Cres Cor H135UA11J1 Operating instructions

Cres Cor
Brand
Cres Cor
Model
H135UA11J1
Category
Car kits
Type
Operating instructions
5925 Heisley Road • Mentor, OH 44060-1833
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H135UA11-J Series Hot Cabinet
Hot Cabinets
FL-2328-J
Rev. 1 (3/07) Page 1 of 4
Model No. Volts Watts Amps Hertz Phase NEMA
H135UA11J1 100 1400 14 50/60 1 5-15P
Designed for AC service.
CONTROL PANEL PARTS IDENTIFICATION
1. Power Switch
2. Yellow Light-Power
3. Thermostat
4. Thermometer
HOW TO INSTALL UNIT:
Place cabinet near warm ovens. Do NOT put in
drafty areas or near ventilating systems.
Plug cord end into proper wall outlet.
1.
2.
HOW TO START UNIT:
Turn the POWER switch on. The yellow light will
turn on.
Turn thermostat to #10.
Preheat cabinet for 30 minutes.
Put food into cabinet.
Turn thermostat to #8 and close door.
1.
2.
3.
4.
5.
NOTE: No. 8 setting = approx. 88°C (190°F)
No.6 setting = approx. 74°C (165°F)
Proper food holing temperature is 60°C (140°F) or
higher. The thermometer shows the temperature inside.
TO TURN OFF UNIT:
Turn thermostat off.
Turn the POWER switch off.
The yellow light will go out.
1.
2.
3.
5925 Heisley Road • Mentor, OH 44060-1833
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H135UA11-J Series Hot Cabinet
Hot Cabinets
FL-2328-J
Rev. 1 (3/07) Page 2 of 4
MAINTENANCE
HOT UNIT REMOVAL INSTRUCTIONS:
Unplug power cord from wall outlet.
Pull entire unit out the front of the cabinet.
1.
2.
HOW TO CLEAN THE UNIT:
SOIL CLEANER METHOD
DOOR
and
CABINET
Inside and
Outside
(Aluminum)
DIRT
Mild detergent* and hot water, or mild
abrasive cleaner.
1. Use soft, damp cloth.
2. Rinse with hot water.
3. Wipe dry.
Steam (no strong alkaline additive)
1. Rinse after steam cleaning.
2. Wipe dry.
FINGERPRINTS,
GREASE OIL
Chemical oven cleaner for aluminum.
Follow oven cleaner
manufacturer’s directions.
Mild abrasive cleaner;
oily or waxy cleaner.
Apply with soft, clean cloth.
WATER SPOTS Mild abrasive cleaner.
1. Wipe with damp cloth.
2. Rinse and dry.
* Mild detergents include soaps and non-abrasive cleaners
Cleaning Notes:
Wipe up spills as soon as possible.
Clean cabinet regularly to avoid heavy dirt build-up.
Make a test spot with cleaner.
Follow manufacturer’s directions on cleaner.
Do not mix cleaners.
Avoid drips and splashes.
1.
2.
3.
4.
5.
6.
Allow cabinet to cool.
Remove Hot unit from cabinet.
Do NOT use abrasives or harsh
chemicals.
1.
2.
3.
HOW TO CLEAN THE CABINET:
BEFORE cleaning
the cabinet:
5925 Heisley Road • Mentor, OH 44060-1833
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H135UA11-J Series Hot Cabinet
Hot Cabinets
FL-2328-J
Rev. 1 (3/07) Page 3 of 4
TROUBLE-SHOOTING CHART:
FAILURE POSSIBLE CAUSE
1. Yellow light at switch does NOT light
1a. Circuit breaker/fuse to wall outlet is blown.
1b. Cord is unplugged from wall outlet.
1c. Switch is “OFF”.
2. Unit does not heat.
2a. Thermostat set too low or is “OFF”.
2b. Switch is “OFF”.
3. Unit gets too hot or won’t shut off. 3a. Defective electrical parts. UNPLUG UNIT
FROM WALL OUTLET.
4. Blower does not work or make noise. 4a. Defective blower.
If cause is none of the above, refer to our list of Authorized Service Centers, FL-1400.
REPLACEMENT PARTS:
DESCRIPTION 120 VOLT
Hot Unit HU1254058J
Blower Kit 0769-005-K
Heater Kit 0811-022
Thermostat Kit 0848-062-K
Thermometer Kit (Analog) 5238-030-K
Power Cord 0810-171
Power Switch 0808-116
Pilot Light 0766-094
Terminal Block 0852-091
CABINET
Door Latch 1006-154-01
Door Hinge 0519-104
Pan Slides 0621-181
Door Assembly 1200-495-BL
Door Gasket 0861-234
5925 Heisley Road • Mentor, OH 44060-1833
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H135UA11-J Series Hot Cabinet
Hot Cabinets
FL-2328-J
Rev. 1 (3/07) Page 4 of 4
WIRING DIAGRAM:
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4

Cres Cor H135UA11J1 Operating instructions

Cres Cor
Brand
Cres Cor
Model
H135UA11J1
Category
Car kits
Type
Operating instructions
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers