Gasmate BQ2047BL & BQ2047BLNG Owner's manual

FOR YOUR SAFETY

If you smell gas:

1. Shutothegastotheappliance.

2. Extinguishanyopename.

3. Ifodourcontinues,immediatelycall

yourgassupplier.

Donotstoreorusegasolineorotherammablevapour

andliquidsinthevicinityofthisoranyotherappliance.

Premium#304gradestainlesssteelorMattblacknish

FlameFailureDevice(FFD)foraddedsafety

Electronicignition

Satinenamelcastironhotplateandgrill

Convenientlidgivesyouextrabenchspace

whennotinuse

Stainlesssteelburners

Suppliedfullyassembled

GasCertiedtoAustralianStandards

SuitableforNaturalGasconversion

Important: Retain these instructions for future use.

0458011/23

Gasmate®isaregisteredtrademarkof

SitroGroupAustraliaPtyLtdwww.gasmate.com.au

AberLiving,N.Z.www.gasmate.co.nz

PHOENIX

DROPIN4BURNERBBQ

StainlessSteelModelNO.BQ2047,BQ2047NG,

BlackModelNO.BQ2047BL,BQ2047BLNG

FOR OUTDOOR USE ONLY

WARNING:

Improperinstallation,adjustment,alteration,serviceor

maintenancecancauseinjuryorpropertydamage.

Readtheinstructionsthoroughlybeforeinstallingor

servicingthisequipment.

WARNING! DO NOT USE AN ADAPTOR ON THE

CYLINDER CONNECTION

LCC27 REGULATOR SUPPLIED

(LPGORULPGMODELSONLY)

ThisLCC27Regulatorcanonlybeusedwith

thenewsaferindustrystandardLCC27Gas

CylinderConnection.

Gas Installation Codes

•Barbecuesmustbeusedinaccordancewiththe

installationrequirementsofyourgassupplyauthority,

ortheAustralianStandardAS5601.

•Barbecuesforusewithbottledgasarelabelled

‘propanegas’.

•Barbecuesforusewithnaturalgasarelabelled‘natural

gas’andmustbeinstalledbyanauthorisedperson.

Checkthegastypestickerattachedtothebarbecue.

Clearances

MinimumClearancesfromcombustiblematerialsmust

be:Rear-100mm,Sides-100mm,Above-1000mm

Hose & Regulator Safety

PropaneModel-Theregulatorandhoseassembly

suppliedwiththe‘PropaneGas’or‘UniversalL.P.G’.

barbecuesaresuitableforpropanegasonly.Agas

regulatoradjustedtohaveanoutletpressureof2.75kPA

issuppliedforconnectiontothepropanegascylinder.

Thepressureregulatorandhoseassemblysupplied

withthebarbecuemustbeused.Replacementpressure

regulatorsandhoseassembliesmustbethosespecied

bythebarbecuemanufacturer.

Whenconnectingthehoseandregulatorassemblytothe

gascylinder,takecaretoavoidunnecessarytwistingor

kinkingoftheexiblehose.

Aftertheassemblyhasbeensecured,turnonthegas

andcheckforleaksbybrushingasoapandwater

solutionoverallconnections.

Ifyouareunabletocorrecttheleakbytighteningthe

connections,turnothegasandcontactthesupplier

immediately.

Alwaysensurethebarbecueiskeptawayfromammable

GENERAL INFORMATION

materialsandthegascylinderclearofanyheatsource.

Whenchangingoverfromanemptygascylindertoa

fullonemakesurethisprocedureiscarriedoutinawell

ventilatedlocation,preferablyoutside,awayfrompeople

andawayfromanysourcesofignition;suchasnaked

ames,pilotames,electricheaters/equipment.

Specications

Barbecuespecicationscanbefoundonthe

datalabelattachedtothebarbecuebody.Hose

connectionthreadatgasinletis1/4”-BSP.

Gas Cylinder Use & Safety

Thisisalowpressurebarbecueandmustonlybeused

withthehoseandregulatorsupplied.Yourbarbecueis

designedforusewith9Kgpropanegascylinderscertied

toAS2469.

Thecylindershouldbelledbyareputablegassupplier

andvisuallyinspectedandre-qualiedateachlling.

Alwayskeepcylinderinanuprightposition.Alwaysclose

thecylindervalvewhenthebarbecueisnotinuse.

Donotsubjectthecylindertoexcessiveheat.

Never Store your Gas Cylinder Indoors.

Ifyoustoreyourbarbecueindoors,ALWAYSdisconnect

thecylinderrstandstoreitsafelyoutside.Cylinders

mustbestoredoutdoorsinawellventilatedareaoutof

reachofchildren,andmustnotbestoredinabuilding,

garageoranyotherenclosedarea.

Location of your Barbecue

DONOTuseyourbarbecueingarages,porches,sheds,

breezeways,orotherenclosedareas.Yourbarbecueisto

beusedOUTDOORS.Thebarbecueisnotintendedtobe

installedinoronrecreationalvehiclesand/orboatsand

shouldnotbeplacedunderanysurfacethatwillburn.Do

notobstructtheowofcombustionandventilationair

aroundthebarbecuehousing.

Check Barbecue for any Damage

Inspectbarbecuepartsasyouproceed.Contactyour

supplierforassistanceregardingreplacementofany

damagedormissingparts.Donotassembleoroperatea

barbecuethatappearsdamaged.Barbecuesforusewith

gascylindersarelabelled‘PropaneGas’or‘Universal

L.P.G’.Checklabellingatthegasconnectiononyour

barbecue.

Protect Children

Keepchildrenawayfrombarbecueduringuseanduntil

barbecuehascooledafteryouhavenished.Donot

allowchildrentooperatebarbecue.

Alwaysensurethatnosportingorphysicalactivitiesare

carriedoutincloseproximitytothebarbecueduringuse

andwhilestillhot.

IMPORTANT

Readtheseinstructioncarefullypriortouse.

Familiariseyourselfwiththeappliancebefore

connectingittoit’sgascontainer.Keepthese

instructionsforfuturereference.

If you smell gas

1.Shutogastothebarbecueatits

source,ifpossible.

2.Extinguishanyopename.

3.Openhood.

4.Ifodourcontinuesimmediatelycallyour

gassupplierorredepartment.

WARNING

Failuretocomplywiththeseinstructionscouldresult

inareorexplosionwhichcouldcauseseriousbodily

injury,deathorpropertydamage.

CAUTION: Accessible parts may be very hot.

•Keepyoungchildrenaway.

•DONOTmodifythisbarbecue.

•Donotmovethisbarbecueduringuse.

•Turnogassupplyatthecylinderafteruse.

•Readinstructionsbeforeusingthebarbecue.

•Partssealedbythemanufacturerortheiragent

mustnotbemanipulatedbytheuser.

•Thisbarbecueisonlytobeusedandstored

outdoors.

•Neveroperatethisbarbecuewithoutaregulator

•Donottestforgasleakswithanopename

•Ifthisinformationisnotfollowedexactly,a

recausingdeathorseriousinjurymayoccur.

Donotstoreasparegascylinderunderor

nearthisbarbecue.Neverllthecylinder

beyond80%full.Thisbarbecueisonlytobe

usedandstoredoutdoors.

•Ifthereisaleakonyourappliance(smellofgas

immediatelyattempttoturnothecylindervalve.

Removetheappliancetoawellventilatedlocation

awayfromanyignitionsource.Onlycheckforleaks

outdoorsusingsoapywater.DONOTtrytodetect

leaksusingaame.

•Checkforleaksbybrushingasoapandwater

solutionoverallconnections.Ifyouareunableto

correcttheleakbytighteningtheconnections,

turnothegasandcontactcustomerservice

immediately.

•Onlyusethehoseassemblyassuppliedwiththis

applianceforconnectiontothecylinder-DONOT

USEADAPTORS.

•Afteruseturnthegascylindervalveo,waitfor

theametogoout,thenturntheappliancecontrol

valveo.

•Donotconnectyourbarbecuetoagascylinder

exceeding9kgcapacity.

•Neverconnectanunregulatedgascylindertoyour

barbecue.

•Readcarefullybeforeassemblingandoperating

yourbarbecue.

FOR YOUR SAFETY

• Donotsprayareosolsinthevicinityofthis

appliancewhileitisinoperation.

•DonotuseorstoreammablematerialsInornear

thisappliance

•DonotplacearticalsonoragainstthisAppliance

•Donotmodifythisappliance.Avoidtwistingor

kinkingtheexiblehose.

•Donotstoreorusepetrolorotherammableliquids

inthevicinityofthisoranyotherappliance.

•Donotstoreemptyorfullsparegascylindersunder

ornearthisoranyotherappliance.

•Nevertestforgasleakswithalitmatchoropen

ame.Neverlightbarbecuewithhoodclosedor

beforecheckingtoensuretheburnertubesarefully

seatedovergasvalveorices.

•Neverleanovercookingsurfacewhenlighting.

•Neveralterormodifytheregulatororgassupply

assembly.

• Ensurethebarbecueissetuponalevelandstable

surface.

• Donotmovethebarbecuewhileinuseorwhenhot.

• Removethedriptraybeforemoving.

• Thebuilt-inbarbecuecannotbeinstalledwithan

overheadcombustiblesurface.

• Thebuilt-inbarbecuecanonlybeinstalledwithan

overheadsurfaceorgreaselterwithaminimumof

1200mmverticalclearance.

• Thisbarbecuemustnotbeusedindoors.

• Onlyuseinwellventilatedareas.

• CARBONMONOXIDEHAZARD-USINGTHIS

APPLIANCEINANENCLOSEDSPACEMAY

CAUSEDEATH.DONOTUSEINCARAVANS,

TENTS,MARINECRAFT,CARS,MOBILEHOMES

ORSIMILARLOCATIONS.

• DONOTinstallin,orconnecttotheconsumer

pipingorgassupplysystemofaboatorcaravan.

• Thisapplianceshallonlybeusedinanabove

groundopen-airsituationwithnaturalventilation,

withoutstagnantareas,wheregasleakageand

productsofcombustionarerapidlydispersedby

windandnaturalconvection.

• Ensurethebarbecueissetuponalevelandstable

surface.

• Donotmovethebarbecuewhileinuseorwhenhot.

Removethedriptraybeforemoving.

• DONOTreplacethegrillwithanextrahotplate.

Thewarrantywillbevoidedanditviolatesthegas

approval,thegrillprovidestheventilationneeded

fortheBBQtooperatesafely.Itisnotdesignedto

beasolidhotplatedevice.

IF THERE IS A LEAK

• Turnthecylindero.

• Ventilatetheareatodispersegas.

• Checkallconnections.

• Ifleakpersists,keepthecylinderupright.Keep

skinawayfromanygasorliquidescapingfromthe

cylinder.

• Keepthecylinderatleast20metresawayfrom

anysparksorignitionsources,includingelectrical

equipment,cameraashes,enginesandmotors.

• Dispersegasbyencouragingmaximumventilation

andsprayingwithanewaterspray.

IF THERE IS A FIRE

• Ifthereisatthebarbecue,turnthegasoatthe

cylinder.Smothertheameswithawetcloth,re

blanketorextinguishusingareextinguisher.

• Ifthereisatthecylinder,oryoucannotgettothe

valvetoturnthegaso,contacttherebrigade

immediately.

• Usingagardenhose,directthewatertothemiddle

ofthecylindertokeepitcool.Trynottoextinguish

theame.Atleastifthegasisburning,itwon’tbe

abletobuilduppressureandexplode.

GENERAL ASSEMBLY

Connecting & Disconnecting to the Gas Source

Familiariseyourselfwiththegeneralinformationand

safetyguidelineslocatedatthefrontofthismanual.

DO NOT USE AN ADAPTOR ON THE CYLINDER

CONNECTION

Check

1. Thecylinderislled.Asloshingsoundwillbeheard

whenshaken.

2. Theburnercontrolsareinthe‘OFF’position

Connecting

1. Ensurecylindervalveisinitsfulloposition.

2. Checkforanydamagetoeitherthecylinder

connectionorthehose.NEVERattempttouse

damagedequipment.

3. Whenconnectingthehosetothecylindertightenthe

nuttoapositivestopbyhand.

4. Opencylindervalvefully.Ifaleakcanbeheardat

eitherendofthehoseturncylinderoandtighten

joint.Wait5minutesbeforere-testingandusea

soapywatersolutiontocheckthejoint.Ifbubbles

appeartheconnectionwillneedtobere-tightened.

Disconnecting

1. Ensuretheburnercontrolisinthe‘OFF’position.

2. Ensurecylindervalveisinthefulloposition.

Forstorageandcylinderexchange,disconnecthose

atthecylinderonly,DONOTdisconnecthosefrom

appliance.

Disconnecting

1. Ensuretheburnercontrolisinthe‘OFF’position.

2. Ensurecylindervalveisinthefulloposition.

FOR STORAGE AND CYLINDER EXCHANGE,

DISCONNECT HOSE AT THE CYLINDER ONLY, DO

NOT DISCONNECT HOSE FROM APPLIANCE.

REMOVE TRANSIT PACKAGING MATERIAL

BEFORE USE.

IMPORTANT

•Donotsmokewhenattemptingtoignitethe

barbecue.

• Neverusevolcanicrock,heatbeadsorother

material.

•Alwaysuseprotectivegloveswhenhandlinghot

components.

• Note:Ifforsomereason,ignitorfailstoproduce

asparkattheelectrode,barbecuecanbelitbya

longbarbecuematch.Withthecoverremoved,lift

outthegrillplateandlightaburnerwithamatchor

lighter.Subsequentburnerswillcrosslight.

• Thelidmustbeintheopenpositionforlightingand

duringuse.

• Donotleavethebarbecueunattendedwhenalight.

• CleanyourbarbecueaftereachUSE.DONOTuse

abrasiveorammablecleaners,asitwilldamage

thepartsoftheproductandmaystartare.Clean

inwarmsoapywater.

•IMPORTANT:Beforeconnectinganddisconnecting

barbecuetogassource,makesureburnercontrols

arein‘OFF’position.

•CAUTION:Whenthebarbecueisnotinuse,thegas

mustbeturnedoatthecylinder

•Checkthatthesealsbetweentheapplianceand

thegascylinderareinplaceandingoodcondition

beforeconnectingthegascylinder

•Donotusethisapplianceifithasdamagedorworn

seals.

•CheckperformanceofburnerpriortoinstallingBBQ

plates.

LIGHTING PROCEDURE

Install and replace battery (4 Burner BBQ)

TheBBQisfeaturedwithelectronicignitionssystem,

whichispoweredbyoneAAbattery.

Toinstallorreplaceabattery,rotatetoremovethe

batterycover.Insertanewbatteryasbelowimage

shows,thenreplacethebatterycover.

NOTE:Ensurethebatteryhasbeenplacedinthecorrect

orientationasshown.

Burner Operation & Ignition System Check

1. OpentheLidofthebarbecuebeforeattemptingto

lighttheburners.

2. Turnthecontrolknobsclockwiseto“OFF”position.

3. Connecttheregulatortothegasbottle.Turnthegas

supply“ON”atthecylinder.Checkwiththeuseof

soapywaterforanygasleakagebetweenthebottle

andtheregulator.

4. Pushdownacontrolknobandkeeppressingwhilst

turninganti-clockwisetothe“HIGH”position(a

clickingsoundisheard).Continuetoholdthecontrol

knobfor10seconds(ThisistoensuretheFlame

FailureDevicetobeengaged).Releasethencheck

theamestayson.

5. Iftheburnerstilldoesnotlight,turnthecontrol

knobto‘OFF’wait5minutesandrepeatthelighting

procedure.

6. AdjusttheheatbyturningtheknobtotheHigh/Low

position.

7. Toturnthebarbecue‘OFF’,turnthecylindervalve

tothe‘OFF’positionandthenturnallofthecontrol

knobsontheapplianceclockwisetothe‘OFF’

position.

Problem Possible Reason Solution

Burnerwillnotignite

Valveoncylinderisclosed Openvalveoncylinder

Controlknobiso Turnknobtohighwhenlighting

Ignitionsystemnotworking Checkbattery-Thecontrolknobshouldhavea

clickingsoundwhenpressed

Burnerhasgoneout Checkthatthegasbottleisnotempty

Igniterisfaulty Usealongbarbecuematch

Flamenotstayingon

oncecontrolknobis

released

Controlknobnothelddownlong

enoughforFlameFailureDeviceto

engage

Repeatthelightingprocedureandholdcontrol

knobdownfor15seconds

Nominal Hourly Gas Consumption

Model No. Gas Type Number of Burners Injector Size

Total Gas

Consumption

MJ/h

Gas Pressure kPa

BQ2047

BQ2047BL ULPG

4 Ø1.05mm

54MJ/h 2.75kPa

MJ/hEach 13.5MJ/h

BQ2047NG

BQ2047BLNG

Natural

Gas

4 Ø1.80mm

54MJ/h 1.0kPa

MJ/hEach 13.5MJ/h

S.G.A.PtyLtd.33-35LionelRoad,Mt.Waverley,

Victoria3149,Australia.

FORCORRECTOPERATIONREFERTOINSTRUCTIONSPROVIDED.

A.G.A

Approval No.

AGA9058G

AGA9117G

LCC27 Regulator

& Hose

LCC27 Gas

Cylinder

(Cylinder

Not Included)

LCC27 Cylinder

Connection Device

Location of your Barbecue

DONOTuseyourbarbecueingarages,porches,sheds,

breezeways,orotherenclosedareas.Yourbarbecueis

tobeusedOUTDOORS.Thebarbecueisnotintended

tobeinstalledinoronrecreationalvehiclesand/orboats

andshouldnotbeplacedunderanysurfacethatwillburn.

Donotobstructtheowofcombustionandventilationair

aroundthebarbecuehousing.

Protect Children

Keepchildrenawayfrombarbecueduringuseanduntil

barbecuehascooledafteryouhavenished.Donotallow

childrentooperatebarbecue.

Alwaysensurethatnosportingorphysicalactivitiesare

carriedoutincloseproximitytothebarbecueduringuse

andwhilestillhot.

Tools You Will Need

Adjustablespanner,Phillipsheadscrewdriver.

Check Barbecue for any Damage

Inspectbarbecuepartsasyouproceed.Contactyour

supplierforassistanceregardingreplacementofany

damagedormissingparts.Donotassembleoroperate

abarbecuethatappearsdamaged.Barbecuesforuse

withgascylindersarelabelled‘PropaneGas’or‘Universal

L.P.G’.Checklabellingatthegasconnectiononyour

barbecue.

Aswithallappliances,propercareandmaintenancewill

keepthemintopoperatingconditionandprolongtheirlife.

Yournewgasbarbecueisnoexception.Byfollowingthese

cleaningproceduresonatimelybasis,yourbarbecuewill

bekeptcleanandworkingproperlywithminimumeort.

Cleaning the Cooking Surface

Aftercooking,turnburnercontrolto‘OFF’andletbarbecue

coolbeforeattemptingtocleanthecookingsurface.Before

rstuseandperiodically,itissuggestedthatyouwashthe

cookingsurfaceinamildsoapandwarmwatersolution.

Care of Cooking Surface

Useandcareofthecookingsurfaceisimportant.Donot

usepansonthecookingsurface.Donotoverheatthe

cookingsurfacewiththehooddownornofoodonthe

cookingsurface.

Cleaning the Drip Tray

Toavoidfatorgreasedrippingfromthebarbecueremove

andemptythedriptrayaftereachuse.Waituntilthedrip

trayiscooltotouchbeforedisposingofcontents.

Thedriptrayshouldbewashedperiodicallyinamild

detergentandwarmwatersolution.

General Cleaning of Painted Surface

WhencleaningyourBBQuseamilddishsoapcombined

withwarmwaterandamicroberclothtocleanthesurface.

ThenrinseyourBBQwithcleanwater.

Note:Neverusesteelwooloranyhardcleaningpadonany

paintedandstainlesssteelsurface,asitcancausesurface

damage.

Ifnotinuse,turnothegasfromthesource.Aftercleaning

andwhenitisdry,spraysomecanolaoiloverthewhole

BBQsurfaceandwipeotheexcesswithmicrobercloth

toenhancethesurfaceprotection.ThencovertheBBQwith

aBBQcoverandstoreitinadryplace.

CARE & MAINTENANCE CARE AND CLEANING OF

STAINLESS STEEL

Stainlesssteelpartsofthisappliancearemadefrom304

&430gradestainlesssteel.Topreservetheappearance

andcorrosionresistanceofthestainlesssteelmaterial

regularcleaningisrequired.Althoughstainlesssteel

doesnotrustinthesamemannerassteelitcanstill

exhibit‘corrosion’blemishesthatlooksimilartorustand

detractfromtheappliancesappearance.Unlikesteel,

thecorrosionofstainlesssteelismostlyconnedtothe

surfaceandinmostcasescanberemovedbycleaning,

returningthesurfacetoalmostlikenew.

Themostcommonformofcorrosionthataects

stainlesssteeliswhatisknownas‘TeaStaining”.This

showsupasbrownspotsonthesurface,hencethe

confusionwithrusting.Thisismostcommonincoastal

areasbutdependingontheenvironmentcanalso

occurininlandareas.Ifthe‘TeaStaining’marksarenot

regularlycleanedfromthematerialsurfacetheycan

penetrationintothematerialandbecomeverydicultto

remove,theapplicationofametalpolishwouldthenbe

required.

Iftheapplianceislocatednearswimmingpoolscareful

attentiontocleaningisrequired.Poolchemicalscontain

chlorideswhichcanaectthestainlesssteel.Thisalso

appliestosaltwaterpoolsastheycontainsalt,namely

sodiumchloride.

Theuseofbleachescontainingchlorineshouldnotbe

usedtocleanthestainlesssteelsurfaces.Iftheresidues

arenotcompletedrinsedawaytheycancauseheavy

pittingofthematerial.Pittingcorrosioneatsdeepinto

thesurfaceandisnoteasilyremoved.Heavypolishingis

required.

ROUTINE CARE

Aftereachuseallowtheappliancetocoolthenwipe

overwithasoft,damp,soapycloth.(DONOTUSE

CLEANERSCONTAININGCHLORIDE).Finallywipe

overwithsoft,dampcloth.Besuretowipeofood

particlesandcookingresidues,somemarinatesand

oilscanbeacidandthereforeattackthemetalsurface.

Also,cookingresiduesthatarenotremovedaftereach

usebakeintothesurfacesduringsubsequentusesand

becomemorediculttoremove.

Thereareanumberofproprietystainlesssteelcleaners

availablethatcanbesafelyusedonthisappliance.Read

thedirectionscarefullybeforeusing

DONOTUSESTEELWOOLasparticlescanbecome

embeddedinthesurfaceandthenrustresultinginsmall

brownspecsonthesurface.Ifscouringisrequiredto

removestubborncookingresiduesuseasoftnylonpad

(non-abrasive).

DONOTUSEABRASIVECLEANINGCOMPOUNDS,

usecreamtype.Iftheapplianceisusedonanirregular

basisitisadvisedtostillcleanregularlyandkeepit

coveredfromtheelements,eitherbyusingapurpose

BBQcoverorunderacoveredporch.Dirtanddust

containcorrosiveparticlesfromtheenvironmentthat

canattackthesurface.Stainlesssteelsurfacesretain

theirbestresistancetocorrosionwhenkeepclean.Even

iftheapplianceisprotectedwithapurposeBBQcover

checkregularly,condensationunderneaththecovermay

becorrosiveduetothelocalenvironmentandcause

damagetothemetalsurface.

6. Cleananyblockedportswithastiwiresuchasan

openpaperclip.

7. Checkburnerfordamage,duetonormalwearand

corrosionsomeholesmaybecomeenlarged.Ifany

largecracksorholesarefoundreplaceburner.

8. Carefullyretburners,ensuringtheyarelocatedon

thegasvalve.

9. Replaceclipattheendofburner.

10.Replacegreasetrayandcookinggrates.

WARNING

Bewareofspidersandwasps.Burnertubeshouldbe

inspectedandcleanedperiodically.

Toavoidanyare-ups,itisrecommendedthatthe

driptraybecheckedandemptiedregularly.Contents

ofthedriptraymaybeveryhotduringcooking.If

emptiedduringextendedcookingextremecaution

shouldbetakenanddirectcontactbyhandshould

beavoidedatalltimes.Allowtocoolcompletely

beforedisposingofthecontents.

Shouldtheburnersextinguishforanyreason,turno

allcontrolknobsandthecylindergasvalve.Wait5

minutesbeforeattemptingtorelighttheappliance.

Ifagreaseorfatreoccurs,turnoallcontrolknobs

andgascylindervalveimmediatelyuntilthereis

out.

Aleaktestmustbecarriedoutpriortousingthe

applianceforthersttimeoreachtimethegas

cylinderisrelledoreachtimethegashoseandgas

regulatorbeingdisconnectedfromthegascylinders

orappliance.

IMPORTANT:

Burner tubes

must re-engage

valve openings.

See image.

Aftercleaningapplyingathincoatingof‘lightoil’,for

examplebabyoil,willalsohelpprotectthestainlesssteel

surfacefromtheelements.

Stubborn Stains and Corrosion Spots

Stubbornstains,discolouration,‘TeaStaining’can

occurfrominsucientcleaning,excessivespillagefrom

cooking,severeenvironmentalconditionsandextreme

cookingconditions.

Thereareproprietystainlesssteelcleanersavailablethat

aredesignedforsuchinstances.Readtheinstructions

carefullybeforeusing.

• Alwaysruborwipeinthedirectionofthesurfacegrain

 ororiginalpolishlines.

• Somestainlesssteelcleanersmaydamagepaintedor

 plasticsurfaces,readthedirectionscarefully.

Flash-Back

Spidersandsmallinsectsoccasionallyspinwebsor

makenestsintheburnertubesduringwarehousingand

transit.Thesewebscanleadtoagasowobstruction

whichcouldresultinareinandaroundtheburner

tubes.Cleaningwithasoftbrushbeforeuseandatleast

everysixmonthsisrecommended.

Thistypeofreisknownas‘FLASH-BACK’andcan

causeseriousdamagetoyourbarbecueandcreatean

unsafeoperatingconditionfortheuser.Althoughan

obstructedburnertubeisnottheonlycauseof‘FLASH-

BACK’itisthemostcommoncauseandfrequent

inspectionandcleaningoftheburnertubesisnecessary.

Ifreoccursinandaroundtheburner,immediatelyturn

ogasatitssourceandturntheburnercontrolto‘OFF’,

waituntilthebarbecuehascooled,thencleantheburner

tubesandburnerports.

CLEANING THE BURNER

Followtheseinstructionstocleanand/orreplaceburners.

1. Turngasoatcontrolknobsandgascylinder.

2. Removecookinggratesandgreasetray.

3. Removeclipatendofburner.

4. Carefullylifteachburnerupandawayfromvalve

openings.

CAUTION:Inspectburnerforanydamage(cracksor

holes).Ifdamageisfound,replacewithanewburner.

Reinstalltheburner,checktoensurethatthegasvalve

oricesarecorrectlypositionedandsecuredinsidethe

burnerinlet.

Wesuggestthreewaystocleantheburnertubes.Use

theoneeasiestforyou.

(A)Bendastiwire(alightweightcoathangerworks

well)intoasmallhook.Runthehookthrougheach

burnertubeseveraltimes.

(B)Useanarrowbottlebrushwithaexiblehandle(DO

NOTuseabrasswirebrush),runthebrushthrough

eachburnertubeseveraltimes.

(C)Weareyeprotection:useanairhosetoforceairinto

theburnertubeandouttheairports.Checkeach

porttomakesureaircomesouteachhole.

5. Wirebrushentireoutersurfaceofburnertoremove

foodresidueanddirt.

PRODUCT DIMENSIONS

(FRONT/REAR VIEW)

(SIDE VIEW)

914mm

900mm

576mm

545mm

933mm

609mm

285mm

40mm FOOT HEIGHT ADJUSTMENT

259mm

(TOP VIEW)

933mm

609mm

VENTING VENTING

WARNING

Thisdrop-inBBQisdesignedtositushwiththe

bench.However,ifyouchoosetoinstalltheBBQontop

ofthestonebench,youneedtomakesurethelegsare

supportingtheBBQ.

Theappliancerequiresventing.WhentheBBQissitting

ushwiththebench,thereisanapproximate2mmgap

aroundtheBBQedgewiththebench.Thisgapplays

animportantroleofventing,therefore,itshouldnot

besealedwithsilicon.Ifyouchoose,however,toseal

thegap,arectangularunimpededopeningofapprox

750mmWx10mmHineitherthefrontortherear

shouldbeincorporatedwithinthecabinet.Pleaserefer

todiagrambelowasanexample.

916mm

580mm

BENCH CUT-OUT DIMENSIONS

936mm

612mm

The cutout size, when sitting the BBQ

ush with the stone bench

Feet Adjustment:

4adjustablefeetaresuppliedwiththeBBQ.Pleaseensure

all4feetareattachedtotheBBQforheightadjustment.If

youplantoinstallthedropinBBQinourAlfrecoPlusBBQ

cabinetmodule,pleaseadjustthefeetoftheBBQsothat

overallheightis290mm.AdjustthefeetoftheBBQsoall

edgessitush.Ifyouchoosetobuildyourowncabinet,

pleaseadjustthefeetheightaccordingly.

Drip tray access:

Pleasenotethatyoumustallowaccessunder

theBBQforthedriptraytoberemoved.

UNDER BENCH CLEARANCE:

150mm ALL AROUND SIDE WALLS OF BBQ

The cutout size, when sitting the BBQ

on top of the stone bench

SPACER BRACKETS

Twospacerbracketshavebeenprovided.TheyareessentiallyforcustomerswhomounttheirBBQintoadierenttypeof

cavity/cabinetry,where(unliketheAlfrescoPlusBBQmoduledesignedfortheBBQ)therearenodoorscoveringthefront

faceoftheBBQ-butjustacutouttoaccessthedriptray(880mmx50mm).

Inthatset-up,thedriptraycouldprotrudeoutfromtheBBQbutalignsupwiththecabinetfront.Thosebracketsessentially

justpushforwardthedriptray,forthattypeofset-up/cabinetry.

50mm

BENCH CUT-OUT DIMENSIONS

SPACER BRACKET INSTALLATION

UNDER BENCH CLEARANCE 150mm ALL AROUND SIDE WALLS OF BBQ

880mm

FAT TRAY

CUT OUT

DIMENSIONS

FAT TRAY

SPACER

BRACKET

LOCATION

100mm

From edge

GAS HOSE

CONNECTION

CUT OUT

100mmØ

BACK OF BBQ

CLOSE UP

INSTALLATION

CLOSE UP

INSTALLATION

DRIP TRAY

DRIP TRAY STOPS

2 x Drip Tray Spacer Brackets

(Left & Right Side)

1110

WARNING

•Improperinstallation,adjustment,alteration,serviceormaintenancecancauseinjury

orpropertydamage.

•Readtheinstructionsthoroughlybeforeinstallingorservicingthisequipment.

•THISAPPLIANCEMUSTNOTBEINSTALLEDORUSEDINDOORS.

•NATURALGASAPPLIANCE.TOBEINSTALLEDONLYBYANAUTHORISEDPERSON.

•THEAUTHORISEDPERSONWILLPROVIDEACERTIFICATEOFCOMPLIANCE.

•AnAGAapprovedhighownaturalgasregulatormustbeinstalledinthepipelineandbesetat1kPa.

NOTE: BBQ MUST BE TESTED. AND PRESSURE MUST BE 1KPA WITH ALL BURNERS RUNNING

NATURAL GAS CONVERSION

TO BE INSTALLED ONLY ON OR IN A NON-

COMBUSTIBLE ENCLOSURE

Note:Recommendedclearancesmustbemaintained.

GAS PIPING

1. Thisapplianceisonlytobeinstalledbyanauthorised

person.

2. Checkwithlocalandstateplumbingandheating

codesregardingsizingofthegaslines.

3. Allgaspipeconnectionsmustbesealedwithagas

pipecompoundresistanttoNaturalGas.

4. Installationofadriplegifrequiredinthegassupply

linemustconformtoAS5601.

5. Whencheckingforgasleaks,donotuseanopen

ame.Useasoapandwatersolutionandcheckfor

bubblesindicatinggasleakage.

6. Installationof1/8”NPTpluggedtapping,accessible

fortestgaugeconnections,isrequiredupstreamof

thegassupplyconnection.

WARNING

Improperinstallation,adjustment,alteration,serviceor

maintenancecancauseinjuryorpropertydamage.Read

theinstructionsthoroughlybeforeinstallingorservicing

thisequipment.

SERVICING INSTRUCTIONS

Appliancesshouldbeservicedatleastannuallyand

servicingmustonlybecarriedoutbyaLicensedPlumber

orAuthorisedPerson.

CleantheBurnerPortsandtopwithaSoftBrush.

Inspectandcleanallcombustionairinlets,thenreplace

theBurnerensuringitisrmlysecured.

Minimum Clearance for Ventilation:

Rear-50mmSide-50mm

NOTE TO THE INSTALLER:

Note:Fornaturalgasconversion,youneedtopurchase

thespecialNaturalGasValvewithbuilt-inFlameFailure

Device(FFD)fromyoursupplier.

Similarly,toconvertanaturalgasversionoftheBBQto

LPG,youneedpurchasethespecialLPGvalvewithbuilt-

inFFDfromyoursupplierfortheconversion.

TEST OPERATION OF APPLIANCE

BEFORE LEAVING.

PROVIDE A CERTIFICATE OF COMPLIANCE.

Conversion ONLY to be done by an authorised

Overall Dimensions

Length Width Height

BQ2047

BQ2047BL

BQ2047NG

BQ2047BLNG

933mm 609mm 265mm

1110

SAFE APPLIANCE LOCATIONS

Thisapplianceshallonlybeusedinanaboveground

open-airsituationwithnaturalventilation,without

stagnantareas,wheregasleakageandproductsof

combustionarerapidlydispersedbywindandnatural

convection.

Anyenclosureinwhichtheapplianceisusedshall

complywiththefollowing:

Anenclosurewithwallsonallsides,butatleastone

permanentopeningatgroundlevelandnooverhead

cover(seeExample1).

DIAGRAMMATIC REPRESENTATIONS OF OUTDOOR AREAS

Thefollowingguresarediagrammaticrepresentationsofoutdoorareas.Rectangularareashavebeenusedinthese

gures–thesameprinciplesapplytoanyothershapedarea.

Withinapartialenclosurethatincludesanoverhead

coverandnomorethantwowalls

(seeExample2&3).

Withinapartialenclosurethatincludesanoverhead

coverandmorethantwowalls,thefollowingwillapply:

atleast25%ofthetotalwallareaiscompletelyopen,

andatleast30%oftheremainingwallareaisopenand

unrestricted(seeExample4&5).

Inthecaseofbalconies,atleast20%ofthetotalwall

areashallbeandremainopenandunrestricted.

1212

For any queries or assistance call

Customer Service

(AustraliaOnly)

1300 174 876

Hoursofoperation:

MondaytoFriday8am-5pmEST

Do not return to place of purchase.

Keepyourpurchasereceipt,thiswillberequiredto

makeanyclaimsunderthe5yearwarranty.

Before any work/modication is done on/to this

product please refer to the link to the SDS for

your personal protection requirements.

https://sitro.com.au/support/sds/

Gasmate BQ2047BL & BQ2047BLNG Owner's manual

Related papers

Other documents