

dizzy or weak, get to fresh air immediately.

GENERATOR MUST BE INSTALLED AND OPERATED

OUTDOORS ONLY.

Carbon monoxide (CO) poisoning symptoms include but are not

limited to the following:

Lightheadedness, dizziness, blurred vision

Physical fatigue, weakness in joints and muscles

Mental fatigue, sleepiness, inability to concentrate or

speak clearly,

Stomachache, vomiting, nausea

In the event of carbon monoxide (CO) poisoning:

Seek fresh air immediately

DO NOT sit, lie down or fall asleep.

Alert others to the possibility of carbon monoxide (CO)

poisoning.

If the affected person does not improve within minutes

of breathing fresh air, call 911 immediately for medical

assistance.

 DANGER

Carbon Monoxide (CO) is a colorless, odorless, poisonous

gas. Breathing carbon monoxide will cause nausea, dizziness,

fainting or death.

Generator must be installed and operated outdoors only.

NEVER allow exhaust fumes to enter a conﬁned area through

windows, doors, air intake vents or other openings of the

building

ALWAYS avoid breathing exhaust fumes when near an

operating generator.

NEVER alter the generator or modify the exhaust system

thereby creating noncompliance with Federal and State

emissions regulations, local applicable codes, standards and

laws.

NEVER allow blockage of the engine’s air intake cooling

ventilation system. Doing so can seriously affect performance

and safe operation of the generator.

Always install a battery-operated carbon monoxide (CO)

detector on each level of any building adjacent to the generator

location following the manufacturer’s CO detector installation

instructions.

 WARNING

In many U.S. States it is required by law to have a Carbon

Monoxide (CO) detector in an occupied home or dwelling. It is

strongly recommended that a Carbon Monoxide (CO) detector

be installed on each level of any private dwelling or building in

operating condition.

A Carbon Monoxide (CO) detector is a device that detects elevated

hazardous levels of poisonous CO and will alert the occupants by

ﬂashing a visual light indicator and an audible alarm.

 WARNING

Do not use generator for medical life support uses.

In case of emergency, call 911 immediately.

NEVER use this product to power life support devices or life

support appliances.

Inform your electricity provider immediately if you or anyone in

your household depends on electrical equipment to live.

Inform your electrical provider immediately if a loss of power

would cause you or anyone in your household to experience a

medical emergency.

100136 - 12.5-KW HOME STANDBY GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Installation Hazards

 WARNING

Always have a qualiﬁed electrician or installation technician

who are familiar with applicable safety codes, standards and

regulations install and service the generator.

ALWAYS comply with local, state and national electrical and

building codes when installing the generator.

NEVER alter the recommended installation in a way that would

render the unit non compliant with these codes.

ALWAYS comply with regulations that Occupational Safety and

Health Administration (OSHA) has established.

Always follow the generator manufacturer’s instructions.

Before Starting

 WARNING

Before operation, read and understand the features and

controls of the generator, including the safety and maintenance

sections of this manual.

The owner/operator is responsible for all periodic maintenance.

Complete all scheduled maintenance in a timely manner.

Correct any issue before operating the generator.

The owner/operator is responsible for the safe operation of this

generator.

If any portion of this manual is not understood, contact

your Champion dealer for assistance before operating the

generator.

For service or parts assistance, contact your Champion dealer

if repairs are needed.

NEVER climb or step on any part or components of the

generator. Doing so may result in personal injury and cause

damage to the exhaust system and/or create leakage to the

fuel system.

Operation Hazards

 WARNING

ALWAYS operate the generator following the manufacturer’s

instructions. Operating the generator improperly or neglecting

maintenance can result in serious injury or possible death.

DO NOT allow children or unqualiﬁed persons to operate or

service the generator.

NEVER operate the generator with the covers open. Only

operate the generator with the covers closed and secured in

place.

NEVER leave the generator covers unlocked.

NEVER work on the generator when physically or mentally

fatigued. Remain alert at all times when working on the

generator.

NEVER operate the generator while under the inﬂuence of

alcohol or drugs.

Accidental Starting

 WARNING

ALWAYS prevent the generator from starting while the covers

are open. The generator may crank and start at any time

without notice. Follow these steps in order:

1. Turn the exercise switch to the OFF position.

2. Switch the main circuit breaker to the OFF position.

3. Turn the ATS control module to the OFF position.

4. Turn the engine control module switch to the OFF position.

5. Disconnect the NEGATIVE, NEG or (-) battery cable ﬁrst,

and then remove the POSITIVE, POS or (+) battery cable.

To return the generator to service, follow these steps in order:

1. Connect the POSITIVE, POS or (+) battery cable ﬁrst, and

then connect the NEGATIVE, NEG or (-) battery cable.

2. Turn the engine control module switch to the ATS position.

3. Turn the ATS control module switch to the AUTO position.

4. Switch the main circuit breaker to the ON position.

5. Turn the exercise switch to the ON position..

100136 - 12.5-KW HOME STANDBY GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Electrical Shock Hazards

 WARNING

Use extreme caution when near the generator while it is

operating. The generator produces dangerous voltage.

Avoid contact with bare wires, terminals and connections while

the generator is operating.

ALWAYS stand on an insulated dry surface to reduce shock

hazard if work must be done on an operating generator.

NEVER wear jewelry that can conduct electricity when working

on the generator.

NEVER handle any kind of electrical device while hands or feet

are wet, while standing in water or while barefoot.

Proper earth grounding of the frame and external electrical

conductive components is required by the National Electrical

Code (NEC). State and local codes for proper grounding may

also apply.

Avoid direct contact with an electric shock victim. Immediately

shut down the source of electrical power. If this is not possible,

attempt to free the victim from the live conductor using a

nonconducting item such as a dry board or rope. If the victim

is unconscious, apply ﬁrst aid and call 911 immediately.

Fire/Explosion Hazards

 WARNING

Natural Gas (NG) and Liquiﬁed Petroleum Gas (LPG) and their

vapors are extremely explosive.

NEVER allow any ﬂames or smoke near the fuel system.

Wipe up any oil spills immediately.

NEVER allow any combustible materials to be near the

generator or to be left in the generator compartment.

ALWAYS keep the surrounding area near the generator clean

and free of debris.

Be sure to properly purge the fuel lines and leak-test according

to applicable codes before placing the generator in service.

Be sure to regularly inspect the fuel system for leaks. NEVER

operate the generator if a fuel leak is present.

Install a ﬁre extinguisher near the generator. Keep it properly

charged and be familiar with its use. An ABC rated National

Fire Protection extinguisher is appropriate for use on standby

electric systems. Contact your local ﬁre department with any

questions concerning the ﬁre extinguisher.

Burn Hazards

 WARNING

DO NOT touch hot surfaces.

ALWAYS avoid contact with hot exhaust components and

gases. Running engines produce heat. Severe burns can occur

on contact.

ALWAYS allow hot surfaces to cool to the touch.

Entanglement Hazards

 WARNING

Use extreme caution when near rotating parts. Rotating parts

can entangle hands, feet, hair, clothing and/or accessories.

Traumatic amputation or severe laceration can result.

Keep hands and feet away from rotating parts.

Tie up long hair and remove jewelry.

Operate equipment with guards in place.

DO NOT wear loose-ﬁtting clothing, dangling drawstrings or

items that could become caught.

Battery Hazards

 WARNING

Always read and comply with the battery

manufacturer’s recommendations for

procedures concerning proper battery use

and maintenance.

Batteries contain sulfuric acid and generate

explosive mixtures of hydrogen and oxygen

gases. Keep any device that may cause

sparks or ﬂames away from the battery to

prevent explosion.

Always wear protective glasses or goggles

and protective clothing when working with

batteries. You must follow the battery

manufacturer’s instructions on safety,

maintenance and installation procedures.

100136 - 12.5-KW HOME STANDBY GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Safety Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these

symbols will allow you to more safely operate the product.

SYMBOL MEANING

Read Operator’s Manual. To reduce the risk of injury, user must read and understand operator’s manual

before using this product.

Eye protection. Always wear eye protection with side shields marked to comply with ANSI Z87.1

Wear personal protective equipment

Safety alert symbol

Asphyxiation hazard

Electrical shock hazard

Entanglement hazard

Fire hazard

Fire/Explosion. Fuel and its vapors are extremely ﬂammable and explosive. Fire or explosion can cause

severe burns or death.

Hot Surface. To reduce the risk of injury or damage, avoid contact with any hot surface.

100136 - 12.5-KW HOME STANDBY GENERATOR IMPORTANT SAFETY INSTRUCTIONS

SYMBOL MEANING

Sever hazard (rotating blade)

Crush hazard (top)

100136 - 12.5-KW HOME STANDBY GENERATOR SAFETY LABELS AND HANG TAGS

SAFETY LABELS AND HANG TAGS

 WARNING

DO NOT operate the generator if there are missing or badly

worn safety labels. Safety labels must be legible to alert

personnel of safety hazards.

Replace any illegible or missing label immediately. Missing

safety labels must be replaced in their original position before

the generator is operated.

Labels

LABEL DESCRIPTION PART NO.

Burn Hazard DO NOT

touch hot surfaces. Allow

the engine and alternator

to cool to the touch

before servicing.

Danger de brulure NE

TOUCHEZ PAS les

surfaces chaudes.

Laissez le moteur et

l’alternateur devenir froid

au toucher avant

d’intervenir.

Riesgo de quemaduras

NO toque las superficies

calientes. Deje que el

motor y el alternador se

enfríen para tocarlos

antes de realizarles el

mantenimiento. 100794

100789

Electrical Shock Hazard ALWAYS

close and lock generator covers before

operating. The generator produces

dangerous voltage.

Risque de choc électrique Fermez et

verrouillez TOUJOURS les capots de

groupe électrogène avant d’utiliser le

groupe. Le groupe électrogène génère

des tensions dangereuses.

Riesgo de descarga eléctrica

SIEMPRE cierre y trabe las tapas del

generador antes de ponerlo en

funcionamiento. El generador produce

un voltaje peligroso.

101045

Electrical Shock Hazard

Do not remove this access panel. The panel

should only be removed by an authorized

Service Dealer or a qualified electrician;

high voltage inside.

Risque de choc électrique

Riesgo de descarga eléctrica

N’enlevez pas ce panneau d’accès.

Le panneau ne devrait être enlevé que par

un concessionnaire d’entretien agréé ou un

électricien qualifié ; haute tension à l’intérieur.

No remueva este tablero de acceso. El tablero

sólo deberá ser removido por un distribuidor

de servicio autorizado o un electricista

calificado; alto voltaje al interior.

101051

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases.

101500

101499

101045

101051 100789

100794

4 5

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases.

101500

Fire Hazard ALWAYS keep the surrounding

area near generator clean and free of debris

and/or dry vegetation. The generator may

create sparks while operating.

Risque d’incendie Nettoyez TOUJOURS la

surface à proximité du groupe électrogène et

enlevez les débris et/ou la végétation sèche.

Le groupe électrogène peut générer des

étincelles pendant son fonctionnement.

Riesgo de incendio SIEMPRE mantenga el

área circundante cerca del generador limpia y

libre de escombros y/o vegetación seca. El

generador puede crear chispas mientras está

en funcionamiento.

Poisonous Gas Hazard Generator exhaust

contains carbon monoxide. Breathing carbon

monoxide will cause nausea, dizziness, and

fainting, and it may cause death.

Risque d’empoisonnement par le gaz Les gaz

d’échappement de groupe électrogène contiennent

du monoxyde de carbone. Si l’on respire du

monoxyde de carbone, ceci peut provoquer des

nausées, un évanouissement et une perte de

conscience, et ceci peut provoquer la mort.

Riesgo de gas venenoso El escape del

generador contiene monóxido de carbono. Aspirar

monóxido de carbono causará náuseas, mareos,

desvanecimiento y hasta la muerte.

Read Operator’s Manual Read,

understand and follow all safety

messages in Installation and Operator’s

manuals.

Lisez le manuel d’utilisation Lisez,

comprenez bien et respectez tous les

messages de sécurité dans les manuels

d’installation et d’utilisation.

Lea el manual del operador Lea,

comprenda y siga todos los mensajes

de seguridad en los manuales de

instalación y del operador.

Starting Hazard The generator may crank and

start at any time without notice. Prevent the

generator from starting while the covers are open.

See the safety section of the operator’s manual for

further detail.

Risque au démarrage Le groupe électrogène

peut tourner et démarrer à tout moment sans

préavis. Ne démarrez pas le groupe électrogène

lorsque les capots sont ouverts. Consultez la

section sécurité du manuel d’utilisation pour plus

de détail.

Riesgo de inicio El generador puede encenderse

y ponerse en marcha en cualquier momento sin

previo aviso. Evite que el generador se ponga en

marcha mientras las tapas están abiertas. Vea la

sección de seguridad en el manual del operador

para más detalles. 101499

Explosion Hazard Battery gases are explosive.

Keep sparks and flames away from the battery

compartment.

Risque d’explosion Les gaz dégagés par la

batterie peuvent exploser. Ecartez les étincelles

et les flammes du compartiment batterie.

Riesgo de explosión Los gases de las baterías

son explosivos. Mantenga las chispas y llamas

alejadas del compartimento de las baterías.

Poison, Burn and Fire

Warning 101500

Burn Hazard DO NOT

touch hot surfaces. Allow

the engine and alternator

to cool to the touch

before servicing.

Danger de brulure NE

TOUCHEZ PAS les

surfaces chaudes.

Laissez le moteur et

l’alternateur devenir froid

au toucher avant

d’intervenir.

Riesgo de quemaduras

NO toque las superficies

calientes. Deje que el

motor y el alternador se

enfríen para tocarlos

antes de realizarles el

mantenimiento. 100794

100789

Electrical Shock Hazard ALWAYS

close and lock generator covers before

operating. The generator produces

dangerous voltage.

Risque de choc électrique Fermez et

verrouillez TOUJOURS les capots de

groupe électrogène avant d’utiliser le

groupe. Le groupe électrogène génère

des tensions dangereuses.

Riesgo de descarga eléctrica

SIEMPRE cierre y trabe las tapas del

generador antes de ponerlo en

funcionamiento. El generador produce

un voltaje peligroso.

101045

Electrical Shock Hazard

Do not remove this access panel. The panel

should only be removed by an authorized

Service Dealer or a qualified electrician;

high voltage inside.

Risque de choc électrique

Riesgo de descarga eléctrica

N’enlevez pas ce panneau d’accès.

Le panneau ne devrait être enlevé que par

un concessionnaire d’entretien agréé ou un

électricien qualifié ; haute tension à l’intérieur.

No remueva este tablero de acceso. El tablero

sólo deberá ser removido por un distribuidor

de servicio autorizado o un electricista

calificado; alto voltaje al interior.

101051

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases.

101500

101499

101045

101051 100789

100794

4 5

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases. 101500

Fire Hazard ALWAYS keep the surrounding

area near generator clean and free of debris

and/or dry vegetation. The generator may

create sparks while operating.

Risque d’incendie Nettoyez TOUJOURS la

surface à proximité du groupe électrogène et

enlevez les débris et/ou la végétation sèche.

Le groupe électrogène peut générer des

étincelles pendant son fonctionnement.

Riesgo de incendio SIEMPRE mantenga el

área circundante cerca del generador limpia y

libre de escombros y/o vegetación seca. El

generador puede crear chispas mientras está

en funcionamiento.

Poisonous Gas Hazard Generator exhaust

contains carbon monoxide. Breathing carbon

monoxide will cause nausea, dizziness, and

fainting, and it may cause death.

Risque d’empoisonnement par le gaz Les gaz

d’échappement de groupe électrogène contiennent

du monoxyde de carbone. Si l’on respire du

monoxyde de carbone, ceci peut provoquer des

nausées, un évanouissement et une perte de

conscience, et ceci peut provoquer la mort.

Riesgo de gas venenoso El escape del

generador contiene monóxido de carbono. Aspirar

monóxido de carbono causará náuseas, mareos,

desvanecimiento y hasta la muerte.

Read Operator’s Manual Read,

understand and follow all safety

messages in Installation and Operator’s

manuals.

Lisez le manuel d’utilisation Lisez,

comprenez bien et respectez tous les

messages de sécurité dans les manuels

d’installation et d’utilisation.

Lea el manual del operador Lea,

comprenda y siga todos los mensajes

de seguridad en los manuales de

instalación y del operador.

Starting Hazard The generator may crank and

start at any time without notice. Prevent the

generator from starting while the covers are open.

See the safety section of the operator’s manual for

further detail.

Risque au démarrage Le groupe électrogène

peut tourner et démarrer à tout moment sans

préavis. Ne démarrez pas le groupe électrogène

lorsque les capots sont ouverts. Consultez la

section sécurité du manuel d’utilisation pour plus

de détail.

Riesgo de inicio El generador puede encenderse

y ponerse en marcha en cualquier momento sin

previo aviso. Evite que el generador se ponga en

marcha mientras las tapas están abiertas. Vea la

sección de seguridad en el manual del operador

para más detalles. 101499

Explosion Hazard Battery gases are explosive.

Keep sparks and flames away from the battery

compartment.

Risque d’explosion Les gaz dégagés par la

batterie peuvent exploser. Ecartez les étincelles

et les flammes du compartiment batterie.

Riesgo de explosión Los gases de las baterías

son explosivos. Mantenga las chispas y llamas

alejadas del compartimento de las baterías.

Burn Warning 100794

Burn Hazard DO NOT

touch hot surfaces. Allow

the engine and alternator

to cool to the touch

before servicing.

Danger de brulure NE

TOUCHEZ PAS les

surfaces chaudes.

Laissez le moteur et

l’alternateur devenir froid

au toucher avant

d’intervenir.

Riesgo de quemaduras

NO toque las superficies

calientes. Deje que el

motor y el alternador se

enfríen para tocarlos

antes de realizarles el

mantenimiento. 100794

100789

Electrical Shock Hazard ALWAYS

close and lock generator covers before

operating. The generator produces

dangerous voltage.

Risque de choc électrique Fermez et

verrouillez TOUJOURS les capots de

groupe électrogène avant d’utiliser le

groupe. Le groupe électrogène génère

des tensions dangereuses.

Riesgo de descarga eléctrica

SIEMPRE cierre y trabe las tapas del

generador antes de ponerlo en

funcionamiento. El generador produce

un voltaje peligroso.

101045

Electrical Shock Hazard

Do not remove this access panel. The panel

should only be removed by an authorized

Service Dealer or a qualified electrician;

high voltage inside.

Risque de choc électrique

Riesgo de descarga eléctrica

N’enlevez pas ce panneau d’accès.

Le panneau ne devrait être enlevé que par

un concessionnaire d’entretien agréé ou un

électricien qualifié ; haute tension à l’intérieur.

No remueva este tablero de acceso. El tablero

sólo deberá ser removido por un distribuidor

de servicio autorizado o un electricista

calificado; alto voltaje al interior.

101051

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases.

101500

101499

101045

101051 100789

100794

4 5

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases. 101500

Fire Hazard ALWAYS keep the surrounding

area near generator clean and free of debris

and/or dry vegetation. The generator may

create sparks while operating.

Risque d’incendie Nettoyez TOUJOURS la

surface à proximité du groupe électrogène et

enlevez les débris et/ou la végétation sèche.

Le groupe électrogène peut générer des

étincelles pendant son fonctionnement.

Riesgo de incendio SIEMPRE mantenga el

área circundante cerca del generador limpia y

libre de escombros y/o vegetación seca. El

generador puede crear chispas mientras está

en funcionamiento.

Poisonous Gas Hazard Generator exhaust

contains carbon monoxide. Breathing carbon

monoxide will cause nausea, dizziness, and

fainting, and it may cause death.

Risque d’empoisonnement par le gaz Les gaz

d’échappement de groupe électrogène contiennent

du monoxyde de carbone. Si l’on respire du

monoxyde de carbone, ceci peut provoquer des

nausées, un évanouissement et une perte de

conscience, et ceci peut provoquer la mort.

Riesgo de gas venenoso El escape del

generador contiene monóxido de carbono. Aspirar

monóxido de carbono causará náuseas, mareos,

desvanecimiento y hasta la muerte.

Read Operator’s Manual Read,

understand and follow all safety

messages in Installation and Operator’s

manuals.

Lisez le manuel d’utilisation Lisez,

comprenez bien et respectez tous les

messages de sécurité dans les manuels

d’installation et d’utilisation.

Lea el manual del operador Lea,

comprenda y siga todos los mensajes

de seguridad en los manuales de

instalación y del operador.

Starting Hazard The generator may crank and

start at any time without notice. Prevent the

generator from starting while the covers are open.

See the safety section of the operator’s manual for

further detail.

Risque au démarrage Le groupe électrogène

peut tourner et démarrer à tout moment sans

préavis. Ne démarrez pas le groupe électrogène

lorsque les capots sont ouverts. Consultez la

section sécurité du manuel d’utilisation pour plus

de détail.

Riesgo de inicio El generador puede encenderse

y ponerse en marcha en cualquier momento sin

previo aviso. Evite que el generador se ponga en

marcha mientras las tapas están abiertas. Vea la

sección de seguridad en el manual del operador

para más detalles. 101499

Explosion Hazard Battery gases are explosive.

Keep sparks and flames away from the battery

compartment.

Risque d’explosion Les gaz dégagés par la

batterie peuvent exploser. Ecartez les étincelles

et les flammes du compartiment batterie.

Riesgo de explosión Los gases de las baterías

son explosivos. Mantenga las chispas y llamas

alejadas del compartimento de las baterías.

Electrocution Warning 101045

Burn Hazard DO NOT

touch hot surfaces. Allow

the engine and alternator

to cool to the touch

before servicing.

Danger de brulure NE

TOUCHEZ PAS les

surfaces chaudes.

Laissez le moteur et

l’alternateur devenir froid

au toucher avant

d’intervenir.

Riesgo de quemaduras

NO toque las superficies

calientes. Deje que el

motor y el alternador se

enfríen para tocarlos

antes de realizarles el

mantenimiento. 100794

100789

Electrical Shock Hazard ALWAYS

close and lock generator covers before

operating. The generator produces

dangerous voltage.

Risque de choc électrique Fermez et

verrouillez TOUJOURS les capots de

groupe électrogène avant d’utiliser le

groupe. Le groupe électrogène génère

des tensions dangereuses.

Riesgo de descarga eléctrica

SIEMPRE cierre y trabe las tapas del

generador antes de ponerlo en

funcionamiento. El generador produce

un voltaje peligroso.

101045

Electrical Shock Hazard

Do not remove this access panel. The panel

should only be removed by an authorized

Service Dealer or a qualified electrician;

high voltage inside.

Risque de choc électrique

Riesgo de descarga eléctrica

N’enlevez pas ce panneau d’accès.

Le panneau ne devrait être enlevé que par

un concessionnaire d’entretien agréé ou un

électricien qualifié ; haute tension à l’intérieur.

No remueva este tablero de acceso. El tablero

sólo deberá ser removido por un distribuidor

de servicio autorizado o un electricista

calificado; alto voltaje al interior.

101051

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras

NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases.

101500

101499

101045

101051 100789

100794

4 5

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases. 101500

Fire Hazard ALWAYS keep the surrounding

area near generator clean and free of debris

and/or dry vegetation. The generator may

create sparks while operating.

Risque d’incendie Nettoyez TOUJOURS la

surface à proximité du groupe électrogène et

enlevez les débris et/ou la végétation sèche.

Le groupe électrogène peut générer des

étincelles pendant son fonctionnement.

Riesgo de incendio SIEMPRE mantenga el

área circundante cerca del generador limpia y

libre de escombros y/o vegetación seca. El

generador puede crear chispas mientras está

en funcionamiento.

Poisonous Gas Hazard Generator exhaust

contains carbon monoxide. Breathing carbon

monoxide will cause nausea, dizziness, and

fainting, and it may cause death.

Risque d’empoisonnement par le gaz Les gaz

d’échappement de groupe électrogène contiennent

du monoxyde de carbone. Si l’on respire du

monoxyde de carbone, ceci peut provoquer des

nausées, un évanouissement et une perte de

conscience, et ceci peut provoquer la mort.

Riesgo de gas venenoso El escape del

generador contiene monóxido de carbono. Aspirar

monóxido de carbono causará náuseas, mareos,

desvanecimiento y hasta la muerte.

Read Operator’s Manual Read,

understand and follow all safety

messages in Installation and Operator’s

manuals.

Lisez le manuel d’utilisation Lisez,

comprenez bien et respectez tous les

messages de sécurité dans les manuels

d’installation et d’utilisation.

Lea el manual del operador Lea,

comprenda y siga todos los mensajes

de seguridad en los manuales de

instalación y del operador.

Starting Hazard The generator may crank and

start at any time without notice. Prevent the

generator from starting while the covers are open.

See the safety section of the operator’s manual for

further detail.

Risque au démarrage Le groupe électrogène

peut tourner et démarrer à tout moment sans

préavis. Ne démarrez pas le groupe électrogène

lorsque les capots sont ouverts. Consultez la

section sécurité du manuel d’utilisation pour plus

de détail.

Riesgo de inicio El generador puede encenderse

y ponerse en marcha en cualquier momento sin

previo aviso. Evite que el generador se ponga en

marcha mientras las tapas están abiertas. Vea la

sección de seguridad en el manual del operador

para más detalles. 101499

Explosion Hazard Battery gases are explosive.

Keep sparks and flames away from the battery

compartment.

Risque d’explosion Les gaz dégagés par la

batterie peuvent exploser. Ecartez les étincelles

et les flammes du compartiment batterie.

Riesgo de explosión Los gases de las baterías

son explosivos. Mantenga las chispas y llamas

alejadas del compartimento de las baterías.

Burn Warning 101051

Burn Hazard DO NOT

touch hot surfaces. Allow

the engine and alternator

to cool to the touch

before servicing.

Danger de brulure NE

TOUCHEZ PAS les

surfaces chaudes.

Laissez le moteur et

l’alternateur devenir froid

au toucher avant

d’intervenir.

Riesgo de quemaduras

NO toque las superficies

calientes. Deje que el

motor y el alternador se

enfríen para tocarlos

antes de realizarles el

mantenimiento. 100794

100789

Electrical Shock Hazard ALWAYS

close and lock generator covers before

operating. The generator produces

dangerous voltage.

Risque de choc électrique Fermez et

verrouillez TOUJOURS les capots de

groupe électrogène avant d’utiliser le

groupe. Le groupe électrogène génère

des tensions dangereuses.

Riesgo de descarga eléctrica

SIEMPRE cierre y trabe las tapas del

generador antes de ponerlo en

funcionamiento. El generador produce

un voltaje peligroso.

101045

Electrical Shock Hazard

Do not remove this access panel. The panel

should only be removed by an authorized

Service Dealer or a qualified electrician;

high voltage inside.

Risque de choc électrique

Riesgo de descarga eléctrica

N’enlevez pas ce panneau d’accès.

Le panneau ne devrait être enlevé que par

un concessionnaire d’entretien agréé ou un

électricien qualifié ; haute tension à l’intérieur.

No remueva este tablero de acceso. El tablero

sólo deberá ser removido por un distribuidor

de servicio autorizado o un electricista

calificado; alto voltaje al interior.

101051

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases.

101500

101499

101045

101051 100789

100794

4 5

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases. 101500

Fire Hazard ALWAYS keep the surrounding

area near generator clean and free of debris

and/or dry vegetation. The generator may

create sparks while operating.

Risque d’incendie Nettoyez TOUJOURS la

surface à proximité du groupe électrogène et

enlevez les débris et/ou la végétation sèche.

Le groupe électrogène peut générer des

étincelles pendant son fonctionnement.

Riesgo de incendio SIEMPRE mantenga el

área circundante cerca del generador limpia y

libre de escombros y/o vegetación seca. El

generador puede crear chispas mientras está

en funcionamiento.

Poisonous Gas Hazard Generator exhaust

contains carbon monoxide. Breathing carbon

monoxide will cause nausea, dizziness, and

fainting, and it may cause death.

Risque d’empoisonnement par le gaz Les gaz

d’échappement de groupe électrogène contiennent

du monoxyde de carbone. Si l’on respire du

monoxyde de carbone, ceci peut provoquer des

nausées, un évanouissement et une perte de

conscience, et ceci peut provoquer la mort.

Riesgo de gas venenoso El escape del

generador contiene monóxido de carbono. Aspirar

monóxido de carbono causará náuseas, mareos,

desvanecimiento y hasta la muerte.

Read Operator’s Manual Read,

understand and follow all safety

messages in Installation and Operator’s

manuals.

Lisez le manuel d’utilisation Lisez,

comprenez bien et respectez tous les

messages de sécurité dans les manuels

d’installation et d’utilisation.

Lea el manual del operador Lea,

comprenda y siga todos los mensajes

de seguridad en los manuales de

instalación y del operador.

Starting Hazard The generator may crank and

start at any time without notice. Prevent the

generator from starting while the covers are open.

See the safety section of the operator’s manual for

further detail.

Risque au démarrage Le groupe électrogène

peut tourner et démarrer à tout moment sans

préavis. Ne démarrez pas le groupe électrogène

lorsque les capots sont ouverts. Consultez la

section sécurité du manuel d’utilisation pour plus

de détail.

Riesgo de inicio El generador puede encenderse

y ponerse en marcha en cualquier momento sin

previo aviso. Evite que el generador se ponga en

marcha mientras las tapas están abiertas. Vea la

sección de seguridad en el manual del operador

para más detalles. 101499

Explosion Hazard Battery gases are explosive.

Keep sparks and flames away from the battery

compartment.

Risque d’explosion Les gaz dégagés par la

batterie peuvent exploser. Ecartez les étincelles

et les flammes du compartiment batterie.

Riesgo de explosión Los gases de las baterías

son explosivos. Mantenga las chispas y llamas

alejadas del compartimento de las baterías.

Electrocution Warning 100789

100136 - 12.5-KW HOME STANDBY GENERATOR SAFETY LABELS AND HANG TAGS

LABEL DESCRIPTION PART NO.

Burn Hazard DO NOT

touch hot surfaces. Allow

the engine and alternator

to cool to the touch

before servicing.

Danger de brulure NE

TOUCHEZ PAS les

surfaces chaudes.

Laissez le moteur et

l’alternateur devenir froid

au toucher avant

d’intervenir.

Riesgo de quemaduras

NO toque las superficies

calientes. Deje que el

motor y el alternador se

enfríen para tocarlos

antes de realizarles el

mantenimiento. 100794

100789

Electrical Shock Hazard ALWAYS

close and lock generator covers before

operating. The generator produces

dangerous voltage.

Risque de choc électrique Fermez et

verrouillez TOUJOURS les capots de

groupe électrogène avant d’utiliser le

groupe. Le groupe électrogène génère

des tensions dangereuses.

Riesgo de descarga eléctrica

SIEMPRE cierre y trabe las tapas del

generador antes de ponerlo en

funcionamiento. El generador produce

un voltaje peligroso.

101045

Electrical Shock Hazard

Do not remove this access panel. The panel

should only be removed by an authorized

Service Dealer or a qualified electrician;

high voltage inside.

Risque de choc électrique

Riesgo de descarga eléctrica

N’enlevez pas ce pan neau d’accès .

Le panneau ne devrait être enlevé que par

un concess ionnaire d’entretien agréé ou un

électricien qualifié ; hau te tens ion à l’intérieur.

No remueva este tablero de acceso. El tablero

sólo deberá ser removido por un distribuidor

de servicio autorizado o un electricista

calificado; alto voltaje al interior.

101051

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases.

101500

101499

101045

101051 100789

100794

4 5

Burn Hazard DO NOT touch hot

surfaces. Avoid contact with

exhaust components and gases.

Risque de brûlure NE touchez

PAS les surfaces chaudes. Evitez

le contact avec les composants et

les gaz d’échappement.

Riesgo de quemaduras NO toque

las superficies calientes. Evite el

contacto con los componentes de

escape y gases. 101500

Fire Hazard ALWAYS keep the surrounding

area near generator clean and free of debris

and/or dry vegetation. The generator may

create sparks while operating.

Risque d’incendie Nettoyez TOUJOURS la

surface à proximité du groupe électrogène et

enlevez les débris et/ou la végétation sèche.

Le groupe électrogène peut générer des

étincelles pendant son fonctionnement.

Riesgo de incendio SIEMPRE mantenga el

área circundante cerca del generador limpia y

libre de escombros y/o vegetación seca. El

generador puede crear chispas mientras está

en funcionamiento.

Poisonous Gas Hazard Generator exhaust

contains carbon monoxide. Breathing carbon

monoxide will cause nausea, dizziness, and

fainting, and it may cause death.

Risque d’empoisonnement par le gaz Les gaz

d’échappement de groupe électrogène contiennent

du monoxyde de carbone. Si l’on respire du

monoxyde de carbone, ceci peut provoquer des

nausées, un évanouissement et une perte de

conscience, et ceci peut provoquer la mort.

Riesgo de gas venenoso El escape del

generador contiene monóxido de carbono. Aspirar

monóxido de carbono causará náuseas, mareos,

desvanecimiento y hasta la muerte.

Read Operator’s Manual Read,

understand and follow all safety

messages in Installation and Operator’s

manuals.

Lisez le manuel d’utilisation Lisez,

comprenez bien et respectez tous les

messages de sécurité dans les manuels

d’installation et d’utilisation.

Lea el manual del operador Lea,

comprenda y siga todos los mensajes

de seguridad en los manuales de

instalación y del operador.

Starting Hazard The generator may crank and

start at any time without notice. Prevent the

generator from starting while the covers are open.

See the safety section of the operator’s manual for

further detail.

Risque au démarrage Le groupe électrogène

peut tourner et démarrer à tout moment sans

préavis. Ne démarrez pas le groupe électrogène

lorsque les capots sont ouverts. Consultez la

section sécurité du manuel d’utilisation pour plus

de détail.

Riesgo de inicio El generador puede encenderse

y ponerse en marcha en cualquier momento sin

previo aviso. Evite que el generador se ponga en

marcha mientras las tapas están abiertas. Vea la

sección de seguridad en el manual del operador

para más detalles. 101499

Explosion Hazard Battery gases are explosive.

Keep sparks and flames away from the battery

compartment.

Risque d’explosion Les gaz dégagés par la

batterie peuvent exploser. Ecartez les étincelles

et les flammes du compartiment batterie.

Riesgo de explosión Los gases de las baterías

son explosivos. Mantenga las chispas y llamas

alejadas del compartimento de las baterías.

Explosion Warning, Read

OM, Starting Warning 101499

Hang Tags

HANG TAG DESCRIPTION PART NO.

1. Set select or switch to 200.

1. Mettez le sélec teur de changement sur 200.

1. Poner el inte rruptor select or a 200.

1979 -T-PR-A

NOTICE

AVISO

AVIS

NOTICE

AVISO

AVIS

THIS CHAMPION HSB GENERATOR is set up for a 50 /100A Select C ircuit ATS. If yo u are using this wi th a 200A Ser vice Entranc e

ATS model 10138 0, you will need to:

Failure to make correct changes may

damage gene rator or ATS and ma y

void warranty coverage.

Refer to INS TALLATI ON MANUAL

for further info.

La falta d e no hacer correc ciones puede da ñar

al generad or o al ATS y puede anul ar

la cobertura de la garantía.

Reﬁera al M ANUAL DE IN STALACI ÓN

para más información.

ATS Controlle r 100667

Pin 1, Pin 4, Pin 5, Pin 9 ON

ATS Controlle r 100667

Broche 1, Broche 4, Broche 5, Broche 9

ON (en marche)

Control del AT S 100667

Clavija 1, Clavija 4 , Clavija 5, Clav ija 9

ON (encendido)

Le fait de ne f aire aucune cor rection, peu t

endommager la génératice ou l’ATS et pe ut

entraîner la nullité de la couverture de garantie.

Reporte z-vous au MANU EL D’INSTA LLATION po ur

des information plus complètes.

CE GÉNÉR ATEUR CHAMPION HSB est mis en place pour un 5 0/100A circu it de selection AT S. Si vous utili sez cela avec un 20 0A

Servic e Entrée ATS modè le 101380, vous aur ez besoin de :

ESTÉ GENERADOR CHAMPION HSB está conﬁ gurado para un AT S de circuito se lecto de 50/10 0A. Si usted lo e stá utilizan do con

un ATS de entr ada de servic io de 200A, mo delo 101380, uste d necesitar á:

2. Change AT S controller pin se ttings as below.

2. Change r les paramètres des b roches du contr ôleur ATS

comme indiqué ci−dessous.

2. Cambia r las conﬁgurac iones de las clavija s del control del ATS

como en la par te de abajo.

200A Serv ice Entrance AT S

Production Setting.

200A servi ce entrée ATS

production réglage

Conﬁguración de producción del ATS de

entrada de ser vicio de 200 A

--- --- ---

ColorsLPN 197 9-T-PR

Rev A

Size 120 x 100 mm

Artwork Notes

2mm safe m argin; fron t and back; to be p rinted on

white substrate

Revision Changes

---

This artw ork belongs to Champio n Power Equipment. The c ontents are conﬁ dential and privileg ed and shall not be disclo sed to or used by or for

outside par ties without th e explicit consent of C hampion Power Equip ment.

2945

Service Entrance 1979-T-PR

1681-T- PR

 ATTENTION

ALTERNATE POWER SOURCE AVAILABLE -

STANDBY GENERATOR ON PREMISES.

 ATTENTION

AUTRE SOURCE DE COURANT DISPONIBLE -

GENERATEUR SUR SITE.

 ATENCIÓN

FUENTE DE CORRIENTE ALTERNA DISPONIBLE -

GENERADOR DE RESERVA EN EL SITIO.

GENERATOR LOCATION:

UBICACIÓN DEL GENERADOR:

EMPLACEMENT DU GENERATEUR:

DO NOT REMOVE \ NO REMUEVA \ NE PAS ENLEVER

W E

NNE

SW SSE

1681-T- PR

 ATTENTION

ALTERNATE POWER SOURCE AVAILABLE -

STANDBY GENERATOR ON PREMISES.

 ATTENTION

AUTRE SOURCE DE COURANT DISPONIBLE -

GENERATEUR SUR SITE.

 ATENCIÓN

FUENTE DE CORRIENTE ALTERNA DISPONIBLE -

GENERADOR DE RESERVA EN EL SITIO.

GENERATOR LOCATION:

UBICACIÓN DEL GENERADOR:

EMPLACEMENT DU GENERATEUR:

DO NOT REMOVE \ NO REMUEVA \ NE PAS ENLEVER

W E

NNE

SW SSE

FRONT BACK

K---------

ColorsLPN 168 1-T-OP

Rev --

Size 115 x 110 mm

Artwork Notes

2mm safe ma rgin; front a nd back; to be pr inted on

weather-resistant, white, synthetic substrate (PE/PP

mix)

Revision Changes

This artwor k belongs to Champion P ower Equipment. The co ntents are conﬁde ntial and privileged a nd shall not be disclos ed to or used by or for

outside part ies without the ex plicit consent of Ch ampion Power Equipme nt.

152

Alternate Power Source 1681-T-PR

100136 - 12.5-KW HOME STANDBY GENERATOR SAFETY LABELS AND HANG TAGS

C A

Safety label and Hang Tag locations

The safety labels have speciﬁc placement and must be replaced if they are unreadable, damaged or missing.

If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement.

A. Serial number location

B. Nameplate

C. NFPA 37 Compliance

D. Service Entrance hang tag

E. Connector assembly (behind panel)

F. Oil hang tag

G. Alternate power source (not shown – in the OM bag)

H. Flexible Fuel Line hang tag

100136 - 12.5-KW HOME STANDBY GENERATOR GENERAL INFORMATION

GENERAL INFORMATION

Component Identiﬁcation - 12.5-kW Generator

1. Exhaust System

2. Alternator

3. Air Inlet

4. Main Circuit Breaker

5. Hour Meter

6. Exercise Switch

7. ATS Control Module

8. Engine Control Module

9. Exterior Fault Code Indicator Light

10. Fuel Regulator/Wire Connections (behind panel)

11. Batteries (not included)

12. Engine

100136 - 12.5-KW HOME STANDBY GENERATOR GENERAL INFORMATION

Component Identiﬁcation – Engine

1. Engine Oil Dipstick

2. Air Cleaner

3. Oil Cap

4. Spark Plug (second on opposite side)

5. Oil Filter

Control Panel

MAIN CIRCUIT BREAKER

The 52-amp main circuit breaker protects the generator from

circuit overload. The main circuit breaker controls total output of

the generator.

ON OFF

MAIN CIRCUIT BREAKER

GENERATOR ON/OFF SWITCH

The exercise switch incorporates a built-in timer. The generator

will automatically perform an exercise period once every seven

days (168 hours). At the start of the exercise period, the engine

will start and run for 15 minutes. Load transfer from the generator

output will not occur unless the utility power is lost. When the

switch is in the OFF position, the exercise function is disabled.

Refer to Set Exercise Time to reset.

OFF

SET EXERCISE TIME

To set the exercise time, the engine control module switch must be

in the ATS mode. Decide on the desired day and time to exercise

the generator. Press the exercise switch to ON. The generator

will start and run for 15 minutes and then shut off. The exercise

time is now set. The generator will begin the next exercise period

exactly 168 hours from when the exercise switch was pressed to

the ON position.

If you choose to change the current exercise time setting, choose

the new day and time and cycle the exercise switch from off to on

and it will begin the cycle again.

The exercise time will have to be reset if:

• The battery was disconnected from the generator

• The switch was moved to the OFF position for maintenance

HOUR METER

The generator is equipped with an hour meter that will display the

generator actual run and exercise times.

ENGINE CONTROL MODULE

The engine control module contains the ATS/OFF/Manual mode

switch and the LEDs that indicate if a generator operation is being

performed or if there is an active alarm.

If the exterior fault code indicator light is on, open the enclosure

to view the engine control module. Determine what the fault code

is and remedy the situation or have the generator serviced by an

authorized Service Dealer or contact Champion Customer Service

at 1-877-338-0999.

100136 - 12.5-KW HOME STANDBY GENERATOR GENERAL INFORMATION

RESET FAULT CODE(S)

There is also an exterior fault code indicator light located on the

back of the enclosure. This should be checked weekly to make

sure there are no active fault codes.

The fault code(s) can be reset by placing the Engine Control

Module in the OFF position. This will reset fault LED, however if a

fault code(s) re-occurs it must be addressed.

APAGADO

ARRÊT

OFF

Manual

Manuel

Manual

ATS

Hz over/under / Hz plus / sous

Hz Más / Menos

Run / Marche

Funcionar

Power / Alimentation

Potencia

High engine temperature

Surchauffe moteur

Alta temperatura del motor

Low oil / Huile basse

Baja de aceite

Over crank

Surdémarrage

Sobre manivela

Exercise / Exercice /

Ejercicio

Low battery /

Batterie faible

Batería baja

MODE SWITCH

ATS – This position allows for fully automatic operation. If utility

power is lost, the generator will automatically start up. It also

allows the generator to automatically perform the exercise period.

OFF – This position shuts down the engine and prevents automatic

operation of the generator.

Manual – This position allows manual starting of the engine. Load

transfer from the generator output does not occur unless the utility

power is lost.

EXERCISE LED

The green LED will be ﬂashing when the HSB is performing the

weekly exercise cycle. When the exercise period has completed,

the LED will stay lit and the HSB will resume standby monitoring.

LOW BATTERY LED

The yellow LED will be lit if the battery voltage fell below 21.0 volts

for at least one minute while the engine was running. If battery

voltage rises above 21.1 volts, the LED will turn off. Battery

voltage is not monitored when cranking the engine.

HIGH ENGINE TEMP LED

The red LED will be lit if the engine operating temperature exceeds

the factory preset limits. If excessive operating temperature is

detected, the HSB will shut down and re-start will be disabled.

The RED LEDs on the module and enclosure exterior are lit.

This failure could be the result of an excessive load or high

ambient temperatures. Should this fault occur do the following;

1. Open the enclosure doors to increase air ﬂow throughout the

unit.

2. Check oil level, add oil if required.

3. Inspect the interior and exterior of the enclosure for debris,

leaves, ect., and remove them to increase air ﬂow around and

inside the unit.

4. Once the engine temperature falls into the normal operating

range, generally 30 minutes, follow the reset procedures in

the manuals speciﬁc to your model to clear and correct fault.

5. Close the enclosure doors and the unit is ready to run.

HZ OVER / UNDER SPEED LED

The red LED will be lit if the engine was operating above or below

its preset speed limit. The engine will shut down, and the LED will

remain lit until the generator is repaired and operating correctly.

Appliances connected to the generator circuit could be damaged

from high generator output if the engine is allowed to operate

above its preset limit. If this failure occurs, contact an authorized

Service Dealer or contact Champion Customer Service at

1-877-338-0999.

LOW OIL LED

The red LED will be lit if the engine oil level has dropped below

the safe operating level. When this happens, the engine will shut

down. Check the engine oil level before attempting to restart the

engine. The engine will not start until the problem is corrected.

OVER CRANK LED

The red LED will be lit if the engine tried to start but was unable to

start in the speciﬁed time period. The engine will try to start ﬁve

times and if unsuccessful the light will turn on. This may occur

on initial start-up, the fuel system needs to be fully pressurized to

start and operate. Follow reset procedure on page 16.

RUN LED

The green LED will be lit indicating the engine is running.

POWER LED

The green LED will be lit indicating the generator is working

correctly and loads can be connected to it.

100136 - 12.5-KW HOME STANDBY GENERATOR GENERAL INFORMATION

ATS CONTROL MODULE

The ATS control module contains the TEST/AUTO/OFF switch and

LEDs that indicate type of power delivery.

AUTO / AUTO / AUTOMÁTICO

OFF / ARRÊT / APAGADO

TEST / ESSAI / PRUEBA

UTILIDAD

UTILITÉ

UTILITY

CARGA

CHARGER

LOAD

GENSET

TEST/AUTO/OFF SWITCH

• TEST – This position allows veriﬁcation that the generator

power delivery circuit is functional. With the switch in

the TEST position, the engine will start and the ATS will

transfer. The GENSET LED, ATS LED (middle LED) and

LOAD LED should be lit, indicating the generator power

delivery circuit is functional.

• AUTO – This position allows automatic delivery of power

from the generator if there is a utility outage. With the

switch in the AUTO position and the engine not running, the

UTILITY LED, ATS LED (middle LED) and LOAD LED should

be lit, indicating the household is using utility provided

power.

• OFF – This position will not allow any power to be delivered

to the ATS when the engine is running.

FCC Statement

* Applicable in USA only.

1. This device complies with Part 15 of the FCC Rules. Operation

is subject to the following two conditions:

1a. This device may not cause harmful interference.

1b. This device must accept any interference received,

including interference that may cause undesired

operation.

2. Changes or modiﬁcations not expressly approved by the party

responsible for compliance could void the user’s authority to

operate the equipment.

 NOTICE

This equipment has been tested and found to comply with

the limits for a Class B digital device, pursuant to Part 15

of the FCC Rules. These limits are designed to provide

reasonable protection against harmful interference in a

residential installation. This equipment generates, uses and

can radiate radio frequency energy and if not installed and

used in accordance with the instructions, may cause harmful

interference to radio communications.

CAN ICES-002/NMB-002

* Applicable in Canada only.

This device complies with Industry Canada license - exempt RSS

standard(s).

Operation is subject to the following two conditions:

1. This device may not cause interference, and

2. This device must accept any interference, including

interference that may cause undesired operation of the

device.

100136 - 12.5-KW HOME STANDBY GENERATOR GENERAL INFORMATION

Battery Charger

The LEDs on the battery charger indicate the state of the battery’s

charge level. Battery charger rating 24 Vdc 1.6A.

NO CHARGE / PAS DE CHARGE /

SIN CARGA

AUTOMATIC BATTERY CHARGER /

CHARGE AUTOMATIQUE DE BATTERIE /

CARGADOR DE BATERÍA AUTOMÁTICO

Output: 24 Vdc 1.6 A

Producción: 24 V C.C. 1,6 A

Sortie : 24 V c.c. 1,6 A

Power: 80-125 Vac 1.0 A 50 / 60 Hz

Potencia: 80 - 125 V C.A. 1,0 A 50 / 60 Hz

Alimentation : 80-125 V c.a. 1,0 A 50 / 60 Hz

L N ADJ

E. O.

POWER / ALIMENTATION /

POTENCIA

OUTPUT / SORTIE /

PRODUCCIÓN

POWER

ALIMENTATION

POTENCIA

Conforms to UL

Std. 1236

RECOGNIZED

COMPONENT

For use with lead acid (LA/SLA), AGM, or Gel batteries. Not for use with Lithium-ion batteries.

Pour une utilisation avec des batteries au plomb-acide (LA/SLA), AGM ou gel. Ne pas utiliser

avec des batteries au lithium-ion.

Para uso con baterías de plomo ácido (LA/SLA), AGM o gel. No para uso con las baterías de iones de litio.

K109 485 REFLEX BLUE

ColorsAPN 2484-L-PR

Rev B

Size 76 x 75 mm

Artwork Notes

2mm safe margin;

to be printed on

White

substrate.

Revision Changes

---

This artwork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

Power Lit to indicate the battery is fully

charged.

Small Bar Lit to indicate the battery is receiving a

trickle charge

Middle Bar Lit to indicate current output is near

50%.

Large Bar Lit to indicate the charger is operating

above 50% capacity.

No Charge

Lit to indicate a battery charging

problem. If this LED is lit, the LED on

the Engine Controller module, “LOW

BATTERY” will also be lit.

Emission Requirements

This engine-powered generator meets all United States

Environmental Protection Agency (EPA) Phase 3 requirements and

is approved for use in both the USA and Canada.

This generator is certiﬁed to operate on pipeline NG and LPG

(vapor) fuel for use as a stationary engine for standby power

generation. Federal and/or local laws may be violated if it is used

for any other purpose.

The maintenance schedule must be followed to ensure that the

engine complies with the applicable emission standards for the

duration of the engine’s life.

 NOTICE

For Emission control devices and systems, read and

understand your responsibilities for service as stated in the

Emission Control Warranty Statement of this manual.

100136 - 12.5-KW HOME STANDBY GENERATOR GENERAL INFORMATION

Speciﬁcations

Home Standby Generator

Maximum continuous power, LPG 12.5 kW

Maximum continuous power, NG 11 kW

Rated voltage 120/240

Amps 104/52 LPG (propane), 91.6/45.8 NG (natural gas)

Harmonic distortion Less than 5%

Main line circuit breaker 52 amp

Phase Single

Frequency 60 Hz

Unit weight 425.5 lb. (193 kg)

Size (L x W x H) 49 x 28 x 28 in. (124.5 x 71 x 71 cm)

Engine

Type Milwaukee Series OHV Commercial V-Twin

No. of cylinders 2

Displacement 717 cc

Cylinder block Aluminum with cast iron sleeves

Ignition system Solid state – magneto

Spark plug F7RTC (NGK BPR7ES)

Governor Mechanical

Starter Electric 24V DC

Oil capacity 1.6 qt (1.5 L)

Oil Type 5W-30 Full Synthetic*

RPM 3600

Controls

Mode switch auto Auto start on utility failure

Mode switch manual Starts on demand

Mode switch off Stops unit/control and charger active

Ready to run/maintenance messages Standard

Programmable start delay Standard

Engine start sequence Standard

Starter lockout Standard

Battery charger/low battery indicator Standard

Charger fault Standard

AVR over voltage protection Standard

Low oil protection Standard

Safety fused Standard

Overcrank/overspeed/underspeed protection Standard

* Serial Number Y2308250001+: Unit comes with oil pre-ﬁlled in unit.

Serial Number < Y2308250001: Unit does not come with oil. You must ADD OIL before starting the unit.

* * After 5 hours, change oil per maintenance schedule. The recommended oil type for typical use is 5W-30 full synthetic oil. However, using the listed conventional oils

shown in the “Recommended Engine Oil Type” chart may be used for typical use. If running generator in extreme temperatures, refer to the “Recommended Engine Oil

Type” chart.